NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
74 reportsClear category filter97,700 miles · Jun 26, 2016
Engine
2010 GMC ACADIA POSSIBLE TIMING CHAIN STRETCH ISSUE. PURCHASED VEHICLE USED 2 YRS AGO NOW HAVE 96K MILES ON IT. YESTERDAY CAR WOULDN'T START AFTER BEING DRIVE 10 MINUTES EARLIER. PULLED CODES AND ALL POINTED TO THE 1,3, AND 5 CYLINDER IGNITION ISSUE. CLEARED CODES AND SEEMED TO BE FINE, DROVE 20 MILES WITH DEEP RESONATE SO…
Read full complaint
2010 GMC ACADIA POSSIBLE TIMING CHAIN STRETCH ISSUE. PURCHASED VEHICLE USED 2 YRS AGO NOW HAVE 96K MILES ON IT. YESTERDAY CAR WOULDN'T START AFTER BEING DRIVE 10 MINUTES EARLIER. PULLED CODES AND ALL POINTED TO THE 1,3, AND 5 CYLINDER IGNITION ISSUE. CLEARED CODES AND SEEMED TO BE FINE, DROVE 20 MILES WITH DEEP RESONATE SOUND AT CRUISE THAT WENT AWAY WHEN ACCELERATING AND DECELERATING. DRIVE BACK HOME SOUND REMAINED THE SAME AND CHECK ENGINE LIGHT CAME BACK ON. PULLED CODES ONCE AGAIN AND DIFFERENT SET CAME UP WITH P0008, P0016, AND P0017 SIGNIFYING TIMING ISSUES WHICH MAKES ME BELIEVE TIMING CHAIN STRETCH. I THINK I MIGHT BE IN FOR AN EXPENSIVE FIX BUT MOST I WANT THIS REPORTED TO MANUFACTURER TO MAYBE BE THE LAST STRAW TO INCLUDE MY YEAR VEHICLE RECALL. ANY INFO WOULD BE APPRECIATED.
NHTSA ODI #10876640
87,000 miles · Jun 22, 2016
Engine
HAVING THE SAME CHECK ENGINE LIGHT/TIMING CHAIN STRETCH ISSUE. AFTER RESEARCHING I FOUND THAT THESE MODELS OIL CHANGE CYCLE WERE TO BE SET AT 3000 MILES. OURS HAS BEEN 5000 MILES SINCE WE BOUGHT IT BRAND NEW IN MARCH 2010. I ALSO KNOW THAT THIS IS AN ISSUE ON MODELS THROUGH AT LEAST 2012 BUT GM STILL HAS NOT EXTENDED THE WARRANT…
Read full complaint
HAVING THE SAME CHECK ENGINE LIGHT/TIMING CHAIN STRETCH ISSUE. AFTER RESEARCHING I FOUND THAT THESE MODELS OIL CHANGE CYCLE WERE TO BE SET AT 3000 MILES. OURS HAS BEEN 5000 MILES SINCE WE BOUGHT IT BRAND NEW IN MARCH 2010. I ALSO KNOW THAT THIS IS AN ISSUE ON MODELS THROUGH AT LEAST 2012 BUT GM STILL HAS NOT EXTENDED THE WARRANTY TO THE SAME 10 YEARS/120,000 MILES AS THE 2007-2009 MODELS. OUR ACADIA HAS ONLY 87,000 MILES. THIS IS A $3000 FIX FOR AN ISSUE THAT GM KNOWS IS A PROBLEM.
NHTSA ODI #10875754
93,000 miles · Jun 15, 2016
Engine
WHILE DRIVING THE CHECK ENGINE LIGHT CAME ON. THE DEALERSHIP READ THE CODE AND DIAGNOSED THAT THE TIMING CHAINS NEEDED TO BE REPLACED. UNSAFE CONDITION THAT CAN CAUSE THE ENGINE TO STOP RUNNING WHILE BEING DRIVEN AT HIGHWAY SPEEDS. MY RESEARCH SHOWED GM EXTENDED WARRANTY AND COVERS COSTS FOR TIMING CHAIN REPLACEMENT ON THE 3.…
Read full complaint
WHILE DRIVING THE CHECK ENGINE LIGHT CAME ON. THE DEALERSHIP READ THE CODE AND DIAGNOSED THAT THE TIMING CHAINS NEEDED TO BE REPLACED. UNSAFE CONDITION THAT CAN CAUSE THE ENGINE TO STOP RUNNING WHILE BEING DRIVEN AT HIGHWAY SPEEDS. MY RESEARCH SHOWED GM EXTENDED WARRANTY AND COVERS COSTS FOR TIMING CHAIN REPLACEMENT ON THE 3.6 ENGINES FOR THE 2007-2009 MODEL YEARS, BUT NOT THE 2010. THE PROBLEM WITH THE 2007-2009 MODELS WERE THE CAR'S COMPUTER ALERTING THE ENGINE OIL NEEDED TO BE CHANGED TOO LATE AND DIRTY OIL WAS RESTRICTED FROM GOING TO LUBRICATE THE TIMING CHAINS AND RESULTED IN THE TIMING CHAINS STRETCHING AND WEARING PREMATURELY. I HAVE CONTACTED GM AND THEY WILL NOT PROVIDE ANY COVERAGE FOR THE 2010 MODELS. SAME PROBLEM IN THE 2007-2009 MODELS IS COVERED.
NHTSA ODI #10874337
117,000 miles · Apr 25, 2016
Engine
JUST BOUGHT MY ARCADIA JULY 2015 BACK IN DECEMBER THE ENGINE CAME ON HAD IT CHECKED OUT AND ERROR CODE P00008 WAS DETECTED GMC DOESN'T HAVE A RECALL ON THIS IT OBVIOUS THAT THIS PROBLEM ISN'T RESOLVED I'M PAYING $16000 FOR A VEHICLE THAT I HAVE TO INVEST MORE INTO MONEY INTO THAT I HAVEN'T EVEN A YEAR YET EVERY WHERE I LOOK A…
Read full complaint
JUST BOUGHT MY ARCADIA JULY 2015 BACK IN DECEMBER THE ENGINE CAME ON HAD IT CHECKED OUT AND ERROR CODE P00008 WAS DETECTED GMC DOESN'T HAVE A RECALL ON THIS IT OBVIOUS THAT THIS PROBLEM ISN'T RESOLVED I'M PAYING $16000 FOR A VEHICLE THAT I HAVE TO INVEST MORE INTO MONEY INTO THAT I HAVEN'T EVEN A YEAR YET EVERY WHERE I LOOK ABOUT DETAILS ABOUT THIS PROBLEM I KEEP FINDING THE SAME ANSWERS IT WOULD BE GREAT IF THEY WOULD FIX THIS PROBLEM BECAUSE I REALLY LIKE MY VEHICLE BUT I WILL NOT INVEST $3000 + IN A VEHICLE THAT I STILL OWE ON AND IT'S THE MANUFACTURER LIABILITY TO REPLACE!!!
NHTSA ODI #10861405
118,467 miles · Apr 11, 2016
EngineFuel System, Gasoline
ON 9 APR 2016 ON THE WAY TO A CHURCH FUNCTION, OUR 2010 ACADIA TOLD US IT WAS REDUCING ENGINE POWER AND STARTED MISSING AND SMOKING A LITTLE. THANKFULLY WE WERE JUST BLOCKS FROM THE HOUSE, SO WE TURNED AROUND AND LIMPED IT HOME. LATER I MOVED IT FROM THE DRIVEWAY TO THE STREET. THIS TIME, WHILE STILL MISSING, THE VEHICLE PUT…
Read full complaint
ON 9 APR 2016 ON THE WAY TO A CHURCH FUNCTION, OUR 2010 ACADIA TOLD US IT WAS REDUCING ENGINE POWER AND STARTED MISSING AND SMOKING A LITTLE. THANKFULLY WE WERE JUST BLOCKS FROM THE HOUSE, SO WE TURNED AROUND AND LIMPED IT HOME. LATER I MOVED IT FROM THE DRIVEWAY TO THE STREET. THIS TIME, WHILE STILL MISSING, THE VEHICLE PUT OUT A DENSE FOG OF WHITE SMOKE THAT SMELLED OF GASOLINE. THANKFULLY NO ONE LITE A MATCH. I USED MY OBD II CODE READER TO GET FAILURE CODES P0087 AND P0089 INDICATING LOW FUEL RAIL PRESSURE AND INJECTOR ISSUES. SUBSEQUENT RESEARCH ON-LINE LED ME TO TSB PIP4924D (NHTSA# 100419330). I NOW AM OF THE OPINION THAT THE ISSUE IS LIKELY A FUEL INJECTOR THAT IS STUCK OPEN LIKELY DUE TO A FUEL INJECTOR CONTROL LINE THAT IS SHORTING TO GROUND DUE TO BAD MANUFACTURER DESIGN OR IMPROPER MAINTENANCE BY DEALERS FIXING OTHER ISSUES. I VIEW THIS ISSUE AS A HUGE SAFETY PROBLEM. I CAN THINK OF ALL SORTS OF SCENARIOS WHERE THIS COULD CAUSE DANGER TO THE VEHICLE DRIVER AND PASSENGERS. A LITTLE ABOUT ME ... I'VE BEEN WORKING ON CARS FOR THE LAST 48 YEARS AND HOLD A BS IN ELECTRICAL ENGINEERING. ANYONE IS WELCOME TO CONTACT ME AT [XXX]. (UNRELATED ... I WAS ALSO DISAPPOINTED TO LEARN FROM ONE DEALER WHEN FIXING AN A/C ISSUE THAT MY BRAKE BOOSTER DRUM WAS CONTAMINATED WITH BRAKE FLUID DUE TO A BAD SEAL I GUESS. THAT FIX WAS COSTLY AND LIKELY SHOULD HAVE BEEN ON THE MANUFACTURER ALSO). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10854957
72,000 miles · Mar 16, 2016
Engine
2010 GMC ACADIA WITH CHECK ENGINE LIGHT INDICATING A TIMING CHAIN PROBLEM. RECALL EXISTS FROM GMC FOR THIS PROBLEM FOR EARLIER MODEL YEARS BUT DOES NOT INCLUDE 2010 MODELS. THE REPAIR REQUIRES THE ENGINE AND TRANSMISSION TO BE PULLED FROM THE VEHICLE AND EXTENSIVE DISASSEMBLY. REPAIR COST IS OVER $3,000. NUMEROUS REPORTS …
Read full complaint
2010 GMC ACADIA WITH CHECK ENGINE LIGHT INDICATING A TIMING CHAIN PROBLEM. RECALL EXISTS FROM GMC FOR THIS PROBLEM FOR EARLIER MODEL YEARS BUT DOES NOT INCLUDE 2010 MODELS. THE REPAIR REQUIRES THE ENGINE AND TRANSMISSION TO BE PULLED FROM THE VEHICLE AND EXTENSIVE DISASSEMBLY. REPAIR COST IS OVER $3,000. NUMEROUS REPORTS OF THIS DEFECT HAVE BEEN REPORTED AND GMC REFUSES TO EXPAND IT'S RECALL WARRANTY TO INCLUDE 2010 MODELS.
