NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
46 reportsClear category filter75,000 miles · Jan 12, 2017
Steering
TL* THE CONTACT OWNS A 2012 GMC ACADIA. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FA…
Read full complaint
TL* THE CONTACT OWNS A 2012 GMC ACADIA. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10944509
70,000 miles · Dec 13, 2016
Steering
THE STEERING ON THE VEHICLE BEGAN TO ACT LIMITED AND TOUGH TO CONTROL. LAST WEEK WHEN TURNING THROUGH AN INTERSECTION, IT BECAME DIFFICULT TO CONTROL AND AVOIDED AN ACCIDENT ONLY DUE TO LOW RATE OF SPEED. PULLED THE OFF TO THE SIDE AND GOT THE VEHICLE OFF OF THE ROAD IMMEDIATELY AFTER THIS ISSUE. IF TURN WAS CONDUCTED AT A H…
Read full complaint
THE STEERING ON THE VEHICLE BEGAN TO ACT LIMITED AND TOUGH TO CONTROL. LAST WEEK WHEN TURNING THROUGH AN INTERSECTION, IT BECAME DIFFICULT TO CONTROL AND AVOIDED AN ACCIDENT ONLY DUE TO LOW RATE OF SPEED. PULLED THE OFF TO THE SIDE AND GOT THE VEHICLE OFF OF THE ROAD IMMEDIATELY AFTER THIS ISSUE. IF TURN WAS CONDUCTED AT A HIGHER RATE OF SPEED, IT COULD HAVE BEEN A PROBLEM. AFTER HAVING THE VEHICLE IN THE SHOP FOR THREE DAYS IT WAS DETERMINED THAT THERE WAS A MALFUNCTION OF THE POWER STEERING AND A BAD POWER STEERING PUMP. THIS WAS EXTREMELY FRUSTRATING FOR A VEHICLE WITH ONLY 70,000 MILES. *TR
NHTSA ODI #10934977
33,000 miles · Aug 20, 2016
Steering
DURING THE LAST YEAR OR SO, MY STEERING GOES OUT WHEN I'M MAKING A TURN AFTER DRIVING THROUGH A PUDDLE. IT KICKS BACK IN AFTER 15-30 SECONDS. I TOOK IT TO THE DEALER LAST YEAR, THEY JUST BLEW IT OFF, SAID IT WAS A DIRTY SENSOR OR SOMETHING, BUT DIDN'T FIX IT, NOR DID THEY DOCUMENT IT. IT KEPT HAPPENING. I TOOK IT BACK TO THE DEA…
Read full complaint
DURING THE LAST YEAR OR SO, MY STEERING GOES OUT WHEN I'M MAKING A TURN AFTER DRIVING THROUGH A PUDDLE. IT KICKS BACK IN AFTER 15-30 SECONDS. I TOOK IT TO THE DEALER LAST YEAR, THEY JUST BLEW IT OFF, SAID IT WAS A DIRTY SENSOR OR SOMETHING, BUT DIDN'T FIX IT, NOR DID THEY DOCUMENT IT. IT KEPT HAPPENING. I TOOK IT BACK TO THE DEALER LAST WEEK (AFTER MY WARRANTY EXPIRED) AND THEY DID $1800 WORTH OF WORK TO THE CAR (NEW STEERING PUMP AND STEERING HOSE). MY EXTENDED WARRANTY COVERED SOME OF IT. LAST NIGHT IT STORMED AGAIN, THERE WERE A LOT OF PUDDLES ON THE ROADS AND NOW IT'S WORSE THAN EVER!!! THE STEERING IS GOING OUT EVEN WHEN I'M DRIVING STRAIGHT THROUGH A PUDDLE AND IT'S LASTING LONGER. THE BATTERY WARNING LIGHT ALSO FLASHED ON, BUT THEN IT WENT OFF WHEN THE STEERING KICKED BACK IN. I'M PETRIFIED TO DRIVE THE CAR!
NHTSA ODI #10897390
86,000 miles · Jul 6, 2016
Steering
IN 2015, THE GM DEALER REPLACED THE POWER STEERING PUMP DUE TO FAILURE UNDER A RECALL. ON JULY 7, 2016, I TOOK BY CAR BACK TO THE DEALER AND NOW THE RACK IS LEAKING POWER STEERING FLUID. THIS CONTINUES TO BE AN ISSUE WITH THESE VEHICLE. VERY UNSAFE TO OPERATE WHEN THE STEERING SYSTEM KEEPS FAILING. THIS ISSUE HAS MADE THE VE…
Read full complaint
IN 2015, THE GM DEALER REPLACED THE POWER STEERING PUMP DUE TO FAILURE UNDER A RECALL. ON JULY 7, 2016, I TOOK BY CAR BACK TO THE DEALER AND NOW THE RACK IS LEAKING POWER STEERING FLUID. THIS CONTINUES TO BE AN ISSUE WITH THESE VEHICLE. VERY UNSAFE TO OPERATE WHEN THE STEERING SYSTEM KEEPS FAILING. THIS ISSUE HAS MADE THE VEHICLE DIFFICULT TO STEER.
