NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
22 reportsClear category filter95,000 miles · Jan 4, 2018
Fuel/propulsion System
2012 ACADIA NEEDED A REPLACEMENT OF THE NUMBER 2 FUEL INJECTOR IN 2015, NUMBER 4 IN 2016, AND AT THE END OF 2017 REQUIRED ALL 6 REPLACED, PLUS THE FUEL PUMP. ALL 3 TIMES THESE ISSUED OCCURRED WHILE I WAS DRIVING ON THE FREEWAY WHEN THE VEHICLE WARNINGS OF SERVICE STABILITRAK, SERVICE TRACTION CONTROL, AND REDUCED ENGINE POWER S…
Read full complaint
2012 ACADIA NEEDED A REPLACEMENT OF THE NUMBER 2 FUEL INJECTOR IN 2015, NUMBER 4 IN 2016, AND AT THE END OF 2017 REQUIRED ALL 6 REPLACED, PLUS THE FUEL PUMP. ALL 3 TIMES THESE ISSUED OCCURRED WHILE I WAS DRIVING ON THE FREEWAY WHEN THE VEHICLE WARNINGS OF SERVICE STABILITRAK, SERVICE TRACTION CONTROL, AND REDUCED ENGINE POWER STARTED GOING OFF. THE CAR THEN BEGAN TO SMOKE HEAVILY FROM THE EXHAUST PIPE AND IT WAS REQUIRED TO LIMP OFF THE FREEWAY, PRAYING THAT I WOULDN'T BE HIT AS I WENT FROM 75 TO 40 IN SECONDS.
NHTSA ODI #11058557
79,000 miles · Jan 2, 2018
Electrical SystemFuel/propulsion SystemVehicle Speed Control
TL-CONTACT OWNS A 2012 GMC ACADIA ---- CONTACT HAS HAD ISSUE LOSING TRACTION CONTROL ON VEHICLE --- STABILITY SYSTEM DOES NOT STAY ON ---- CONTACT WAS ON INTERSTATE GOING 70MPH AND TRACTION CONTROL WENT OFF --- TRACTION CONTROL WENT OFF A SECOND TIME AND ENGINE STARTED SMOKING WHILE DRIVING --- VEHICLE WAS TAKEN TO LOCAL DEALERS…
Read full complaint
TL-CONTACT OWNS A 2012 GMC ACADIA ---- CONTACT HAS HAD ISSUE LOSING TRACTION CONTROL ON VEHICLE --- STABILITY SYSTEM DOES NOT STAY ON ---- CONTACT WAS ON INTERSTATE GOING 70MPH AND TRACTION CONTROL WENT OFF --- TRACTION CONTROL WENT OFF A SECOND TIME AND ENGINE STARTED SMOKING WHILE DRIVING --- VEHICLE WAS TAKEN TO LOCAL DEALERSHIP AND DEALERSHIP STATED GAS PUMP WAS FAULTY... GAS PUMP WAS FIXED ... ENGINE WAS SMOKING AGAIN TWO DAYS AGO AND CHECK ENGINE LIGHT IS ON.... CONTACT WAS GIVEN NUMBER TO GM --- 0 RECALLS ASSOCIATED WITH THIS VIN.... CB
NHTSA ODI #11057953
60,000 miles · Sep 10, 2017
Fuel/propulsion System
AUTOMOBILE STALLED WHILE DRIVING AND WOULD NOT START. SERVICE COMPLETED AT CHEVROLET DEALERSHIP ON JUNE 12 TO REPLACE FUEL PUMP CONTROL MODULE, WHICH WAS A RECALLED PART ON GMC ACADIA'S. I CALLED GM AND WAS INFORMED MY VIN WAS NOT PART OF RECALL AND WAS TOLD I WOULD BE CALLED BACK WITH AN EXPLANATION WHY. I NEVER RECEIVED A R…
Read full complaint