NHTSA ODI #10850116
Mileage unknown · Feb 1, 2016
EngineExterior Lighting
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING. IN ADDITION, THE EXTERIOR HEADLAMPS MELTED THE WIRES AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN FRACTURED AND THE WIRES NEEDED TO BE REPLACED.…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING. IN ADDITION, THE EXTERIOR HEADLAMPS MELTED THE WIRES AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN FRACTURED AND THE WIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT PROVIDED.
NHTSA ODI #10823586
63,000 miles · Jan 27, 2016
Engine
THE CAM SHAFT ENGINE CORRELATION CODE INDICATED STRETCHED TIMING AND CHAIN GUIDES. EXTENDED WARRANTEES UP TO 10 YEARS AND 120,000 MILES HAVE BEEN OFFERED FOR 2007 AND 2009 GMC ACADIAS WITH THE SAME PROBLEM. TO DATE THEY HAVE NOT BEEN OFFERED FOR THE 2010 MODEL EVEN THOUGH IT'S THE SAME ISSUE. MINE FAILED AT 63,000.00 MILES. HAD…
Read full complaint
THE CAM SHAFT ENGINE CORRELATION CODE INDICATED STRETCHED TIMING AND CHAIN GUIDES. EXTENDED WARRANTEES UP TO 10 YEARS AND 120,000 MILES HAVE BEEN OFFERED FOR 2007 AND 2009 GMC ACADIAS WITH THE SAME PROBLEM. TO DATE THEY HAVE NOT BEEN OFFERED FOR THE 2010 MODEL EVEN THOUGH IT'S THE SAME ISSUE. MINE FAILED AT 63,000.00 MILES. HAD TO HAVE THE TIMING CHAINS REPLACED. DEALERSHIP REPAIRED WITH GM PAYING HALF. THIS SHOULD BE A RECALL DUE TO THE FACT MY CAR WAS MANUFACTURED IN 2009 AND SHOULD FALL UNDER THE ABOVE MENTIONED RECALL AS THE FAILURE IS FOR THE SAME REASON.
NHTSA ODI #10822476
127,681 miles · Jan 21, 2016
EngineStructure
TL* THE CONTACT OWNS A 2010 GMC ACADIA. AFTER THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE), THE HATCHBACK COLLAPSED ON THE CONTACT. NO INJURIES WERE SUSTAINED. THE FAILURE WAS RECURRING. THE CONTACT STATED THAT A LOUD ABNORMAL NOISE COULD BE HEARD COMING FROM THE HATCHBACK MOTOR. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. AFTER THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE), THE HATCHBACK COLLAPSED ON THE CONTACT. NO INJURIES WERE SUSTAINED. THE FAILURE WAS RECURRING. THE CONTACT STATED THAT A LOUD ABNORMAL NOISE COULD BE HEARD COMING FROM THE HATCHBACK MOTOR. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY CONTROL MODULE NEEDED TO BE UPDATED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 127,681.
NHTSA ODI #10821436
Mileage unknown · Jan 19, 2016
Engine
THE CAM SHAFT ENGINE CORRELATION CODE INDICATED STRETCHED TIMING AND CHAIN GUIDES. EXTENDED WARRANTEES UP TO 10 YEARS AND 120,000 MILES HAVE BEEN OFFERED FOR 2007 AND 2009 GMC ACADIAS WITH THE SAME PROBLEM. TO DATE THEY HAVE NOT BEEN OFFERED FOR THE 2010 MODEL EVEN THOUGH IT'S THE SAME ISSUE.
NHTSA ODI #10821092
Official recalls
4Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration