NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
41 reportsClear category filter18,000 miles · Feb 27, 2019
Electrical SystemFuel/propulsion System
TL* THE CONTACT OWNS A 2012 GMC ACADIA. THE CONTACT STATED THAT THE FUEL GAUGE DISPLAYED THE INCORRECT AMOUNT OF FUEL IN THE VEHICLE. WHEN THE CONTACT FILLED UP THE FUEL TANK, THE GAUGE REMAINED ON EMPTY. THE CHECK ENGINE, OIL, AND MULTIPLE UNKNOWN WARNING INDICATORS ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. T…
Read full complaint
TL* THE CONTACT OWNS A 2012 GMC ACADIA. THE CONTACT STATED THAT THE FUEL GAUGE DISPLAYED THE INCORRECT AMOUNT OF FUEL IN THE VEHICLE. WHEN THE CONTACT FILLED UP THE FUEL TANK, THE GAUGE REMAINED ON EMPTY. THE CHECK ENGINE, OIL, AND MULTIPLE UNKNOWN WARNING INDICATORS ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 18,000.
NHTSA ODI #11182868
115,000 miles · Feb 14, 2019
Electrical SystemExterior Lighting
MY LOW BEAM HEAD LIGHTS KEEP BLOWING OVER THE PAST TWO YEARS, I HAVE HAD TO REPLACE THEM 5 TIMES ON THE DRIVER SIDE AND 2 TIMES ON THE PASSENGER SIZE. ALSO HAD MY HEAD LIGHT HARNESS REPLACED OCT DUE THE BLUB BREAKING IN MULTIPLE PIECES. JAN OF 2019, IT RAINED AND MY TURNING SIGNAL BLUB BROKE AGAIN AND THE LIGHTING COMPONENT F…
Read full complaint
MY LOW BEAM HEAD LIGHTS KEEP BLOWING OVER THE PAST TWO YEARS, I HAVE HAD TO REPLACE THEM 5 TIMES ON THE DRIVER SIDE AND 2 TIMES ON THE PASSENGER SIZE. ALSO HAD MY HEAD LIGHT HARNESS REPLACED OCT DUE THE BLUB BREAKING IN MULTIPLE PIECES. JAN OF 2019, IT RAINED AND MY TURNING SIGNAL BLUB BROKE AGAIN AND THE LIGHTING COMPONENT FILLED UP WITH WATER AND LOOKED LIKE A FLOATING FISH BOWL.
NHTSA ODI #11180128
84,000 miles · Feb 12, 2019
Electrical SystemEngineSteering
WE BOUGHT THIS USED CAR FROM A DEALER DROVE IT ABOUT 4 TO 5 MONTHS AND THE LEFT SIGNAL LIGHT FAILED, SO WE CHANGED IT WORKED FOR ONE DAY AND THEN WENT DEAD AGAIN. TURNING LEFT FROM MY STREET THE STEERING WAS REALLY HARD AND HAD PROBLEMS TURNING LEFT BUT I DID FINALLY ON ANOTHER OCCASION THE SAME THING HAPPENED. FINALLY DRIVING …
Read full complaint
WE BOUGHT THIS USED CAR FROM A DEALER DROVE IT ABOUT 4 TO 5 MONTHS AND THE LEFT SIGNAL LIGHT FAILED, SO WE CHANGED IT WORKED FOR ONE DAY AND THEN WENT DEAD AGAIN. TURNING LEFT FROM MY STREET THE STEERING WAS REALLY HARD AND HAD PROBLEMS TURNING LEFT BUT I DID FINALLY ON ANOTHER OCCASION THE SAME THING HAPPENED. FINALLY DRIVING SUDDENLY WE SAW A TURN ENGINE OFF AND THE ENGINE STARTED MAKING LOUD NOISES AND WENT DEAD IN THE MIDDLE OF THE STREET. SO WE KEPT GLIDING WITH NO ENGINE RUNNING AND WENT INTO A PARKING LOT. LUCKY FOR US THE CAR STOPPED RIGHT IN THE PARKING LOT. HAD TO BE TOWED FEW MILES TO A MECHANIC THAT TOLD US THE TIMING CHAIN IS BROKEN AND IN NEED FOR NEW ENGINE. WE TOWED IT TO ANOTHER MECHANIC AND THE SAME THING WAS TOLD. SO NOW IT IS BEEN SITTING AT THE MECHANIC'S SHOP FOR TWO WEEK WAITING FOR NEW ENGINE TO COME IN . I CAN NOT BELIEVE THAT AROUND 84000 MILES THIS CAR NEEDS A NEW ENGINE AND IT IS NOT CHEAP AT ALL. THE CAR HAS A SALVAGE TILTE BUT THIS DOES NOT HAVE ANYTHING TO DO WITH THE PROBLEMS SINCE TOO MANY PEOPLE HAVE BEEN DOCUMENTING THIS PROBLEM, STEERING, ELECTRICAL AND FAILED ENGINE. WHY GM DID NOT RECALL THESE CARS FOR THESE FAILURE. THEY ARE PUTTING PEOPLE AND FAMILIES AT RISK AND WE ARE STUCK WITH THE REPAIRS AND THE BILLS PILING UP.