AUTOMOBILE STALLED WHILE DRIVING AND WOULD NOT START. SERVICE COMPLETED AT CHEVROLET DEALERSHIP ON JUNE 12 TO REPLACE FUEL PUMP CONTROL MODULE, WHICH WAS A RECALLED PART ON GMC ACADIA'S. I CALLED GM AND WAS INFORMED MY VIN WAS NOT PART OF RECALL AND WAS TOLD I WOULD BE CALLED BACK WITH AN EXPLANATION WHY. I NEVER RECEIVED A RETURN PHONE CALL. CAR STALLED AGAIN WHILE DRIVING AND WOULD NOT START. SERVICE COMPLETED AT GMC DEALERSHIP ON AUGUST 12 TO REPLACE FUSE BLOCK THAT CONTROLS FUEL PUMP. APPROXIMATELY 2 WEEKS LATER CAR STALLED WHILE DRIVING, THEN RESTARTED. RETURNED CAR TO CHEVROLET DEALERSHIP FOR SERVICE. THEY HELD CAR 8 DAYS BUT COULD NOT FIND SOURCE OF PROBLEM, THOUGH THOUGHT IT WAS THE FUEL PUMP. CAR STALLED AGAIN ON SEPTEMBER 8 THEN RESTARTED. BROUGHT TO CHEVROLET DEALERSHIP FOR SERVICE BUT AGAIN THEY FOUND NO SERVICE CODE. WAS INFORMED WITH THE NUMBER OF MILES ON VEHICLE, 60,100, I SHOULD NOT BE HAVING THESE ISSUES. CAR STALLED AGAIN ON SEPTEMBER 10 AND WILL NOT RESTART. WILL NEED TO, AGAIN, BRING IN FOR SERVICE. COMPLAINT IS IN REGARD TO VEHICLE RECALL FOR MY YEAR AND MODEL, BUT NOT FOR MY SPECIFIC VIN, EVEN THOUGH RECALL PROBLEM EXISTS WITH MY VEHICLE. HAVE HAD CAR SERVICED AT GM DEALERSHIPS TWICE AT EXPENSE OF OVER $1,000 FOR THE SAME ISSUE AND ISSUE PERSISTS. GM HAS NOT RESPONDED AND GM DEALERSHIPS HAVE BEEN UNABLE TO SOLVE PROBLEM.
NHTSA ODI #11022514
55,000 miles · Mar 1, 2017
Electrical SystemFuel/propulsion System
TODAY WITH THE FUEL GAUGE SHOWING 1/2 TANK FULL, MY ACADIA RAN OUT OF GAS AND I WAS FORCED TO THE SIDE OF THE ROAD. I HAVE SEEN RECALLS FOR OTHER YEAR MODELS FOR THIS EXACT PROBLEM, BUT THE YEAR MY ACADIA IS DOES NOT MATTER TO GM. THIS IS A VERY SERIOUS PROBLEM THAT COULD CAUSE A SEVERE ACCIDENT. GM'S RECALL NUMBER IS 14007. IN…
Read full complaint
TODAY WITH THE FUEL GAUGE SHOWING 1/2 TANK FULL, MY ACADIA RAN OUT OF GAS AND I WAS FORCED TO THE SIDE OF THE ROAD. I HAVE SEEN RECALLS FOR OTHER YEAR MODELS FOR THIS EXACT PROBLEM, BUT THE YEAR MY ACADIA IS DOES NOT MATTER TO GM. THIS IS A VERY SERIOUS PROBLEM THAT COULD CAUSE A SEVERE ACCIDENT. GM'S RECALL NUMBER IS 14007. IN THE AFFECTED VEHICLES, THE ENGINE CONTROL MODULE (ECM) SOFTWARE MAY CAUSE THE FUEL GAUGE TO READ INACCURATELY. AN INACCURATE FUEL GAUGE MAY RESULT IN THE VEHICLE UNEXPECTEDLY RUNNING OUT OF FUEL AND STALLING, INCREASING THE RISK OF A CRASH.THEY KNOW THERE IS A PROBLEM WHY NOT FIX IT.
NHTSA ODI #10957923
86,000 miles · Dec 12, 2016
Fuel System, GasolineFuel/propulsion System
TRUCK HAS A HORRIBLE FUEL SYSTEM. DRIVING DOWN THE HIGHWAY AND LOST POWER IN VEHICLE. LESS THAN 90K MILES. 2 BAD FUEL INJECTORS ALREADY, A FUEL PUMP REPLACEMENT, NOT TO MENTION OTHER MECHANICAL ISSUES. *TR
NHTSA ODI #10934781
133,000 miles · Sep 28, 2016
Fuel/propulsion System
CHASSIS ELECTRONIC CONTROL MODULE INTERNAL CONTAMINATION - GMC RECALL 14515 - THIS IS A RECALL ON A LOT OF GM CARS AND TRUCKS WHICH INCLUDES THE 2012 GMC ACADIA BUT MY VIN DOESN'T QUALIFY. THIS CONTROL MODULE IS EXPOSED TO WATER AND ALL OF THE ELEMENTS WHICH IS WHY THERE IS A RECALL. OURS FAILED YESTERDAY AT HIGHWAY SPEEDS AND …
Read full complaint
CHASSIS ELECTRONIC CONTROL MODULE INTERNAL CONTAMINATION - GMC RECALL 14515 - THIS IS A RECALL ON A LOT OF GM CARS AND TRUCKS WHICH INCLUDES THE 2012 GMC ACADIA BUT MY VIN DOESN'T QUALIFY. THIS CONTROL MODULE IS EXPOSED TO WATER AND ALL OF THE ELEMENTS WHICH IS WHY THERE IS A RECALL. OURS FAILED YESTERDAY AT HIGHWAY SPEEDS AND THE CAR DIED AT 60 MPH. WE WERE LUCKY TO BE HEADING TO THE EXIT WHEN IT DIED AND NOT INVOLVED IN A CRASH. I'VE SPOKEN TO 3 GMC SERVICE CENTERS IN THE AREA AND THE GMC ASSISTANCE CENTER AND THEY TELL ME THAT MY VIN DOES NOT HAVE ANY RECALLS. VERY DANGEROUS SITUATION THAT OCCURRED AND ALL OF THESE VEHICLES NEED TO BE FIXED.
NHTSA ODI #10910150
Mileage unknown · Nov 24, 2015
Fuel/propulsion SystemPower TrainSteering
THE FIRST THING THAT I WANT TO SAY IS THAT SOME OF THE RECALLS ARE NOT FOR THE 2012 MODEL BUT MINE HAS HAD THE ISSUES WITH THE FUEL MODULER NOT READING CORRECTLY AS IN ONE RECALL AND ALSO THE SHIFTER CLIP CAUSING THE VEHICLE TO NOT BE IN THE CORRECT GEAR. WHAT DO I DO? ALSO THE SECOND THING IS THE A/C BROKE WITHIN THE 3RD YEAR O…
Read full complaint
THE FIRST THING THAT I WANT TO SAY IS THAT SOME OF THE RECALLS ARE NOT FOR THE 2012 MODEL BUT MINE HAS HAD THE ISSUES WITH THE FUEL MODULER NOT READING CORRECTLY AS IN ONE RECALL AND ALSO THE SHIFTER CLIP CAUSING THE VEHICLE TO NOT BE IN THE CORRECT GEAR. WHAT DO I DO? ALSO THE SECOND THING IS THE A/C BROKE WITHIN THE 3RD YEAR OF HAVING IT. THE THIRD THING TO GO WRONG IS THE POWER STEERING. IT COMES AND GOES BUT AS LONG AS I PUSH ON THE GAS I HAVE POWER STEERING. I'M VERY CONCERNED ABOUT THE FUEL MODULER BECAUSE MY DAUGHTER DRIVES THIS VEHICLE ALSO TRAVELING THE INTERSTATE TO WORK AND ALSO A VERY POPULATED SECONDARY ROAD.
