IllustrationVEHICLE: 2005 GMC ENVOY XUV ISSUE: REAR DOOR LATCHES FAILED DUE TO EXCESSIVE RUST BUILD UP. PROBLEM IS EXACTLY LIKE THAT FOUND ON 2002-03 ENVOY. ROAD SALT GETS INTO LATCH AND RUSTS OUT. BOTH DOOR EFFECTED AND REQUIRED REM=PLACEMENT. *TR
2005 GMC Envoy Xuv
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy Xuv years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 19 of 23 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
23 reportsFOR THE PAST FEW MONTHS WHEN I TURN ON MY TRUCK THE AIRBAG LIGHT TURNS ON AND STAYS ON FOR A FEW HOURS STATING THAT IT NEEDS SERVICE. IT HAPPENS EVERY FEW WEEKS AND IT CAN BE VERY DANGEROUS. IF I WERE TO BE INVOLVED IN A CAR ACCIDENT THE AIR BAGS MAY OR MAY NOT DEPLOY. I HAD TAKEN IT BACK TO THE DEALERSHIP WHERE I PURCHASED THE …
Read full complaint
FOR THE PAST FEW MONTHS WHEN I TURN ON MY TRUCK THE AIRBAG LIGHT TURNS ON AND STAYS ON FOR A FEW HOURS STATING THAT IT NEEDS SERVICE. IT HAPPENS EVERY FEW WEEKS AND IT CAN BE VERY DANGEROUS. IF I WERE TO BE INVOLVED IN A CAR ACCIDENT THE AIR BAGS MAY OR MAY NOT DEPLOY. I HAD TAKEN IT BACK TO THE DEALERSHIP WHERE I PURCHASED THE TRUCK TO TAKE A LOOK AT IT AND THEY SAID IT WAS OK, THAT I MUST OF PASSED A BUMP TOO FAST CAUSING IT TO TURN ON, BUT IT HAS BEEN QUITE A WHILE AND IT CONTINUES TO DO THE SAME THING. I GUARANTEE NO BUMP WOULD CAUSE A AIR BAG LIGHT TO TURN ON AND MALFUNCTION. AS IF THAT WAS NOT ENOUGH OF A PROBLEM IN THE BEGINNING OF THIS MONTH (MARCH) I STARTED HAVING TROUBLE WITH THE GAS GAUGE. AT FIRST WHEN I WOULD FILL IT UP IT WOULD READ EMPTY AND WOULD REGISTER ABOUT 30 MINUTES LATER TO THE CORRECT LEVEL. NOW IT DOESN'T REGISTER AT ALL, IT JUST MOVES FROM SIDE TO SIDE, STATES EMPTY WHEN I FILL UP AND EVERYMORNING WHEN I TURN THE TRUCK ON AND SAYS I HAVE A QUARTER TANK THERE AFTER. WHAT SAD IS THAT I AM NOT THE ONLY PERSON WITH THIS PROBLEM AND IT HAS NOT BEEN RECALLED. THIS CAN BE A SAFETY HAZARD AND CAUSES DISTRACTIONS WHEN DRIVING. *TR
BOTH OF MY WINDOWS WHICH SLIDE DOWN WITH THE PUSH OF A BUTTON DO NOT WORK! THEY HAVE BOTH BUSTED. ONE IS STUCK DOWN. THE OTHER I HAVE TO SHOVE UP BECAUSE WHILE DRIVING FROM THE VIBRATIONS IT FALLS. VERY UNSAFE. THEY BOTH STOPPED WORK WHILE I WAS OPERATING THEM BY PUSHING THE BUTTON FOR THEM TO SLIDE DOWN. I HAVE NOT REPLACED THE…
Read full complaint
BOTH OF MY WINDOWS WHICH SLIDE DOWN WITH THE PUSH OF A BUTTON DO NOT WORK! THEY HAVE BOTH BUSTED. ONE IS STUCK DOWN. THE OTHER I HAVE TO SHOVE UP BECAUSE WHILE DRIVING FROM THE VIBRATIONS IT FALLS. VERY UNSAFE. THEY BOTH STOPPED WORK WHILE I WAS OPERATING THEM BY PUSHING THE BUTTON FOR THEM TO SLIDE DOWN. I HAVE NOT REPLACED THEM YET. ITS VERY COSTLY. ITS HARD TO BELIEVE NO RECALL HAS BEEN DONE. I HAVE FOUND MANY OTHER COMPLAINTS REGARDING THIS. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.