2005 GMC Canyon

BODY FRAME HAS ROT HOLES THROUGHOUT UNDERCARRIAGE. NEW FRAME NEEDED. WHILE DRIVING, I WENT OVER A SPEED BUMP AND HEARD A LOUD BOOM FROM UNDERNEATH THE TRUCK. UPON INVESTIGATING, IT WAS DETERMINED THAT THE DRIVESHAFT BROKE OFF N WAS LYING ON THE AXEL. AAA WAS CALLED AND IMMEDIATELY TOWED THE TRUCH 1 MILE TO OUR MECHANIC. AFTER A THOROUGH INSPECTION, IT WAS DETERMINED THAT A NEW DRIVESHAFT WAS NEEDED AND UPON FURTHER INSPECTION, THE MECHANIC SPOTTED NUMEROUS PITTING RUSTED HOLES THROUGHOUT THE FRAME. DETERMINED THAT SAID TRUCK WAS A TOTAL LOSS.

TL* THE CONTACT OWNS A 2005 GMC CANYON. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR NEW TIRES, THE TECHNICIAN NOTICED THAT THE BOTTOM OF THE FRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

THE LEFT REAR FRAME RAIL JUST IN FRONT OF THE LEFT REAR FRONT SPRING SHACKLE HAS RUSTED THROUGH AND IS NO LONGER SAFE TO DRIVE THE VEHICLE. THERE ARE HOLES THROUGH THE LOWER PORTION OF THE FRAME RAIL. THE SIDES OF THE SAME AREA HAVE BECOME VERY THIN COMPARED TO THE ORIGINAL THICKNESS OF THE FRAME RAIL. BECAUSE OF THE LOCATION OF THE RUST THROUGH AT THE SPRING SHACKLE IT WAS RECOMMENDED A FRAME REPAIR SHOULD NOT BE COMPLETED. THE TRUCK WAS DISPOSED OF AND TAKEN OFF ROAD. THE REMAINDER OF THE VEHICLE IS IN GOOD CONDITION. MILEAGE 75,124 MILES. THE FRAME RAIL IS FORMED INTO A BOX FRAME WITH THE SEAM LOCATED AT THE BOTTOM OF THE RAIL. THE RUST APPEARS TO BE WORST ON THE SEAM. THE SEAM IS A LAP SEAM AND APPEARS TO TRAP WATER IN THE LAP SEAM. THE RIGHT SIDE FRAME RAIL IS THIN HOWEVER IS NOT RUSTED THROUGH AT THIS TIME.

MY 2005 GMC CANYON CONTINUES TO HAVE ISSUES WITH THE PASSLOCK II SYSTEM. NO MODIFICATIONS HAVE BEEN MADE TO THE IGNITION SWITCH, KEYS, OR ANY OTHER ELECTRICAL SYSTEM. THE PASSLOCK PREVENTS ME FROM STARTING MY TRUCK BECAUSE FOR SOME REASON THE COMPUTER THINKS IT IS TRYING TO BE STOLEN. THE LAST TIME THIS ISSUE OCCURED, MY TRUCK WAS PARKED IN MY GARAGE. WHEN ATTEMPTED TO START, THE TRUCK CRANKED BUT DID NOT START AND THE PASSLOCK LIGHT CAME ON. I HAD TO SIT AND WAIT FOR 10 MINUTES UNTIL THE LIGHT WENT OFF. THE PROBLEM WAS I WAS TRYING TO DRIVE MYSELF TO THE EMERGENCY ROOM BECAUSE I HAD JUST BEEN BITTEN BY A DOG.

