IllustrationFIRE UNDER THE HOOD STARTED, ENTIRE CAR BURNED IN DRIVEWAY, DAMAGING HOUSE AND A SECOND CAR
2008 GMC Envoy
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 GMC Envoy do not stand out strongly from the model-year median of 22.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
1125–50K
1050–75K
875–100K
15100–150K
9150K+
59 reports with mileage · 18 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports4 fire reports4 injury reports
Unknown Or Other complaints
5 reportsMY VEHICLE JUST SUDDENLY STOPPED DEAD, IN THE ROAD AFTER LEAVING MY RESIDENCE AND ALL CONTROL WAS LOST. UNABLE TO PUT TRANSMISSION IN NEUTRAL TO PUSH VEHICLE OFF ROAD. I HAD IT REPAIRED BY A TRAINED MECHANIC AND WAS TOLD IT WAS A FAULTY IGNITION. I HAD THE FAULTY IGNITION REPLACED AND THE VEHICLE WAS OPERATIONAL AGAIN ALONG WITH…
Read full complaint
MY VEHICLE JUST SUDDENLY STOPPED DEAD, IN THE ROAD AFTER LEAVING MY RESIDENCE AND ALL CONTROL WAS LOST. UNABLE TO PUT TRANSMISSION IN NEUTRAL TO PUSH VEHICLE OFF ROAD. I HAD IT REPAIRED BY A TRAINED MECHANIC AND WAS TOLD IT WAS A FAULTY IGNITION. I HAD THE FAULTY IGNITION REPLACED AND THE VEHICLE WAS OPERATIONAL AGAIN ALONG WITH THE WORRY OF THIS HAPPENING AGAIN.
02.05.2018 -- WAS AT A SUPERBOWL PARTY AND MY CAR WAS PARKED FOR 5 HOURS OUTSIDE, IT WAS ABOUT 20 DEGREES. HAD A 10 MINUTE DRIVE HOME - PARKED CAR IN GARAGE AND SHUT THE GARAGE DOOR. WHILE DRIVING, I DID USE REAR DEFROSTER AND WIPER BLADE, AS THERE WAS SNOW ON BACK WINDOW AND IT WAS SNOWING. APPROXIMATELY 15 MINUTES AFTER PARKI…
Read full complaint
02.05.2018 -- WAS AT A SUPERBOWL PARTY AND MY CAR WAS PARKED FOR 5 HOURS OUTSIDE, IT WAS ABOUT 20 DEGREES. HAD A 10 MINUTE DRIVE HOME - PARKED CAR IN GARAGE AND SHUT THE GARAGE DOOR. WHILE DRIVING, I DID USE REAR DEFROSTER AND WIPER BLADE, AS THERE WAS SNOW ON BACK WINDOW AND IT WAS SNOWING. APPROXIMATELY 15 MINUTES AFTER PARKING THE VEHICLE,I HEARD A LOUD BLAST, LIKE SOMEONE DROVE THROUGH MY GARAGE DOOR. THE REAR WINDOW OF MY GMC ENVOY EXPLODED INTO MANY PIECES. GLASS WAS INSIDE AND OUTSIDE THE VEHICLE. MY GARAGE IS NOT HEATED. I HAVE NO IDEA HOW IT HAPPENED. I CALLED MY INSURANCE COMPANY IMMEDIATELY AND AM GOING TO DRIVE THE CAR TO A GMC DEALERSHIP TO HAVE IT FIXED.
I WAS DRIVING THE SUV ON THE FREEWAY WHEN A FIRE STARTED UNDER THE HOOD. I CAME OFF THE FREEWAY AND WATCHED ENVOY BECOME COMPLETELY ENGULFED IN FLAMES AS FIRE DEPARTMENT WORK TO PUT IT OUT. VEHICLE COMPLETELY DESTROYED. NO KNOWN ISSUES WITH VEHICLE PRIOR TO ITS INFERNO MOMENT.
I PUT THE CAR IN PARK AND SHUT THE VEHICLE OFF AND PULLED THE KEY OUT OF THE IGNITION. THE CAR REMAINED RUNNING WITH THE KEY OUT AND IN ORDER TO SHUT IT OFF WE HAD TO POP THE HOOD AND PULL OUT A RELAY. WE THEN TRIED RESTARTING THE CAR AND IT STARTED WITH THE KEY TURNED BACKWARDS. IT WASN'T DRIVEABLE AT THIS TIME BECAUSE IT WAS S…
Read full complaint
I PUT THE CAR IN PARK AND SHUT THE VEHICLE OFF AND PULLED THE KEY OUT OF THE IGNITION. THE CAR REMAINED RUNNING WITH THE KEY OUT AND IN ORDER TO SHUT IT OFF WE HAD TO POP THE HOOD AND PULL OUT A RELAY. WE THEN TRIED RESTARTING THE CAR AND IT STARTED WITH THE KEY TURNED BACKWARDS. IT WASN'T DRIVEABLE AT THIS TIME BECAUSE IT WAS SPITTING AND SPUTTERING. WE REPLACED THE IGNITION SWITCH AND IT WAS WORKING FOR A FEW DAYS AND NOW ITS BACK TO DOING THE SAME THING.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.