IllustrationSTALLING OUT IN INTERSECTION,FUEL GAGE AND SPEED ODOMETER ,AIR BAGS DEFAULTING,SHACKING IN FRONT END , WHEN DRIVING. VERRY DANGEROUS.
2005 GMC Envoy Xl 370
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy Xl 370 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
2225–50K
3050–75K
1975–100K
16100–150K
2150K+
91 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports3 injury reports
Electronic Stability Control (esc) complaints
2 reportsI HAD TROUBLE WITH THE GAUGE THAT SHOWS OVERHEATING.I TOOK THE CAR IN TO PUT IN A THERMOSTAT THINKING IT WAS THE PROBLEM,BUT WHEN I TOOK IT IN THEY SAID THAT MY CLUSTER WAS BAD AND THE GAUGES WERE MESSED UP.I PAID $392.00 FOR THE CLUSTER AND $100.00 FOR LABOR.I BOUGHT THIS VEHICLE USED WITH 119,000 MILES ON IT ON 6/20/2011 AND O…
Read full complaint
I HAD TROUBLE WITH THE GAUGE THAT SHOWS OVERHEATING.I TOOK THE CAR IN TO PUT IN A THERMOSTAT THINKING IT WAS THE PROBLEM,BUT WHEN I TOOK IT IN THEY SAID THAT MY CLUSTER WAS BAD AND THE GAUGES WERE MESSED UP.I PAID $392.00 FOR THE CLUSTER AND $100.00 FOR LABOR.I BOUGHT THIS VEHICLE USED WITH 119,000 MILES ON IT ON 6/20/2011 AND ON 2/23/2013 I HAD THE CLUSTER REPLACED WITH MILEAGE OF 132,356. I PUT ON NEW BRAKES AT THIS TIME SINCE THE HAD A HABIT OF GRABBING AND MAKING ME SLIDE AND JERK TO A STOP.THE ONLY PROBLEM I HAVE NOW IS THE THE DOOR LOCKS MESS UP ONCE IN AWHILE BUT OTHER THAN THAT I TAKE MY ENVOY IN EVERY 4000 MILES FOR AN OIL CHANGE AND A CHECK UP IT IS NOW 12/15/2015 AND I ONLY HAVE 142,000 MILES ON IT AND IT IS STILL RUNNING OK.I KEEP CHECKING ONCE A MONTH FOR RECALLS ON MY VEHICLE SOMETIMES A DOME LIGHT WILL COME ON .BUT NOT OFTEN.MY ENVOY HAS NOT RUST AND THE INTERIOR IS IN AS GOOD AS IT WAS WHEN I PURCHASED IT FROM THE PREVIOUS OWNER WHICH IS IN EXCELLENT CONDITION
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11014 · Fuel Level Gauge System Failure
Opened Apr 25, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Additional source detail variants (2)
Fuel System, Other
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.