NHTSA ODI #10806407
29,000 miles · Nov 18, 2015
Fuel/propulsion System
HIGHWAY, VEHICLE IN FRONT KICKED UP A BACKPACK UNABLE TO AVOID, WHEN SPEED WAS LOWERED, ODOR OF GASOLINE NOTICED, STOPPED, FUEL TANK LEAKING, TOWED TO NEAREST DEALER. PHOTO ATTACHED
NHTSA ODI #10794624
40,000 miles · Jun 11, 2015
Fuel/propulsion System
MY FUEL GAUGE IS READING EMPTY AND THE MILES LEFT IS NOT WORKING. EVEN THOUGH I HAVE GAS IN THE TANK.
NHTSA ODI #10724833
1,500 miles · Aug 28, 2014
Equipment Adaptive/mobilityFuel/propulsion SystemPower Train
EITHER I GOT A LEMON, WHICH IS DEFINITELY A POSSIBILITY, OR THERE ARE SIGNIFICANT ISSUES W/ GMC AS A MANUFACTURER WHICH IS EVIDENT. THE AMERICAN CAR INDUSTRY JUST WON'T DO BUSINESS DIFFERENTLY BUT THEN AGAIN, THEY DON'T HAVE TO- THEY GET BAILED OUT BY THE GOVERNMENT REPEATEDLY. I LEASED THIS VEHICLE IN OCTOBER, 2012. THE IS…
Read full complaint
EITHER I GOT A LEMON, WHICH IS DEFINITELY A POSSIBILITY, OR THERE ARE SIGNIFICANT ISSUES W/ GMC AS A MANUFACTURER WHICH IS EVIDENT. THE AMERICAN CAR INDUSTRY JUST WON'T DO BUSINESS DIFFERENTLY BUT THEN AGAIN, THEY DON'T HAVE TO- THEY GET BAILED OUT BY THE GOVERNMENT REPEATEDLY. I LEASED THIS VEHICLE IN OCTOBER, 2012. THE ISSUES CITED ABOVE, WERE RELATED TO 3 BAD FUEL IGNITION VALVES, THEY WERE REPLACED FINALLY AFTER I TOOK THE CAR BACK TO 2 DIFFERENT DEALERS AND NEARLY 6 MONTHS OF COMPLAINING. THE ISSUE WAS WHEN ACCELERATING, THE RPMS WOULD STICK AT AROUND 5-6 WHEN I WAS TRAVELING AROUND SPEEDS OF 45 MPH TO 60 MPH. THE TRANSMISSION WOULDN'T SHIFT INTO THE NEXT GEAR. THIS WAS HIGHWAY DRIVING, BUT WILL HAPPEN ON 4 LANE ROADS AS WELL. DURING THE SAME TIME FRAME, THE STABILITY OF THE CAR IN ICE/SNOW ONLY WORKED IF THE TOW PACKAGE FEATURE WAS TURNED ON. OTHERWISE, I SPUN OUT LEAVING OUR NEIGHBORHOOD GOING DOWN A SLOPE AT SPEEDS OF LESS THAN 30 MPH. DEALER SAID IT DIDN'T MAKE SENSE AND DID NOTHING. I JUST KEEP THE TOW FEATURE ON DURING SNOW/ICE/RAIN. ELECTRICAL ISSUES, HEATING/COOLING SYSTEM WASN'T WORKING CORRECTLY, IT WASN'T HEATING UNLESS THE TEMP WAS PUT AT 80 DEGREES. ONLY THING DEALER WOULD CONCEDE WAS THERE WAS A KINK IN THE HOSE. IT'S HAPPENING AGAIN- WE HAVE TO SET THE A/C AT 60 IN ORDER FOR IT TO COOL THE CAR DOWN. VERY DISAPPOINTED IN THIS CAR. ONCE AGAIN, THE ISSUE WITH THE RPMS AND HEATING/COOLING SYSTEM IS HAPPENING AGAIN. I'M PAYING OFF THIS LEASE EARLY AND HOPEFULLY WILL NOT GET A PENALTY. THIS IS A POORLY MADE CAR. *TR
NHTSA ODI #10629017
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration