IllustrationTHROW BEARING WEARS OUT EVERY 40,000 KM. BELL HOUSING GONE AT 180,000 KM'S, REAR END WORE OUT AT 182,000 KMS AND FORTH GEAR GONE IN TRANSMISSION AT 183,000, DASH CLUSTER GONE AT 188,000. MANUFACTURE OR DEALER WOULD NOT COVER ANYTHING. *NM
2003 GMC C4500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all C4500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Power Train complaints
2 reportsVEHICLE WAS EXPERIENCING A PROBLEM WITH GREASE FROM THE REAR END LEAKING ONTO THE LEFT REAR WHEEL BRAKING SYSTEM. THIS CAUSED LOSS OF BRAKING IN THAT WHEEL. DEALER REPLACED THE GREASE SEAL WITH AN UPGRADED SEAL SIX TIMES, PROBLEM RECURRED. *AK REAL GREASE SEAL WAS REPLACED. THE DRIVER SIDE BRAKE CALIPER BOLT FELL OUT CAUSIN…
Read full complaint
VEHICLE WAS EXPERIENCING A PROBLEM WITH GREASE FROM THE REAR END LEAKING ONTO THE LEFT REAR WHEEL BRAKING SYSTEM. THIS CAUSED LOSS OF BRAKING IN THAT WHEEL. DEALER REPLACED THE GREASE SEAL WITH AN UPGRADED SEAL SIX TIMES, PROBLEM RECURRED. *AK REAL GREASE SEAL WAS REPLACED. THE DRIVER SIDE BRAKE CALIPER BOLT FELL OUT CAUSING THE CALIPER TO RUB THE INSIDE OF THE INNER DUAL WHEEL CAUSING DAMAGE TO THE CALIPER AND WHEEL. *TC
Official recalls
102V202000 · Suspension:rear
Jul 26, 2002
CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH 11,000 LB. REAR AXLE HAVE A CONDITION WHERE THE REAR AXLE ANCHOR PLATE MAY FRACTURE. AS THE ANCHOR PLATE FRACTURES, THERE IS AN AUDIBLE "BANG." IF THIS INDICATION OF A CONDITION REQUIRING THE DRIVER'S ATTENTION WENT UNNOTICED OR WAS IGNORED, AND UNDER CERTAIN REBOUND, BRAKING, OR CORNERING MANEUVERS, THE REAR AXLE WOULD BE FREE TO MOVE FORE AND AFT AND PROVIDE UNEXPECTED STEERING INPUTS TO THE VEHICLE.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD RESULT.
Remedy: DEALERS WILL INSTALL A NEW REAR AXLE ANCHOR PLATE AND SPACER. OWNER NOTIFICATION BEGAN AUGUST 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.