NHTSA ODI #10882942
50,800 miles · Apr 26, 2016
Steering
I HAVE HAD SOME ISSUES WITH THIS VEHICLE INCLUDING A FAILED BRAKE BOOSTER AND MY RACK AND PINION STEERING MECHANISM IS CURRENTLY BEING REPLACED DUE TO LEAKING AND PROBABLE FAILURE, WHICH I UNDERSTAND IS A COMMON PROBLEM WITH THESE VEHICLES. I WAS HEARING NOISE COMING OUT OF THE STEERING COLUMN WHEN TURNING FOR SOMETIME NOW. I …
Read full complaint
I HAVE HAD SOME ISSUES WITH THIS VEHICLE INCLUDING A FAILED BRAKE BOOSTER AND MY RACK AND PINION STEERING MECHANISM IS CURRENTLY BEING REPLACED DUE TO LEAKING AND PROBABLE FAILURE, WHICH I UNDERSTAND IS A COMMON PROBLEM WITH THESE VEHICLES. I WAS HEARING NOISE COMING OUT OF THE STEERING COLUMN WHEN TURNING FOR SOMETIME NOW. I WAS TOLD THAT THE HYDRAULIC MECHANISM MAY FAIL AND CAUSE SUDDEN MORE DIFFICULT TURNING WITHOUT REPLACEMENT. I HAVE ALSO OWNED ANOTHER 2007 ACADIA AND HAD TO HAVE A POWER STEERING PUMP REPLACED 4 TIMES.
NHTSA ODI #10861511
97,000 miles · Jan 25, 2016
Steering
PURCHASED A GMC ACADIA DENALI IN SEP 2015. HAD TO HAVE TRANSMISSION REPAIRED, STRUTS REPLACED IN NOV 2015. BEGAN HAVING PROBLEMS WITH STEERING LOCKING UP WHEN TURNING WHEEL HARD AND MAKING A LOUD WHINING SOUND AS WELL AS BURNING FLUID SMELL IN JAN 2016. TOOK VEHICLE TO DEALER AND WAS ADVISED BY SERVICE DEPARTMENT THAT THE POWER …
Read full complaint
PURCHASED A GMC ACADIA DENALI IN SEP 2015. HAD TO HAVE TRANSMISSION REPAIRED, STRUTS REPLACED IN NOV 2015. BEGAN HAVING PROBLEMS WITH STEERING LOCKING UP WHEN TURNING WHEEL HARD AND MAKING A LOUD WHINING SOUND AS WELL AS BURNING FLUID SMELL IN JAN 2016. TOOK VEHICLE TO DEALER AND WAS ADVISED BY SERVICE DEPARTMENT THAT THE POWER STEERING PUMP/MOTOR WAS LEAKING AND REQUIRES REPLACEMENT, AND THE RACK AND PINION IS BAD AND HAS TO BE REPLACED. FURTHER RESEARCH INDICATES THIS IS A VERY COMMON ISSUE WITH THIS VEHICLE AND GM IS AWARE OF THE DEFECTIVE POWER STEERING PUMP/MOTOR AND RACK AND PINION. EVEN DEALER SERVICE TECHS ADVISED IT IS A VERY WELL KNOWN AND DOCUMENTED PROBLEM WITH THIS MODEL VEHICLE YET THE REPAIR IS NOT COVERED BY THE MANUFACTURER. THIS IS A VERY DANGEROUS CONDITION TO THE DRIVER OF THE VEHICLE AS WELL AS TO THE DRIVING PUBLIC AND PEDESTRIANS IN GENERAL. THERE IS AN OPEN CLASS ACTION LAWSUIT AS WELL. NHTSA SHOULD REQUIRE GM TO RECALL THESE VEHICLES AND MAKE THE REQUIRED REPAIRS AS TO PREVENT A CLEAR DANGER TO THE PUBLIC.
NHTSA ODI #10822018
72,000 miles · Jan 6, 2016
Steering
TL* THE CONTACT OWNS A 2012 GMC ACADIA. WHILE DRIVING 45 MPH, THE STEERING WHEEL BEGAN TO MAKE A LOUD ABNORMAL NOISE AND THE VEHICLE STEERED TO THE LEFT WITHOUT WARNING. THE FAILURE WAS CONSISTENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 7…
Read full complaint
TL* THE CONTACT OWNS A 2012 GMC ACADIA. WHILE DRIVING 45 MPH, THE STEERING WHEEL BEGAN TO MAKE A LOUD ABNORMAL NOISE AND THE VEHICLE STEERED TO THE LEFT WITHOUT WARNING. THE FAILURE WAS CONSISTENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000.
