Electrical SystemEngine And Engine CoolingFuel System, Gasoline
BOTH OUTSIDE MIRRORS HAVE FALLEN OFF BEFORE 90K MILES. THIS WAS DUE TO THE PLASTIC DETERIORATING AT THE JUNCTION WHERE THE MIRROR "FOLDS AWAY." REPLACED EGR VALVE SEVERAL TIMES. THE FIRST THREE WERE UNDER WARRANTY, THE REST HAVE BEEN ON ME. IN ADDITION, MOST MAJOR FUEL SYSTEM COMPONENTS HAVE BEEN REPLACED, OR REPAIRED. THE …
Read full complaint
BOTH OUTSIDE MIRRORS HAVE FALLEN OFF BEFORE 90K MILES. THIS WAS DUE TO THE PLASTIC DETERIORATING AT THE JUNCTION WHERE THE MIRROR "FOLDS AWAY." REPLACED EGR VALVE SEVERAL TIMES. THE FIRST THREE WERE UNDER WARRANTY, THE REST HAVE BEEN ON ME. IN ADDITION, MOST MAJOR FUEL SYSTEM COMPONENTS HAVE BEEN REPLACED, OR REPAIRED. THE IDLE HAS ALWAYS BEEN ROUGH, AND IT WILL ON OCCASION, SMOKE AND OMIT STRONG ODORS OF UNBURNED FUEL. WIPERS FAILED AT 20K MILES. I RESOLDERED THE CIRCUIT BOARD TO CORRECT THE PROBLEM. DRIVERS SEAT WILL NOT STAY IN A LOCKED POSITION, WHICH CAUSES ME SOME CONCERN. BY THE WAY, THE FIRST WEEK I HAD THE CAR (BOUGHT IT NEW), THE SEAT WOULD NOT STAY LOCKED. TOOK IT TO THE DEALER, AND WAS PROMPTLY TOLD THAT "IT IS A NORMAL CONDITION." HMMM, AS A DESIGN ENGINEER I HAVE TO WONDER ABOUT THE LOGIC BEHIND THIS; AS ANY FORWARD OR REARWARD IMPACT WOULD ALLOW THE SEAT TO FLEX WHICH COULD MAKE A MINOR NON-INJURY ACCIDENT SOMETHING FAR WORSE. THE WATER PUMP HAS BEEN REPLACED THREE TIMES, ALTERNATOR TWICE, BATTERY FIVE. ALL PARTS WERE REPLACED WITH ORIGINAL PARTS THROUGH GM. I HAVE HAD ALL BRAKE COMPONENTS REPLACED THREE TIMES, AND STILL THERE IS A PAINFUL CHATTER OF THE PEDAL UNDER CERTAIN CONDITIONS, WHICH IS OUTSIDE THE ABS PARAMETERS. WIND NOISE IS QUITE LOUD, AS THE FIT OF THE DRIVERS SIDE DOOR IS, FOR LACK OF A BETTER WORD, TERRIBLE. THE PLASTIC WHICH COVERS THE A/C WITHIN THE ENGINE COMPARTMENT HAS DETERIORATED TO THE POINT WHERE IT HAS BROKEN AND FALLEN AWAY, PIECE BY PIECE, SOMETIMES LODGING ITSELF ON THE EXHAUST MANIFOLD, CAUSING SOME RATHER UNPLEASANT ODORS. OH, AND SINCE THERE IS NO LONGER ANY COVERING OVER THE A/C, IT GOES WITHOUT SAYING THAT THE COLDNESS, WHICH WAS THE SAVING GRACE OF THIS VEHICLE, HAS BEEN REDUCED TO THAT OF A GLORIFIED FAN. *NM
NHTSA ODI #10168470
Mileage unknown · Sep 10, 2002
Engine And Engine CoolingFuel System, Gasoline
WHEN GAS TANK IS NEAR EMPTY AND ENGINE DIES WHILE TRAVELING DOWNHILL AT A 15 DEGREE SLOPE OR GREATER. CONSUMER VERY CONCERNED ABOUT SAFETY DUE TO HILLS IN AREA BEING VERY STEEP,AND VEHICLE STALLING.*AK
NHTSA ODI #8018362
Mileage unknown · Aug 27, 2002
Fuel System, Gasoline
THE CPI UNIT WAS SRAYING GAS DIRECTLY INTO THE ENGINE. THERE ARE OTHER REPORTS OF THIS ON THE INTERNET. IT IS A FIRE HAZARD!. *AK
NHTSA ODI #766275
Mileage unknown · May 31, 2002
Fuel System, Gasoline
INJECTOR BOX DOESN'T SHUT FUEL OFF WNEN PRESSURE BUILDS. THEREFORE, A PULL OF GAS IS LAYING ON INTAKE MANIFOLD. WITH HEAT AND GAS VEHICLE COULD EXPLODE WITH PASSENGERS INSIDE. TOOK VEHICLETO A MECHANIC, AND THEY ARE FAMILIAR WITH PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8010840
Mileage unknown · May 20, 2002
Fuel System, Gasoline
FUEL PUMP HAS FAILED AND HAS BEEN REPLACED THREE TIMES, 5016 MILES, 20426 MILES AND 40250 MILES. NLM
NHTSA ODI #566895
Mileage unknown · May 3, 2002
Fuel System, Gasoline
FUEL INJECTION SYSTEM IS LEAKING OIL ONTO THE MOTOR.*AK
NHTSA ODI #8009167
Mileage unknown · Oct 2, 2001
Electrical SystemEngine And Engine CoolingEquipment
THE MAIN COMPUTER HAS FAILED TWICE CAUSING THE VEHICLE TO DRIVE POOR AND IDLE ROUGHLY. NLM
NHTSA ODI #563526
Mileage unknown · Sep 26, 2001
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
VEHICLE RAN ROUGH AND STALLED. ENGINE LIGHT CAME ON WHEN SITTING STILL. PROBLEM HAS BEEN SINCE 1996. EGR VALVE HAS BEEN REPLACED 4 TIMES AND CLEANED ONCE. MANUFACTURER SENT A WARRANTY LETTER OUT FOR SERVICE REGARDING THE EGR VALVE, HOWEVER CONSUMER NEVER RECEIVED THE ORIGINAL. *AK *YH
NHTSA ODI #896859
Mileage unknown · Sep 10, 2001
Fuel System, GasolineService Brakes, Hydraulic
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #752004
Mileage unknown · Jul 5, 2001
Engine And Engine CoolingFuel System, GasolineUnknown Or Other
VEHICLE HAS A FUEL BURNING SMELL. ENGINE CHECK LIGHT IS ON, AND THERE IS A CLANKING SOUND. DEALER REPLACED CATALYTIC CONVERTER, DID NOT REMEDY PROBLEM. AT THIS TIME DEALER INFORMED CONSUMER FUEL INJECTION SYSTEM NEEDED TO BE REPLACED.*AK
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1995 GMC Jimmy Problems, Complaints & Recalls | Skip That Year
Illustration