TL*THE CONTACT OWNS A 2005 GMC ENVOY. WHILE THE VEHICLE WAS PARKED A WARNING SOUND BEGAN TO INDICATE TO THE CONTACT THAT THE FUEL TANK WAS EMPTY AND THE FUEL GAUGE READING INDICATED THAT THE FUEL TANK WAS EMPTY. THE CONTACT STATED THE FUEL WAS ADDED TO THE VEHICLE BEFORE THE FAILURE OCCURRED. THE FUEL INDICATOR ALSO DISPLAYED…
Read full complaint
TL*THE CONTACT OWNS A 2005 GMC ENVOY. WHILE THE VEHICLE WAS PARKED A WARNING SOUND BEGAN TO INDICATE TO THE CONTACT THAT THE FUEL TANK WAS EMPTY AND THE FUEL GAUGE READING INDICATED THAT THE FUEL TANK WAS EMPTY. THE CONTACT STATED THE FUEL WAS ADDED TO THE VEHICLE BEFORE THE FAILURE OCCURRED. THE FUEL INDICATOR ALSO DISPLAYED A READING THAT FLUCTUATES AND DOES NOT SHOW THE ACCURATE AMOUNT OF FUEL IN THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER WAS CONTACTED AND STATED THE FUEL LEVEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: DP10001 (FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10405326
96,000 miles · May 27, 2011
Fuel System, Gasoline
I HAVE A 2005 GMC ENVOY AND THE GAS LIGHT AND FUEL TANK GAUGE ARE MALFUNCTIONING. WHEN WE FILL UP WITH GAS THE EMPTY GAS REMAINS ON FOR SEVERAL MINUTES AND THEN ONLY MOVES TO 1/4 OF A FULL TANK. LATER IT WILL MOVE UP, BUT WILL DRIVING IT WILL JUST DROP TO EMPTY. *TR
NHTSA ODI #10403612
19,000 miles · May 12, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE FAILED. THE CONTACT RAN OUT OF GAS WHILE THE FUEL GAUGE DISPLAYED INACCURATELY THAT THE FUEL TANK WAS HALF FULL BUT WAS ACTUALLY EMPTY. THE CONTACTS MECHANIC INSPECTED THE VEHICLE AND ADVISED THAT THE TANK AND SENSOR WOULD NEED TO BE REPLACED. THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE FAILED. THE CONTACT RAN OUT OF GAS WHILE THE FUEL GAUGE DISPLAYED INACCURATELY THAT THE FUEL TANK WAS HALF FULL BUT WAS ACTUALLY EMPTY. THE CONTACTS MECHANIC INSPECTED THE VEHICLE AND ADVISED THAT THE TANK AND SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 19,000 AND THE CURRENT MILEAGE WAS 31,000.
NHTSA ODI #10400680
Mileage unknown · May 10, 2011
Fuel System, Gasoline
THE GAS GAUGE IS MALFUNCTIONING IN MY 2005 GMC ENVOY (VIN # [XXX]) WHEREAS IT DOES NOT REGISTER THE CORRECT AMOUNT OF GASOLINE.....I CAN FILL IT COMPLETELY UP AND IT WILL SHOW PAST THE EMPTY MARK AND OTHER TIMES IT WILL SHOW 1/4 TANK RIGHT AFTER I FILL UP. I HAVE RAN OUT OF GAS 3X (FORTUNATELY NOT ON A BUSY THOROUGHFARE), BUT T…
Read full complaint
THE GAS GAUGE IS MALFUNCTIONING IN MY 2005 GMC ENVOY (VIN # [XXX]) WHEREAS IT DOES NOT REGISTER THE CORRECT AMOUNT OF GASOLINE.....I CAN FILL IT COMPLETELY UP AND IT WILL SHOW PAST THE EMPTY MARK AND OTHER TIMES IT WILL SHOW 1/4 TANK RIGHT AFTER I FILL UP. I HAVE RAN OUT OF GAS 3X (FORTUNATELY NOT ON A BUSY THOROUGHFARE), BUT THIS CAN BE EXTREMELY DANGEROUS NOT EVER KNOWING FOR CERTAIN HOW MUCH GAS I HAVE IN MY TANK OR NOT. IT IS SO ANNOYING AND FRUSTRATING AND NOT ONLY THAT BUT MY GAS GAUGE 'DINGS' OFF AND ON ALL THE TIME INDICATING THAT I AM LOW ON FUEL EVEN AFTER I HAVE FILLED THE VEHICLE UP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
NHTSA ODI #10399807
40,631 miles · May 9, 2011
Fuel System, Gasoline
A FUEL GAUGE STOPPED WORKING. I HAD TO PAY TO HAVE THE GMC DEALER REPLACE THE FUEL LEVEL SENSOR.
NHTSA ODI #10400363
47,000 miles · May 9, 2011
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED AFTER REFUELING, THE FUEL GAUGE DISPLAYED A READING OF EMPTY. THE VEHICLE WOULD ALSO PERFORM AS IF IT WERE GOING TO STALL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT M…
Read full complaint
TL*THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED AFTER REFUELING, THE FUEL GAUGE DISPLAYED A READING OF EMPTY. THE VEHICLE WOULD ALSO PERFORM AS IF IT WERE GOING TO STALL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 47,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10399563
66,000 miles · May 9, 2011
Electrical SystemFuel System, Gasoline
TL*THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED AFTER REFUELING THE FUEL TANK TO THE FULL CAPACITY LEVEL, THE FUEL GAUGE WOULD REGISTER AN EMPTY FUEL TANK. THE INACCURATE READING WAS CONSISTENT. THE INDEPENDENT MECHANIC WAS NOTIFIED OF THE FAULTY FUEL TANK AND THEY ADVISED THAT THE VEHICLE BE TAKEN IN FOR DIAGNOSIS. T…
Read full complaint
TL*THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED AFTER REFUELING THE FUEL TANK TO THE FULL CAPACITY LEVEL, THE FUEL GAUGE WOULD REGISTER AN EMPTY FUEL TANK. THE INACCURATE READING WAS CONSISTENT. THE INDEPENDENT MECHANIC WAS NOTIFIED OF THE FAULTY FUEL TANK AND THEY ADVISED THAT THE VEHICLE BE TAKEN IN FOR DIAGNOSIS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000. UPDATED 06/17/11 *BF UPDATED 06/30/11
NHTSA ODI #10399533
70,000 miles · May 6, 2011
Electrical SystemFuel System, Gasoline
FUEL GAUGE DOES NOT WORK CORRECTLY. THE READING ON THE FUEL GAUGE DOES NOT REFLECT THE AMOUNT OF GAS IN THE TANK. GAUGE MOSTLY READS EMPTY EVEN AFTER FILLING UP. SOMETIMES IT WILL SHOW THERE IS MORE GAS THAN IS ACTUALLY IN THE TANK.
NHTSA ODI #10400179
75,000 miles · May 6, 2011
Fuel System, Gasoline
GAS GAUGE DOES NOT WORK. *TR
NHTSA ODI #10399321
50,000 miles · May 5, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED AND WOULD NOT MOVE WHETHER THE FUEL TANK WAS EMPTY OR FULL TO CAPACITY. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR REPAIRS OR DIAGNOSTIC TESTING. THE CONTACT STATED THAT THE FAULTY FUEL GAUGE COULD POTENTIALLY CAUSE THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2005 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED AND WOULD NOT MOVE WHETHER THE FUEL TANK WAS EMPTY OR FULL TO CAPACITY. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR REPAIRS OR DIAGNOSTIC TESTING. THE CONTACT STATED THAT THE FAULTY FUEL GAUGE COULD POTENTIALLY CAUSE THE VEHICLE TO RUN OUT OF FUEL WITHOUT KNOWING AND COULD CAUSE A CRASH. THE FAILURE MILEAGE WAS 50,000.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
Consequence & remedy
Consequence: IF A CRASH OCCURS, THE WINDSHIELD MAY NOT BE RETAINED, INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON MARCH 10, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
2005 GMC Envoy Problems, Complaints & Recalls | Skip That Year
Illustration