I TOOK MY TRUCK TO A LOCAL SHOP TO HAVE THE FUEL SYSTEM LOOKED AT AFTER I STARTED SMELLING FUEL. THE SERVICE MANAGER CALLS ME THAT EVENING AND REQUEST I LOOK AT THE TRUCK WHILE IT IS ON THE LIFT SO I CAN SEE THE FRAME FOR MYSELF AS THE FUEL SYSTEM WOULD BE THE LEAST OF MY CONCERNS ONCE I SAW THE FRAME. THE REAR OF THE FRAME FROM THE REAR SPRING HANGER BACK IS ROTTED AWAY ON A 12-YEAR-OLD TRUCK THAT HAS NO BODY RUST AND SOME RUST ON THE OTHER PARTS OF THE FRAME AS TO BE EXPECTED FOR THE AGE. I HAVE ATTACHED PICTURES OF THE SPRING HANGER DETACHED FROM THE FRAME DUE TO THE LACK OF STRUCTURAL SUPPORT AND PICTURES OF THE BAD FRAME SECTION AND THE REST OF THE FRAME ALONG WITH A PICTURE OF THE TRUCK. I HAVE OWNED THE TRUCK SINCE IT WAS NEW AND TAKEN CARE OF IT AND AM TROUBLED THAT A STRUCTURAL ITEM SUCH AS A FRAME ONLY IN ONE SECTION, THE SAME SECTION, ON BOTH SIDES IS IN SUCH BAD SHAPE THAT THE MECHANIC RECOMMENDED THAT I REPLACE THE FRAME. I KNOW I LIVE IN AN AREA THAT RECEIVES SNOW AND THE ROADS ARE SALTED BUT CLEANED MY TRUCK FREQUENTLY TO WASH THE SALT OFF OF IT BUT A TRUCK WITH 112,500 MILES THAT IS 12 YEARS OLD SHOULD NOT HAVE A STRUCTURAL FAILURE WHILE ALL OTHER PARTS INCLUDING THIN SHEET METAL ARE STILL IN GREAT SHAPE AND HAVE NOT BEEN PAINTED. THE ONLY REPAINTED ITEMS ON THE TRUCK ARE THE HOOD (AFTERMARKET) AND TAILGATE. SO WHY DOES THIS TRUCK HAVE A ROTTED STRUCTURAL COMPONENT?

2005 CREW CAB GMC CANYON Z85 SLE - LOCALIZED FRAME DETERIORATION DUE TO EXCESSIVE RUST COMPLETELY THROUGH THE BOX FRAME. NO OTHER AREAS ON FRAME DISPLAY MORE THAN SURFACE RUST. PRESENT FROM DRIVERS SIDE REAR DOOR TO ABOVE THE FRAME ELEVATION CHANGE, INCLUDING THE MOUNTING BRACKET FOR THE REAR LEAF SPRING. HOLES AND SEAMS COMPLETELY OPEN IN AFFECTED AREAS. STRUCTURAL INTEGRITY COMPROMISED AT JOINT OF CAB TO THE BED OF TRUCK. VEHICLE IS STILL FUNCTIONAL BUT DAMAGE TO THIS AREA DOES NOT ALLOW FOR TRUCK TO BE USED AS INTENDED. ANY SIGNIFICANT WEIGHT IN BED MAY CAUSE FRAME TO COLLAPSE. NOT RELATED TO ANY SPECIFIC INCIDENT. NO FAILURE TO OPERATE AT THIS TIME.

MY TRUCK IS EXHIBITING AN ISSUE IN WHICH THE GM PASSLOCK SYSTEM DISABLES THE FUEL AND ENGINE BECAUSE OF SOME MALFUNCTION. THIS SYSTEM IS INTENDED TO DISABLE THE FUEL SYSTEM ON A VEHICLE IF IT DETECTS THAT THE IGNITION HAS BEEN TAMPERED WITH OR IN IMPROPER KEY HAS BEEN USED TO TRY AND START THE VEHICLE. MY ISSUE IS THAT INTERMITTENTLY WHEN I TRY TO START MY TRUCK WITH THE FACTORY KEY, THE PASSLOCK SYSTEM ENGAGES AND DOES NOT ALLOW ME TO START MY TRUCK. I HAVE TO WAIT 10 MINUTES IN ORDER FOR THE PASSLOCK SYSTEM LIGHT TO TURN OFF ON THE DASHBOARD. SOMETIMES MY TRUCK WILL START AFTER THIS 10 MINUTE LOCKOUT PERIOD. IT HAS HAPPENED BEFORE WHERE MY TRUCK WILL FAIL TO START AFTER THE FIRST LOCKOUT PERIOD AND I HAVE TO WAIT ANOTHER 10 MINUTES. ONCE THE PASSLOCK SYSTEM ALLOWS ME TO START THE ENGINE, MY TRUCK RUNS FINE WITH NO ISSUES. IN MY OPINION, THIS IS A SERIOUS SAFETY CONCERN. IN ANY EMERGENCY SITUATION, I WOULD HOPE TO DEPEND ON MY TRUCK STARTING. THIS MALFUNCTIONING PASSLOCK SYSTEM PREVENTS ME FROM STARTING MY TRUCK. MY GREATEST ISSUE WITH THIS SITUATION IS THAT MY TRUCK IS NOT THE ONLY ONE THAT IS AFFECTED BY THIS. A QUICK GOOGLE SEARCH OF "GMC CANYON PASSLOCK" WILL SHOW PAGES UPON PAGES OF FORUMS OF OTHER TRUCK OWNERS WITH THE SAME PROBLEM. I LIVE IN AN AREA OF THE COUNTRY WITH A HIGH RISK OF FOREST FIRES. I KNOW FRIENDS WHO HAVE BEEN EVACUATED FROM THEIR HOMES IN THE PAST. I HONESTLY BELIEVE THAT THIS MALFUNCTION OF MY TRUCK COULD GREATLY IMPACT MY ABILITY TO EVACUATE IN CASE OF AN EMERGENCY.

HIT 3 DEER IN HIGH SPEED COLLISION. MY AIR BAGS DIDN'T FUNCTION. THEN RESEARCH ONLINE SHOWED I HAVE TIKATA AIRBAGS. THEN I NOTICED MY BRAKES IF WET OR HAVE ICE ON ROTORS, WHEN BRAKING, I GET TERRIBLE SQUEAKING NOISE AND FRONT END WILL SHIMMY OR VIBRATE. REAR BRAKES TOO. AND MY POWER STEERING STARTED MAKING NOISE, LIKE A RUBBING SOUND A FEW MONTHS AFTER I BOUGHT TRUCK, THOUGH NO FLUID LOSS OR STIFFNESS IN STEERING. I KNOW THESE AIR BAGS ARE DANGEROUS, METAL PARTS HAVE KILLED A FEW PEOPLE. WHY WASN'T I NOTIFIED BY AUTOMAKER ABOUT WHAT AIRBAGS WERE INSTALLED IN MY TRUCK!? I NEED FIXED. I DO A LOT OF MOUNTAIN DRIVING. I WOULD LIKE THEM TO WORK PROPERLY. AND THESE STRANGE NOISES REALLY BUG ME. I CAN'T BE BREAKING DOWN DEEP INTO MOUNTAIN ROADS WHEN I WORK OR TRAVEL. MUCH HIGHWAY TRAVELING TOO. THE CRUISE CONTROL HAS NEVER WORKED, SINCE TWO WEEKS AFTER BUYING TRUCK. IF COMING UP TO HILLS WHEN SET, THEN AS YOU DRIVE UP & DOWN MORE HILLS, IT WILL SELF EXCELLERATE! NOT SLOW DOWN ON DECLINES. VERY SCARY A COUPLE OF TIMES. VERY DANGEROUS! ENGINE WOULD JUMP INTO PASSING GEAR. I HAVE THE 5 CYLINDER 3.5 MOTOR. AUTOMATIC, SLE EXTENDED CAB 4X4. SHOULD I GO BACK TO DEALER TO GET FIXED?