NHTSA ODI #11176450
150,000 miles · Dec 29, 2018
Electrical System
WIPERS SUDDENLY STOPPED DURING A HEAVY RAIN AT HIGHWAY SPEEDS. MY WIFE AND THREE CHILDREN WERE ON BOARD. THE STUD THAT CONNECTS THE WIPER LINKAGE TO THE MOTOR HAD BROKEN. UPON RESEARCHING THIS, GM HAD ISSUED A RECALL TO AFFECTED VEHICLES IN STATES THAT RECEIVED HEAVY SNOWFALL, WEST VIRGINIA WAS INCLUDED AND WAS WHERE THIS VEHICL…
Read full complaint
WIPERS SUDDENLY STOPPED DURING A HEAVY RAIN AT HIGHWAY SPEEDS. MY WIFE AND THREE CHILDREN WERE ON BOARD. THE STUD THAT CONNECTS THE WIPER LINKAGE TO THE MOTOR HAD BROKEN. UPON RESEARCHING THIS, GM HAD ISSUED A RECALL TO AFFECTED VEHICLES IN STATES THAT RECEIVED HEAVY SNOWFALL, WEST VIRGINIA WAS INCLUDED AND WAS WHERE THIS VEHICLE SPENT MOST OF ITS LIFE. AFTER CALLING GM THEY TOLD ME THEY COULDN'T DO ANYTHING FOR ME SINCE THE VEHICLE IS NOW GARAGED IN TENNESSEE.
NHTSA ODI #11163904
72,282 miles · Apr 24, 2018
Electrical SystemExterior LightingVisibility/wiper
I HAVE HAD TO REPLACE THE HEADLIGHT BULB AND THE DAY LIGHT BULBS 4 TIMES SINCE JANUARY. EACH TIME I REPLACE ONE THE OTHER GOES OUT AND IT DOES'T LAST LONGER THAN A FEW WEEKS. THIS IS VERY DANGEROUS AND STRESSFUL AS THE HEADLIGHTS WENT OUT ON ME AS I WAS DRIVING HOME TWO NIGHTS AGO AND THE ROAD THAT I TAKE TO GET HOME IS VERY DAR…
Read full complaint
I HAVE HAD TO REPLACE THE HEADLIGHT BULB AND THE DAY LIGHT BULBS 4 TIMES SINCE JANUARY. EACH TIME I REPLACE ONE THE OTHER GOES OUT AND IT DOES'T LAST LONGER THAN A FEW WEEKS. THIS IS VERY DANGEROUS AND STRESSFUL AS THE HEADLIGHTS WENT OUT ON ME AS I WAS DRIVING HOME TWO NIGHTS AGO AND THE ROAD THAT I TAKE TO GET HOME IS VERY DARK. ALSO, I HAD TO REPLACE THE MULTI FUNCTION SWITCH (WINDSHIELD WIPER SWITCH DUE TO IT ONLY WORKING ON HIGH SPEED) IN JANUARY. I'VE NOTICED MULTIPLE PEOPLE WITH THE SAME COMPLAINTS. PLEASE FIX THIS PROBLEM AS BUYING BULBS ARE BECOMING EXPENSIVE AS WELL AS THE TIME IT TAKES TO GET THEM REPLACED CAN BE LENGTHY.
NHTSA ODI #11089983
Mileage unknown · Mar 21, 2018
Electrical SystemElectronic Stability Control (esc)Exterior Lighting
I HAVE BEEN CHANGE MANY TIMES THE HEADLIGHT DAY LIGHT OF THE DRIVER SIDE, STABILITY CONTROL GOING ON AND STOP MY MOVEMENT, I AVE TO WAIT FOR 5-10 MINUTES AND UNBLOCK BY ITSELF, AND THE BOTTOM OF THE REAR AC SOMETIMES ARE SUPER HOT.
NHTSA ODI #11080412
108,000 miles · Feb 18, 2018
Electrical SystemUnknown Or Other
LIFT GATE WOULD NOT OPEN, TRIED TO OPEN MY DRIVER DOOR TO OPEN IT FROM THERE AND IT STILL WOULD NOT WORK. TRIED TO CRANK CAR AND IT MADE A LOT OF CLICKING NOISES AND LOOKED AS IF THE BATTERY WAS DEAD BUT THEN ALL OF MY DOORS STARTED MAKING CLICKING NOISES. WON'T START. WON'T RELEASE KEY.
NHTSA ODI #11073516
79,000 miles · Jan 2, 2018
Electrical SystemFuel/propulsion SystemVehicle Speed Control
TL-CONTACT OWNS A 2012 GMC ACADIA ---- CONTACT HAS HAD ISSUE LOSING TRACTION CONTROL ON VEHICLE --- STABILITY SYSTEM DOES NOT STAY ON ---- CONTACT WAS ON INTERSTATE GOING 70MPH AND TRACTION CONTROL WENT OFF --- TRACTION CONTROL WENT OFF A SECOND TIME AND ENGINE STARTED SMOKING WHILE DRIVING --- VEHICLE WAS TAKEN TO LOCAL DEALERS…
Read full complaint
TL-CONTACT OWNS A 2012 GMC ACADIA ---- CONTACT HAS HAD ISSUE LOSING TRACTION CONTROL ON VEHICLE --- STABILITY SYSTEM DOES NOT STAY ON ---- CONTACT WAS ON INTERSTATE GOING 70MPH AND TRACTION CONTROL WENT OFF --- TRACTION CONTROL WENT OFF A SECOND TIME AND ENGINE STARTED SMOKING WHILE DRIVING --- VEHICLE WAS TAKEN TO LOCAL DEALERSHIP AND DEALERSHIP STATED GAS PUMP WAS FAULTY... GAS PUMP WAS FIXED ... ENGINE WAS SMOKING AGAIN TWO DAYS AGO AND CHECK ENGINE LIGHT IS ON.... CONTACT WAS GIVEN NUMBER TO GM --- 0 RECALLS ASSOCIATED WITH THIS VIN.... CB
NHTSA ODI #11057953
80,123 miles · Oct 31, 2017
Electrical System
MY GMC ACADIA DENALI HAS A LITTLE OVER 80,000 MILES. I HAVE OTHER VEHICLES FOR EVERYDAY USE SO I ONLY DRIVE THE ACADIA FOR LONG DISTANCES OVER THE WEEKEND. THE VEHICLE SITS IN THE GARAGE WHEN NOT IN USE. I HAVE HAD NO ISSUES WITH THE VEHICLE UNTIL I TOOK IT TO THE DEALER TO HAVE ONE OF THE HEAD LIGHT BULBS ON THE PASSENGER SIDE…
Read full complaint
MY GMC ACADIA DENALI HAS A LITTLE OVER 80,000 MILES. I HAVE OTHER VEHICLES FOR EVERYDAY USE SO I ONLY DRIVE THE ACADIA FOR LONG DISTANCES OVER THE WEEKEND. THE VEHICLE SITS IN THE GARAGE WHEN NOT IN USE. I HAVE HAD NO ISSUES WITH THE VEHICLE UNTIL I TOOK IT TO THE DEALER TO HAVE ONE OF THE HEAD LIGHT BULBS ON THE PASSENGER SIDE REPLACED. AFTER I PICKED THE VEHICLE UP I DROVE IT TO NEW YORK AND ON MY WAY BACK (THE NEXT DAY) HAD THE SERVICE LIGHT COME ON TO LET ME KNOW THERE WAS A PROBLEM WITH THE BATTERY. I LOOKED AT THE BATTERY INDICATOR IN THE DASH AND NOTICED THE CHARGE WAS GETTING LOWER AND LOWER. BY THE TIME I GOT TO BALTIMORE, MD THE INDICATOR WAS BELOW 12 AND THE VEHICLE FINALLY SHUT OFF. TOWED THE VEHICLE TO THE DEALERSHIP AND THEY FIRST REPLACED THE BATTERY BUT THAT DIDN'T FIX THE PROBLEM. THEY THEN REPLACED THE ALTERNATOR. I DROVE THE VEHICLE THREE TIMES AND IT WORKED FINE. THREE WEEKS LATER I TRIED TO START THE VEHICLE AND HAD NO BATTERY POWER. TRIED JUMPING THE VEHICLE BUT IT WOULD NOT GATHER ENOUGH POWERE TO START THE ENGINE. HAD THE VEHICLE TOWED TO THE DEALER. THEY SAID THAT THE NEW BATTERY THAT WAS INSTALLED HAD A BAD CELL. I AM AFRAID THAT'S NOT THE ISSUE; IT'S OBVIOUS THAT SOMETHING IS DRAINING THE BATTERY WHEN THE CAR IS NOT IN OPERATION AND IT ALL STARTED WHEN I HAD THE HEADLAMP. I THINK GM IS AWARE OF ELECTRICAL ISSUES WITH THE ACADIA. I JUST WANT TO MAKE SURE I PUT THIS COMPLAINT OUT THERE. I AM NOT CONFIDENT THAT THIS PROBLEM WON'T OCCUR THREE WEEKS FROM NOW.
NHTSA ODI #11041567
80,350 miles · Oct 13, 2017
Electrical System
WHEN DRIVING OR EVEN AFTER JUST SITTING FOR A WHILE WITHOUT THE CONTROLS ON OR OFF THE BACK PANEL THAT CONTROLS THE HEAT AND AIR IN THE SECOND ROW THE KNOBS ARE EXTREMELY HOT TO THE TOUCH. I HAVE CHILDREN AND GRANDCHILDREN THAT SIT IN THE SECOND ROW DAILY AND THIS HAS HAPPENED SINCE PURCHASING THE VEHICLE.
NHTSA ODI #11033185
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration