IllustrationTHERE IS A MALFUNCTION IN CONSUMER GMC ENVOY POWER TRAIN CONTROL MODULE RESULTING IN FAILURE TO ACCELERATE. *TS *JB
2004 GMC Envoy
Owner reports · Recalls · Investigations
More warning signs than most Envoy years
Owner complaints for the 2004 GMC Envoy are substantially higher than the model-year median of 22.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
4125–50K
7850–75K
4775–100K
52100–150K
41150K+
288 reports with mileage · 79 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports11 fire reports22 injury reports
Power Train complaints
15 reports2004 GMC ENVOY DEVELOPED THE FOLLOWING PROBLEMS: VEHICLE STALLED, TURN SIGNALS STOPPED WORKING, BLOWER FAN STOPPED WORKING, AND THE SRS LIGHT REMAINS LIT.*MR THE TURN SIGANLS STOPPED WORKING DUE TO A SHORT IN THE FLASHER. THE POWERTRAIN CONTROL MODULE WAS REPLACED DUE TO THE SES LIGHT ILUMINATING. THE BLOWER MOTOR FAN FAILED …
Read full complaint
2004 GMC ENVOY DEVELOPED THE FOLLOWING PROBLEMS: VEHICLE STALLED, TURN SIGNALS STOPPED WORKING, BLOWER FAN STOPPED WORKING, AND THE SRS LIGHT REMAINS LIT.*MR THE TURN SIGANLS STOPPED WORKING DUE TO A SHORT IN THE FLASHER. THE POWERTRAIN CONTROL MODULE WAS REPLACED DUE TO THE SES LIGHT ILUMINATING. THE BLOWER MOTOR FAN FAILED 4 TIMES DUE TO A SHORT IN THE WIRES AND CONTROL HEAD. THE VEHICLE OVERHEATED, BUT THE PROBLEM COULD NOT BE DIAGNOSED. THE LCD DISPLAYS, KNOBS BECOME EXTREMLY HOT AFTER HOURS OF DRIVING. *JB
WHEN CONTACT COMES TO A YIELD SIGN TRANSMISSION JERKS BEFORE GOING INTO GEAR. LATER HE WAS TOLD THIS WAS A BRAKE PROBLEM. WHEN APPROACHING A HILL/DOWNHILL AND APPLYING BRAKES THEY LOCK AND CAR SLIDES.*AK DOZENS OF TIMES CHECK BRAKE, SERVICE 4 WHEEL DRIVE LIGHTS HAVE COME ON. CONTACT HAS TAKEN VEHICLE TO DEALER OVER 1…
Read full complaint
WHEN CONTACT COMES TO A YIELD SIGN TRANSMISSION JERKS BEFORE GOING INTO GEAR. LATER HE WAS TOLD THIS WAS A BRAKE PROBLEM. WHEN APPROACHING A HILL/DOWNHILL AND APPLYING BRAKES THEY LOCK AND CAR SLIDES.*AK DOZENS OF TIMES CHECK BRAKE, SERVICE 4 WHEEL DRIVE LIGHTS HAVE COME ON. CONTACT HAS TAKEN VEHICLE TO DEALER OVER 12 TIMES SINCE IT HAS BEEN PURCHASED. DUE SERVICE LIGHTS, BRAKES AND TRANSMISSION. CONSISTENTLY TOLD BY DEALER THAT NOTHING IS WRONG. BUT DEALER AKNOWLEDGES CHECK BRAKE LIGHTS HAVE COME ON. DEALER STATES THAT IF COMPUTER DIAGNOSTIC DOES NOT PRODUCE AN ERROR CODE, THEN THERE IS NOTHING THEY CAN DO.
1. ENGINE WILL SHUT OFF WHEN MAKING A HARD TURN: AFTER STOPPED AT A STOP SIGN, I WAS TRYING TO MAKE A HARD TURN (STEERING WHEEL REACHED THE MAXIMUM TURNING ANGLE) WHEN THE ENGINE SUDDENLY SHUT OFF ITSELF. IT HAPPENED THREE TIMES EITHER TUNING LEFT OR RIGHT (TODAY), BUT ALWAYS AFTER STOPPING AND WITH A HARD TURNING ANGLE. IT IS…
Read full complaint
1. ENGINE WILL SHUT OFF WHEN MAKING A HARD TURN: AFTER STOPPED AT A STOP SIGN, I WAS TRYING TO MAKE A HARD TURN (STEERING WHEEL REACHED THE MAXIMUM TURNING ANGLE) WHEN THE ENGINE SUDDENLY SHUT OFF ITSELF. IT HAPPENED THREE TIMES EITHER TUNING LEFT OR RIGHT (TODAY), BUT ALWAYS AFTER STOPPING AND WITH A HARD TURNING ANGLE. IT IS SUCH A HUGE SAFETY DEFECT WITH ALL THE CARS INFRONT AND BEHIND YOU. NO REPAIR ACTION HAS BEEN TAKEN. THE PROBLEM MAY BE REPRODUCED. 2. TURNING SIGNALS NOT WORKING AFTER EMERGENCY LIGHTS USED: IT HAPPENED TWO TIMES. TURNING SIGNAL LIGHTS (LEFT OR RIGHT) WILL NOT WORK CORRECTLY AFTER THE EMERGENCY LIGHTS WERE IN USE; INSTEAD BOTH LEFT AND RIGHT TURNING LIGHTS WILL FLASH AT THE SAME TIME. IT CAN BE REPRODUCED. NO REPAIR ACTION TAKEN YET. 3. DIFFICULT TURNING AT A HARD TURN WITH 4-WHEEL-DRIVE IS ON: IT IS ALMOST IMPOSSIBLE TO MAKE A HARD TURN WHEN THE 4-WHELL-DRIVE IS ON. IT HAPPENS EVERY TIME. NO REPAIR ACTION TAKEN YET.*AK
SERVICE 4WD LIGHT CAME ONE WITH 2500 MILES ON NEW 2004 GMC ENVOY. REPLACED ACTUATOR, THEN A CONTROL MODULE ON TRANSFER CASE. WAS TOLD NEITHER FIXED THE PROBLEM. NOW TOLD THE TRANSFER CASE MUST BE REPLACED.
Official recalls
105V198000 · Exterior Lighting:turn Signal
May 5, 2005
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE05006 · Turn Signal Failures
Opened Feb 4, 2005 · Closed May 6, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (3)
Exterior Lighting:turn Signal:flasher Unit
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.