NHTSA ODI #10818520
38,000 miles · Jan 6, 2016
Steering
WHILE DRIVING EITHER IN THE RAIN, OR IF HIT A PUDDLE .....IT DOESN'T HAVE TO BE A BIG PUDDLE EITHER. I HEAR THIS GOD AWFUL SCREECHING NOISE. I THEN LOOSE ALL CONTROL OF THE STEERING AFTER A FEW SECONDS IT CATCHES AND WORKS. THE BATTERY WARNING LIGHT WILL COME ON. THIS HAPPENS W EVERY TIME IT RAINS OR I JUST HIT A PUDDLE. …
Read full complaint
WHILE DRIVING EITHER IN THE RAIN, OR IF HIT A PUDDLE .....IT DOESN'T HAVE TO BE A BIG PUDDLE EITHER. I HEAR THIS GOD AWFUL SCREECHING NOISE. I THEN LOOSE ALL CONTROL OF THE STEERING AFTER A FEW SECONDS IT CATCHES AND WORKS. THE BATTERY WARNING LIGHT WILL COME ON. THIS HAPPENS W EVERY TIME IT RAINS OR I JUST HIT A PUDDLE. LUCKILY I WAS ABLE TO GET OFF THE ROAD AND OUT OF THE WAY OF TRAFFIC. FIRST TIME IT HAPPENED WAS NOVEMBER 17, 2015 AND HAS HAPPENED 4 TIMES SINCE. WAS WONDERING IF THERE HAVE BEEN ANY RECALLS OR INFORMATION ON THIS. THIS IS VERY DANGEROUS AND SCARY!
NHTSA ODI #10818460
Mileage unknown · Nov 24, 2015
Fuel/propulsion SystemPower TrainSteering
THE FIRST THING THAT I WANT TO SAY IS THAT SOME OF THE RECALLS ARE NOT FOR THE 2012 MODEL BUT MINE HAS HAD THE ISSUES WITH THE FUEL MODULER NOT READING CORRECTLY AS IN ONE RECALL AND ALSO THE SHIFTER CLIP CAUSING THE VEHICLE TO NOT BE IN THE CORRECT GEAR. WHAT DO I DO? ALSO THE SECOND THING IS THE A/C BROKE WITHIN THE 3RD YEAR O…
Read full complaint
THE FIRST THING THAT I WANT TO SAY IS THAT SOME OF THE RECALLS ARE NOT FOR THE 2012 MODEL BUT MINE HAS HAD THE ISSUES WITH THE FUEL MODULER NOT READING CORRECTLY AS IN ONE RECALL AND ALSO THE SHIFTER CLIP CAUSING THE VEHICLE TO NOT BE IN THE CORRECT GEAR. WHAT DO I DO? ALSO THE SECOND THING IS THE A/C BROKE WITHIN THE 3RD YEAR OF HAVING IT. THE THIRD THING TO GO WRONG IS THE POWER STEERING. IT COMES AND GOES BUT AS LONG AS I PUSH ON THE GAS I HAVE POWER STEERING. I'M VERY CONCERNED ABOUT THE FUEL MODULER BECAUSE MY DAUGHTER DRIVES THIS VEHICLE ALSO TRAVELING THE INTERSTATE TO WORK AND ALSO A VERY POPULATED SECONDARY ROAD.
NHTSA ODI #10806407
73,113 miles · Nov 23, 2015
Steering
DIFFICULTY IN TURNING, ALONG WITH A GRINDING NOISE WHEN TURNING RIGHT. VEHICLE MILEAGE WAS 73,113. TAKEN TO GMC DEALER IN BRIGHTON, MI ON NOV. 14, 2014 AND POWER STEERING PUMP AND RACK AND PINION WERE REPLACED FOR $2,100.00. THE CAR WAS THEN DRIVEN APPROX. 650 MILES. THE NEXT MORNING, WHEN BACKING OUT OF DRIVE, THE STEERIN…
Read full complaint
DIFFICULTY IN TURNING, ALONG WITH A GRINDING NOISE WHEN TURNING RIGHT. VEHICLE MILEAGE WAS 73,113. TAKEN TO GMC DEALER IN BRIGHTON, MI ON NOV. 14, 2014 AND POWER STEERING PUMP AND RACK AND PINION WERE REPLACED FOR $2,100.00. THE CAR WAS THEN DRIVEN APPROX. 650 MILES. THE NEXT MORNING, WHEN BACKING OUT OF DRIVE, THE STEERING WAS LOCKED-UP AND THE VEHICLE WENT OFF THE DRIVEWAY. TOW TRUCK WAS REQUIRED TO TAKE THE VEHICLE TO GMC DEALER IN INVER GROVE HEIGHTS, MN WHERE THE SAME EXACT PARTS WERE REPLACED AGAIN! I HAVE ALL RECEIPTS.
NHTSA ODI #10806386
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration