NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
343 reports116,000 miles · Nov 7, 2014
SuspensionCrashInjury
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL BEGAN TO VIBRATE ACCOMPANIED BY A LOUD POPPING NOISE. THE CONTACT ATTEMPTED TO TURN LEFT BUT THE STEERING WHEEL TRAVELED IN THE OPPOSITE DIRECTION WHICH CAUSED THE CONTACT TO CRASH INTO TWO VEHICLES. AFTER INSPECTI…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL BEGAN TO VIBRATE ACCOMPANIED BY A LOUD POPPING NOISE. THE CONTACT ATTEMPTED TO TURN LEFT BUT THE STEERING WHEEL TRAVELED IN THE OPPOSITE DIRECTION WHICH CAUSED THE CONTACT TO CRASH INTO TWO VEHICLES. AFTER INSPECTING THE VEHICLE, THE CONTACT OBSERVED THAT THE FRONT PASSENGER SIDE STRUT WAS FRACTURED AND SEPARATED FROM THE VEHICLE. THE FAILURE HAD OCCURRED PREVIOUSLY ON THE OPPOSITE SIDE. THE CONTACT SUSTAINED HAND INJURIES WHICH DID NOT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS THEN TOWED TO THE CONTACTS RESIDENCE AND HAD NOT BEEN DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
NHTSA ODI #10653250
65,279 miles · Nov 3, 2014
Electrical SystemExterior LightingFire
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 30 MPH, THE CONTACT SMELLED SMOKE. THE BULB OVERHEATED AND CAUSED THE SOCKET AND WIRES TO BURN AND THE HEADLIGHT HOUSING TO MELT. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S RECALL FOR A RELATED FAILURE IN 2013. THE VEHICLE WAS TAKEN …
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 30 MPH, THE CONTACT SMELLED SMOKE. THE BULB OVERHEATED AND CAUSED THE SOCKET AND WIRES TO BURN AND THE HEADLIGHT HOUSING TO MELT. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S RECALL FOR A RELATED FAILURE IN 2013. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BULB OVERHEATED AND CAUSED THE SOCKET, THE WIRES, AND THE HEADLIGHT HOUSING UNIT TO BURN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,279.
NHTSA ODI #10652035
41,891 miles · Oct 31, 2014
Electrical System
DAYTIME RUNNING LIGHT WENT OUT AND I WAS CHARGED $106.02 TO HAVE MY BULB CHANGED.AFTER THAT IT WENT OUT AGAIN. THEN I GOT A RECALL FOR THE DAYTIME RUNNING LIGHTS AND TOOK IT IN AGAIN TO HAVE THEM INSTALL A NEW GASKET AND REINFORCEMENT PLATE. SINCE THEN MY LIGHT HASD GONE OUT A FEW MORE TIMES. ABOUT A WEEK AFTER THEY REPAIRED IT,…
Read full complaint
DAYTIME RUNNING LIGHT WENT OUT AND I WAS CHARGED $106.02 TO HAVE MY BULB CHANGED.AFTER THAT IT WENT OUT AGAIN. THEN I GOT A RECALL FOR THE DAYTIME RUNNING LIGHTS AND TOOK IT IN AGAIN TO HAVE THEM INSTALL A NEW GASKET AND REINFORCEMENT PLATE. SINCE THEN MY LIGHT HASD GONE OUT A FEW MORE TIMES. ABOUT A WEEK AFTER THEY REPAIRED IT, I SMELLED SOMETHING BURNING. THE LIGHT ASSEMBLY HAD MELTED AND THE SOCKET AND WIRES WERE MELTED TO . THIS RECALL WAS NOT FIXED CORRECTLY. LOOKING ONLINE I SEE THAT I AM NOT ALONE. I JUST WANT GM TO DO THE RIGHT THING AND REPAIR IT. THIS IS A SAFETY HAZARD. *TR
NHTSA ODI #10651706
62,000 miles · Oct 20, 2014
Air BagsSeat BeltsSteering
I HAVE HAD 3 RECALLS ON MY 4 YEAR OLD ACADIA IN THE LAST SEVERAL MONTHS AND ALSO HAD TO REPLACE MY POWER STEERING AT LESS THAN 65,000 MILES. MY CAR IS BACK AT THE DEALER FOR THE THIRD TIME IN LESS THAN 10 DAYS FOR THE SERVICE AIR BAG LIGHT AFTER THEY HAVE ATTEMPTED TO FIX THE RECALL. ALTHOUGH NO SPECIFIC SAFETY INCIDENT, MY CON…
Read full complaint
I HAVE HAD 3 RECALLS ON MY 4 YEAR OLD ACADIA IN THE LAST SEVERAL MONTHS AND ALSO HAD TO REPLACE MY POWER STEERING AT LESS THAN 65,000 MILES. MY CAR IS BACK AT THE DEALER FOR THE THIRD TIME IN LESS THAN 10 DAYS FOR THE SERVICE AIR BAG LIGHT AFTER THEY HAVE ATTEMPTED TO FIX THE RECALL. ALTHOUGH NO SPECIFIC SAFETY INCIDENT, MY CONCERNS WITH THE ABILITY OF THE DEALER/AUTOMAKER TO PROVIDE A SAFE VEHICLE AND WELL AS THE OVERALL LACK OF RELIABILITY OF THE CAR IN LESS THAN 4 YEARS IS BOTH DISAPPOINTING AND CONCERNING. I AM CURRENTLY IN TOUCH WITH GMC ABOUT MY OPTIONS. *TR
NHTSA ODI #10648836
40,000 miles · Oct 17, 2014
Power Train
I HAVE TO KEEP ADDING POWER STEERING FLUID TO MY CAR. I HAVE BEEN TOLD THAT MY POWER TRAIN WILL NEED TO BE REPLACED AND THAT GMC IS AWARE OF THIS PROBLEM WITH THE ACADIA'S AND REFUSES TO FIX THE PROBLEM. *TR
NHTSA ODI #10648395
33,638 miles · Oct 9, 2014
Electrical SystemExterior Lighting
MY FRONT DAYTIME LIGHT STARTING GOING OF AND ON AND THEN STOPPED-WORKING AND WHEN IT WAS CHECKED BY THE GMC DEALER THEY FOUND THAT THE LIGHT FRAME HAS BEEN MELTED AND IT WOULD NOT HOLD A LIGHT. THEY WOULD NOT FIX IT UNLESS I PAID $1,100 WHICH I WOULD NOT DO. CALLED GMC AND THREE TIMES AND EACH TIME THEY SAID THEY WOULD CALL ME B…
Read full complaint
MY FRONT DAYTIME LIGHT STARTING GOING OF AND ON AND THEN STOPPED-WORKING AND WHEN IT WAS CHECKED BY THE GMC DEALER THEY FOUND THAT THE LIGHT FRAME HAS BEEN MELTED AND IT WOULD NOT HOLD A LIGHT. THEY WOULD NOT FIX IT UNLESS I PAID $1,100 WHICH I WOULD NOT DO. CALLED GMC AND THREE TIMES AND EACH TIME THEY SAID THEY WOULD CALL ME BACK WHICH THEY DID NOT DO. I CALLED BACK AGAIN AND WITHOUT EVEN TALKING TO ME SAID I AGREED TO PAY PART OF THE COST WHICH I DID NOT DO. I AM LEFT WITH AN UNSAFE SUV. *TR
NHTSA ODI #10643673
90,000 miles · Oct 4, 2014
Steering
WHILE TRYING TO ATTEMPT A RIGHT TURN ON A GREEN LIGHT AT APPROXIMATELY 10 MPH MY STEERING WHEEL DID NOT TURN. THIS WAS COMPLETELY UNEXPECTED AND I WAS CAUGHT OFF GUARD BUT MANAGED TO STOP THE VEHICLE INCHES AWAY FROM TRAFFIC COMING IN THE OPPOSITE DIRECTION. I BROUGHT IT IN FOR SERVICING AND WAS TOLD THE R&P NEEDED TO BE REPLACE…
Read full complaint
WHILE TRYING TO ATTEMPT A RIGHT TURN ON A GREEN LIGHT AT APPROXIMATELY 10 MPH MY STEERING WHEEL DID NOT TURN. THIS WAS COMPLETELY UNEXPECTED AND I WAS CAUGHT OFF GUARD BUT MANAGED TO STOP THE VEHICLE INCHES AWAY FROM TRAFFIC COMING IN THE OPPOSITE DIRECTION. I BROUGHT IT IN FOR SERVICING AND WAS TOLD THE R&P NEEDED TO BE REPLACED. THIS WAS DONE BUT THE ISSUE PERSISTS. THE DEALER CLAIMS THEY CAN NOT FIND ANY ISSUES WITH MY STEERING EVEN THOUGH WE HAVE BEEN ON TEST DRIVES WHERE THE STEERING LOCKS UP. TO THIS DAY THE PROBLEM CONTINUES ONLY AT LOW SPEEDS, BUT I WILL NOT LET MY FAMILY TRAVEL IN THIS VEHICLE. *TR
NHTSA ODI #10641378
51,000 miles · Sep 19, 2014
Steering
I FILED MY INITIAL COMPLAINT OVER THE PHONE BUT I'D LIKE TO ADD A FEW MORE DETAILS. AFTER GETTING NOWHERE WITH GMC CORPORATE I DID MY OWN RESEARCH UNCOVERING THERE IS A "CLASS ACTION LAWSUIT" (I HAVE THIS DOCUMENT AND CAN FORWARD IF NEEDED) IN PLACE FOR MULTIPLE GMC VEHICLES FOR THE STEERING ISSUE. GMC HAS PUBLICLY ADMITTE…
Read full complaint
I FILED MY INITIAL COMPLAINT OVER THE PHONE BUT I'D LIKE TO ADD A FEW MORE DETAILS. AFTER GETTING NOWHERE WITH GMC CORPORATE I DID MY OWN RESEARCH UNCOVERING THERE IS A "CLASS ACTION LAWSUIT" (I HAVE THIS DOCUMENT AND CAN FORWARD IF NEEDED) IN PLACE FOR MULTIPLE GMC VEHICLES FOR THE STEERING ISSUE. GMC HAS PUBLICLY ADMITTED TO INSTALLING WRONG SIZE POWER STEERING PUMP! IN ADDITION, THE POWER STEERING CABLE, A LOOSE RIVET IN STEERING COLUMN, POWER STEERING FLUID LEAKING, AND/OR NO OR LOW PRESSURE ALL HAVE BEEN THE SITED AS A "POSSIBLE" CAUSE! *MY POINT BEING FIXING ALL OF THESE ISSUES WILL COST OWNERS THOUSANDS OF DOLLARS AND MOST DON'T HAVE THIS MONEY. GMC NEEDS TO RECALL THIS ISSUE ASAP! GMC HAS RECALLED NUMEROUS OTHER NON-LIFETHREATENING ISSUES WITH THEIR VEHICLES. LOSS OF POWER STEERING WHEN TURNING LEFT ON A MAIN ROAD OR AT ANY OTHER TIME CAN AND WILL RESULT IN SERIOUS INJURY OR FATALITY!! THIS IS SERIOUS AND NEEDS TO BE MADE A PRIORITY ADDRESSED ASAP! *TR
NHTSA ODI #10637426
51,000 miles · Sep 18, 2014
Power TrainSteering
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE MAKING A LEFT TURN AT AN UNKNOWN SPEED, THE VEHICLE JERKED VIOLENTLY AND THE STEERING WHEEL SEIZED. THE CONTACT HAD TO FORCEFULLY TURN THE STEERING WHEEL. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE A…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE MAKING A LEFT TURN AT AN UNKNOWN SPEED, THE VEHICLE JERKED VIOLENTLY AND THE STEERING WHEEL SEIZED. THE CONTACT HAD TO FORCEFULLY TURN THE STEERING WHEEL. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.
NHTSA ODI #10637308
55,750 miles · Sep 11, 2014
Steering
WAS TURNING LEFT INTO A PARKING LOT AND THERE WAS NO ASSIST FROM THE POWER STEERING. IT WAS ALMOST AS IF IT WAS LOCKING UP. THIS ISSUE HAS BEEN OCCURRING SEVERAL TIMES A WEEK SINCE THEN, USUALLY AT LOW SPEEDS. THERE HAVE BEEN A COUPLE OF CLOSE CALLS TO HITTING OTHER VEHICLES AS THIS ISSUE SURFACES WITH NO WARNING. I ASKED LA…
Read full complaint
WAS TURNING LEFT INTO A PARKING LOT AND THERE WAS NO ASSIST FROM THE POWER STEERING. IT WAS ALMOST AS IF IT WAS LOCKING UP. THIS ISSUE HAS BEEN OCCURRING SEVERAL TIMES A WEEK SINCE THEN, USUALLY AT LOW SPEEDS. THERE HAVE BEEN A COUPLE OF CLOSE CALLS TO HITTING OTHER VEHICLES AS THIS ISSUE SURFACES WITH NO WARNING. I ASKED LAFONTAINE IN HIGHLAND MI TO LOOK AT IT WHEN I WAS HAVING WATER PUMP ISSUES. IT SEEMS THERE WAS NO TRUE INVESTIGATION ON THE ISSUE, JUST THAT IT WAS OUT OF WARRANTY AND I WOULD HAVE TO PAY TO CHANGE THE R&P, EVEN THOUGH THAT MAY NOT BE THE ISSUE. I ISSUED A COMPLAINT TO GM CUSTOMER SERVICE WHEN THE VEHICLE WAS IN THE SHOP AGAIN FOR A TRANSMISSION MODULE REPLACEMENT. AGAIN, NO CONCERN FROM GM THAT THE STEERING FAILS WITHOUT WARNING. LOSS OF STEERING IS A VERY BIG SAFETY CONCERN. I AM TRYING TO SELL OR TRADE IN THE VEHICLE AS I DO NOT FEEL SAFE HAVING MY WIFE AND KISS IN THE CAR. *TR
NHTSA ODI #10632445
Official recalls
4Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration