NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
45 reportsClear category filter125,000 miles · Nov 16, 2018
Engine
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. ONCE THE VEHICLE WAS RESTARTED, IT RETURNED TO NORMAL OPERATION. THE VEHICLE WAS TAKEN TO ART MORAN BUICK GMC (29300 TELEGRAPH RD, SOUTHFIELD, MI 48034, (800) 224-2570) TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NO…
Read full complaint
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. ONCE THE VEHICLE WAS RESTARTED, IT RETURNED TO NORMAL OPERATION. THE VEHICLE WAS TAKEN TO ART MORAN BUICK GMC (29300 TELEGRAPH RD, SOUTHFIELD, MI 48034, (800) 224-2570) TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO CALL NHTSA. THE FAILURE MILEAGE WAS 125,000.
NHTSA ODI #11152044
55,000 miles · Jun 20, 2018
Electrical SystemEngineStructureCrash
"TAKATA RECALL" ON TUESDAY JUNE 19 I HAD PULLED INTO MY DRIVEWAY JUST BEFORE MY GARAGE WITH MY TWO SMALL CHILDREN. I PUT THE CAR IN PARK AND GOT OUT TO UNLOAD AND PREPARE TO TRANSFER MY ONE KID AND THEN THE OTHER. IT WAS 100 DEGREE WEATHER SO HAD TO KEEP THE CAR RUNNING. AFTER A MINUTE OR SO BEING IN PARK, MY CAR BEGAN TO DRIVE…
Read full complaint
"TAKATA RECALL" ON TUESDAY JUNE 19 I HAD PULLED INTO MY DRIVEWAY JUST BEFORE MY GARAGE WITH MY TWO SMALL CHILDREN. I PUT THE CAR IN PARK AND GOT OUT TO UNLOAD AND PREPARE TO TRANSFER MY ONE KID AND THEN THE OTHER. IT WAS 100 DEGREE WEATHER SO HAD TO KEEP THE CAR RUNNING. AFTER A MINUTE OR SO BEING IN PARK, MY CAR BEGAN TO DRIVE FORWARD WITH NO ONE BEHIND THE WHEEL. MY CAR DROVE OFF MY RETAINING WALL AND LANDED VERTICALLY WITH MY CHILDREN SUSPENDED IN THEIR CAR SEATS. EMERGENCY OFFICIALS RESPONDED. I HAVE VIDEO AND WILL HOLD OFF FIXING THE DAMAGE OF VEHICLE SO THAT THE FEDS CAN INVESTIGATE. GMC ALSO WOULD LIKE TO TAKE A LOOK AT IT. PLEASE LET ME KNOW WHERE TO SUBMIT MY SECURITY FOOTAGE.
NHTSA ODI #11102864
87,000 miles · Jun 4, 2018
EnginePower Train
WHILE IN MOTION, THE VEHICLE FEELS AS IF IT MISS-SHIFTS. IT DOES NOT MATTER WHETHER IT IS ON A HIGHWAY OR CITY STREETS, FROM TIME TO TIME, IT WILL FEEL LIKE THE SUV PULLS BACK OR "SKIPS A BEAT."
NHTSA ODI #11099557
34,000 miles · Oct 10, 2017
Engine
MOTOR CRANKS FOR AN EXTENDED PERIOD OF TIME WHEN STARTING AND ENGINE RUNS ROUGH FOR A FEW SECONDS AFTER STARTING. ALSO VEHICLE HAS AN ODD SMELL WHEN THIS HAPPENS.
NHTSA ODI #11032634
35,000 miles · Jan 10, 2017
Electrical SystemEngine
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING VARIOUS SPEEDS AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT ALSO MENTIONED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURES…
Read full complaint
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING VARIOUS SPEEDS AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT ALSO MENTIONED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURES WERE UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V614000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 35,000. UPDATED 04/05/17*LJ CONTACT STATED THAT THE PROBLEM HAVE BEEN SOLVED AND CASE COULD CLOSED. *CN
NHTSA ODI #10944198
60,000 miles · Nov 1, 2016
Electronic Stability Control (esc)EngineTraction Control System
MY WIFE WAS DRIVING THE CAR AROUND 40MPH ON SURFACE STREETS. . THE VEHICLE'S TRACTION CONTROL, ELECTRONIC STABILITY CONTROL, AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE CAR RESTARTED BUT WOULD ONLY GO ABOUT 20MPH AND THE DEALER SAID IT WOULD BE SAFE TO DRIVE IT TO THE DEALERSHIP. THE DEALERSHIP DIAGNOSED THE PROBLEM AS A H…
Read full complaint
MY WIFE WAS DRIVING THE CAR AROUND 40MPH ON SURFACE STREETS. . THE VEHICLE'S TRACTION CONTROL, ELECTRONIC STABILITY CONTROL, AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE CAR RESTARTED BUT WOULD ONLY GO ABOUT 20MPH AND THE DEALER SAID IT WOULD BE SAFE TO DRIVE IT TO THE DEALERSHIP. THE DEALERSHIP DIAGNOSED THE PROBLEM AS A HIGH PRESSURE FUEL PUMP AT 60K MILES. THE COST WAS $945 AND IT SEEM TO BE FIXED BUT TOO EXPENSIVE FOR A CAR WITH ONLY 60K MILES. *TR
NHTSA ODI #10920515
50,000 miles · Jul 27, 2016
Engine
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. IT WAS DIAGNOSED THAT THE COMPRESSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 50,000.
NHTSA ODI #10888916
24,000 miles · Jun 15, 2016
Electrical SystemElectronic Stability Control (esc)Engine
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO VIBRATE AND THE TRACTION CONTROL, ELECTRONIC STABILITY CONTROL, AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT ALSO STATED THAT THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2014 GMC ACADIA. WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO VIBRATE AND THE TRACTION CONTROL, ELECTRONIC STABILITY CONTROL, AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT ALSO STATED THAT THE VEHICLE HAD TO BE RESTARTED IN ORDER FOR THE FAILURE TO STOP. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 24,000.
NHTSA ODI #10874481
10,500 miles · Mar 18, 2015
EngineFuel/propulsion System
I WAS DRIVING AT ROUGHLY FIFTY MPH WHEN ENGINE SHUTOFF AND PUT VEHICLE INTO NEUTRAL TO PULLOVER AVOIDING REAR END CRASH BY SEMI TRUCK I ATTEMPTED TO START VEHICLE BUT VEHICLE ENGINE LOCKED WITHOUT ANY WARNING I CALLED DEALER AND TOWED INTO SERVICE AND IT WAS SOMETHING INTERNAL IN ENGINE AND TOLD TO WAIT FOR MORE INFO. *TR
NHTSA ODI #10695220
10,250 miles · Dec 9, 2014
Electronic Stability Control (esc)Engine
I WAS TRAVELING ON THE HIGHWAY AT ABOUT 70 MPH IN THE LEFT LANE AND THE ENGINE BEGAN TO SPUTTER LIKE IT WAS GOING TO STALL. IT DROPPED MY SPEED TO 60 WITHOUT WARNING. I HAD A VEHICLE BEHIND ME GOING THE SAME SPEED AND HAD TO QUICKLY MOVE TO THE RIGHT TO AVOID GETTING HIT. THE CHECK ENGINE LIGHT CAME ON AND THE TRACTION CONTROL…
Read full complaint
I WAS TRAVELING ON THE HIGHWAY AT ABOUT 70 MPH IN THE LEFT LANE AND THE ENGINE BEGAN TO SPUTTER LIKE IT WAS GOING TO STALL. IT DROPPED MY SPEED TO 60 WITHOUT WARNING. I HAD A VEHICLE BEHIND ME GOING THE SAME SPEED AND HAD TO QUICKLY MOVE TO THE RIGHT TO AVOID GETTING HIT. THE CHECK ENGINE LIGHT CAME ON AND THE TRACTION CONTROL / STABILITRAC TURNED OFF. BROUGHT IT TO THE DEALER AND THEY TOLD ME I WAS USING THE WRONG GAS. THEY CLEANED CARBON OUT OF THE INTAKE VALVES. I HAVE PUT GAS IN IT TWICE SINCE THEN, AT SHELL, WHICH IS WHAT THEY TOLD ME TO USE. IT HAPPENED AGAIN TODAY 12/9 WHEN I WAS GOING AROUND A CORNER IN THE RAIN. THIS TIME IT SAID SERVICE STABILITRAK AND SERVICE TRACTION CONTROL WITH THE CHECK ENGINE LIGHT FLASHING AND THE ENGINE SPUTTERING. I HAD BEEN GOING THROUGH A PUDDLE AT THE TIME SO I ALMOST LOST CONTROL OF THE VEHICLE. CALLED THE DEALER AND THEY TOLD ME THEY HAD NO RECORD OF ME BRINGING IT IN ON THE 21ST. I AM BRINGING IT BACK TO THEM ON THE 15TH BECAUSE THAT IS THE FIRST TIME THEY WILL HAVE A LOANER AVAILABLE FOR ME. I AM NOW AFRAID TO DRIVE MY CAR BECAUSE OF THE DANGER OF SLIDING AND LOSING CONTROL. I HAVE NO WARNING OF WHEN THIS IS GOING TO HAPPEN AND I HAVE NOT BEEN ABLE TO PIN POINT IT HAPPENING AT ANY CERTAIN MILEAGE OR SUCH. VERY SCARY WHEN IT HAPPENS. *TR
NHTSA ODI #10663104
Official recalls
6May 10, 2023
General Motors, LLC (GM) is recalling certain 2014-2017 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. GM began mailing final owner letters February 23, 2024 and will continue mailing through December 2025. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N232404980.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Apr 30, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence & remedy
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Additional source detail variants (3)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Electrical System: Instrument Cluster/panel
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Fuel System, Gasoline
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Feb 21, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration