NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
74 reportsClear category filterMileage unknown · Sep 5, 2017
EnginePower Train
TIMING CHAIN NEEDED REPLACEMENT DUE TO STRETCH AND CHECK ENGINE LIGHT AT 137,882 WHICH COST $2,049. THIS ISSUE WAS COVERED UNDER SPECIAL WARRANTY FOR 2007-2009 MODEL YEARS, BUT THE 2010 IS NOT COVERED. MY UNDERSTANDING OF GMC'S FIX IS THAT NOTHING CHANGED WITH THE TIMING CHAIN AND THE OIL SYSTEM LIFE WAS LOWERED AS TO WHEN AN …
Read full complaint
TIMING CHAIN NEEDED REPLACEMENT DUE TO STRETCH AND CHECK ENGINE LIGHT AT 137,882 WHICH COST $2,049. THIS ISSUE WAS COVERED UNDER SPECIAL WARRANTY FOR 2007-2009 MODEL YEARS, BUT THE 2010 IS NOT COVERED. MY UNDERSTANDING OF GMC'S FIX IS THAT NOTHING CHANGED WITH THE TIMING CHAIN AND THE OIL SYSTEM LIFE WAS LOWERED AS TO WHEN AN OIL CHANGE WAS RECOMMENDED BY THE VEHICLE (MORE FREQUENT OIL CHANGES). I HAVE COMPLETED ALL SCHEDULED OIL CHANGES BASED ON THE AUTOMATED PROMPT FROM THE VEHICLE AND STILL HAD TO COMPLETE THIS COSTLY REPAIR OUT OF POCKET. I WOULD LIKE TO SEE THIS KNOWN ISSUE ALSO COVERED BY THE SPECIAL WARRANTY ON NEWER VEHICLES AND BE REIMBURSED FOR MY EXPENSES.
NHTSA ODI #11021536
106,000 miles · Jun 19, 2017
Engine
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT WAS IN THE PROCESS OF TRADING IN THE VEHICLE. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT HAD THE VEHICLE TOWED. A CERTIFIED MECHANIC DIAGNOSED THAT THE MOTOR BURNED AN EXCESSIVE AMOUNT OF OIL, WHICH CAUSED THE FAILURE. THE VEHICLE WAS INOPERAB…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT WAS IN THE PROCESS OF TRADING IN THE VEHICLE. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT HAD THE VEHICLE TOWED. A CERTIFIED MECHANIC DIAGNOSED THAT THE MOTOR BURNED AN EXCESSIVE AMOUNT OF OIL, WHICH CAUSED THE FAILURE. THE VEHICLE WAS INOPERABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE REPAIR WAS NOT COVERED. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
NHTSA ODI #10995829
138,000 miles · May 15, 2017
Engine
CAR HAS BEEN SERVICED REGULARLY. ENGINE WAS RUNNING SMOOTH. DROVE APPROXIMATELY 30 MILES ON HWY TO WORK GOT OFF ON CITY STREET AND CAR STARTED SHAKING BAD. PULLED OVER INTO PARKING SPOT AND ENGINE CUT OFF. WOULDN'T RESTART. CALLED TOWING TO OUR REPAIRSHOP. THE FIRST CYLINDER SPARK PLUG WAS BENT RESULTING IN MAJOR ENGINE FAIL…
Read full complaint
CAR HAS BEEN SERVICED REGULARLY. ENGINE WAS RUNNING SMOOTH. DROVE APPROXIMATELY 30 MILES ON HWY TO WORK GOT OFF ON CITY STREET AND CAR STARTED SHAKING BAD. PULLED OVER INTO PARKING SPOT AND ENGINE CUT OFF. WOULDN'T RESTART. CALLED TOWING TO OUR REPAIRSHOP. THE FIRST CYLINDER SPARK PLUG WAS BENT RESULTING IN MAJOR ENGINE FAILURE DUE TO TIMING BELT STRETCH. NEED A NEW ENGINE AND FOUND THAT THIS IS BIG PROBLEM WITH GMC ENGINES. BOUGHT THE CAR LESS THAN A YEAR AGO AND IT CURRENTLY HAS 138K MILES. 7K TO REPLACE ENGINE INCLUDING LABOR. WOW MOTHER OF 3 KIDS AND I'M STILL PAYING BIG PAYMENT FOR THE CAR AND INSURANCE.. SO MANY COMPLAINTS ABOUT THIS ISSUE I JUST FOUND OUT WITH GMC COVERING THE ISSUE UP AND NOT BEING RESPONSIBLE
NHTSA ODI #10985804
47,125 miles · Apr 3, 2017
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHEN THE HEAT OR AIR CONDITIONING SYSTEM WAS ACTIVATED, A FUEL ODOR EMITTED INSIDE THE VEHICLE. THE DEALER DIAGNOSED THAT THE HVAC SYSTEM FAILED AND NEEDED A FILTER INSTALLED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILE…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHEN THE HEAT OR AIR CONDITIONING SYSTEM WAS ACTIVATED, A FUEL ODOR EMITTED INSIDE THE VEHICLE. THE DEALER DIAGNOSED THAT THE HVAC SYSTEM FAILED AND NEEDED A FILTER INSTALLED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 47,125.
NHTSA ODI #10970091
95,000 miles · Mar 24, 2017
Engine
WHILE I WAS DRIVING TONIGHT MY VEHICLE SHUT OFF IN MID TURN CAUSING LOSS OF POWER STEERING. WHERE THIS HAPPENED IS A VERY BUSY INTERSECTION. I HAD TO PULL OVER AND WHEN I PUT THE CAR IN PARK AND RESTARTED IT CAME ON FOR A SECOND THEN SHUT OFF AGAIN. THEN WAS ABLE TO GET IT RUNNING AGAIN. I HAD MY WIFE AND 6 MONTH OLD DAUGHTER IN…
Read full complaint
WHILE I WAS DRIVING TONIGHT MY VEHICLE SHUT OFF IN MID TURN CAUSING LOSS OF POWER STEERING. WHERE THIS HAPPENED IS A VERY BUSY INTERSECTION. I HAD TO PULL OVER AND WHEN I PUT THE CAR IN PARK AND RESTARTED IT CAME ON FOR A SECOND THEN SHUT OFF AGAIN. THEN WAS ABLE TO GET IT RUNNING AGAIN. I HAD MY WIFE AND 6 MONTH OLD DAUGHTER IN THE CAR AND THIS COULD HAVE BEEN A VERY DIFFERENT OUTCOME. I HAVE READ MANY OF COMPLAINTS ONLINE ABOUT THIS SAME PROBLEM IN THESE VEHICLES. I REALLY FEEL THAT GM NEEDS TO TAKE A SERIOUS LOOK AT THIS ISSUE BEFORE SOMETHING MAJOR HAPPENS.
NHTSA ODI #10968434
104,000 miles · Mar 15, 2017
Engine
WITHOUT ANY WARNING, CAR DIED WHILE DRIVING. TIMING CHAIN APPARENTLY STRETCHED AFTER ONLY 39,000 MILES. THIS IS THE SECOND TIMING CHAIN I HAVE TO REPLACE. GMC HAS EXTENDED THE WARRANTY FOR SEVERAL MODELS TO 120,000 BUT NOT MY YEAR!
NHTSA ODI #10966070
103,000 miles · Mar 8, 2017
Engine
GMC 2010 ACADIA.. 96,000 MILES WHENENGINE LIGHT WITH CODE P0008 INDICATING STRETCHED TIMING CHAINS. MECHANIC AWARE OF EXTENDED WARRANTY ON 2007-2009 VEHICLES. CALLED GMC, THEY SAID 2010 NOT COVERED. SAME ENGINE AS 2009 AND NOT COVERED. FAILED INSPECTION IN NH DUE TO CODE...$2300 IN REPAIRS NEEDED. FILED COMPLAINT WITH GMC..…
Read full complaint
GMC 2010 ACADIA.. 96,000 MILES WHENENGINE LIGHT WITH CODE P0008 INDICATING STRETCHED TIMING CHAINS. MECHANIC AWARE OF EXTENDED WARRANTY ON 2007-2009 VEHICLES. CALLED GMC, THEY SAID 2010 NOT COVERED. SAME ENGINE AS 2009 AND NOT COVERED. FAILED INSPECTION IN NH DUE TO CODE...$2300 IN REPAIRS NEEDED. FILED COMPLAINT WITH GMC...PLAN TO PRINT EXTENSIVE COMPLAINTS FOUND HERE AND HEADING TO DEALERSHIP WHERE I BOUGHT IT.
NHTSA ODI #10959677
159,000 miles · Feb 22, 2017
Engine
TIMING CHAINS STRETCH. VERY COMMON ISSUE ON THIS AND OTHER GM VEHICLES WITH 3.6L ENGINE. JUST PURCHASED MY VEHICLE AND IT'S AT THE DEALER FOR A $2600 REPAOR ON THIS PROBLEM. CAN HAPPEN AT ANY MILEAGE AND WITHOUT WARNING OTHER THAN CHECK ENGINE LIGHT. TIMING CHAINS STRETCH CAUSING ENGINE TO BE OUT OF SYNC AND EVENTUALLY ENGINE DA…
Read full complaint
TIMING CHAINS STRETCH. VERY COMMON ISSUE ON THIS AND OTHER GM VEHICLES WITH 3.6L ENGINE. JUST PURCHASED MY VEHICLE AND IT'S AT THE DEALER FOR A $2600 REPAOR ON THIS PROBLEM. CAN HAPPEN AT ANY MILEAGE AND WITHOUT WARNING OTHER THAN CHECK ENGINE LIGHT. TIMING CHAINS STRETCH CAUSING ENGINE TO BE OUT OF SYNC AND EVENTUALLY ENGINE DAMAGE/FAILURE WHILE DRIVING. MINIMUM COST OF REPAIR IS $2500+ AS ENGINE HAS TO BE REMOVED TO DO THE REPAIR. GM HAS KNOWLEDGE OF THE PROBLEM AND EVEN ISSUED EXTENDED SPECIAL WARRANTIES TO COVER THE PROBLEM ON 2007-2009 MODELS ONLY EVEN THOUGH 2010 AND NEWER MODELS HAVE SAME PROBLEM WITH SAME ENGINE. ANY INTERNET SEARCH WILL YIELD HUNDREDS OF OTHER OWNERS WITH SAME ISSUE.
NHTSA ODI #10956333
84,823 miles · Feb 3, 2017
Engine
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 45 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN AND CRANKSHAFT NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 45 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN AND CRANKSHAFT NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 84,823.
NHTSA ODI #10949313
96,000 miles · Jan 26, 2017
Engine
I'M FILING A COMPLAINT ABOUT MY MODEL YEAR 2010 GMC ACADIA. MY CHECK ENGINE LIGHT HAS COME ON AT 96,000. THE CODE IS P0008. THIS CODE POINTS TO THE TIMING CHAIN. THIS IS A KNOWN ISSUE WITH GMC ACADIA'S AND IS THE SAME ISSUE THAT CAUSED GMC TO EXTEND THEIR POWERTRAIN WARRANTY ON 2009 MODEL ACADIA'S TO 120,000 MILE OR 10 YEARS.…
Read full complaint
I'M FILING A COMPLAINT ABOUT MY MODEL YEAR 2010 GMC ACADIA. MY CHECK ENGINE LIGHT HAS COME ON AT 96,000. THE CODE IS P0008. THIS CODE POINTS TO THE TIMING CHAIN. THIS IS A KNOWN ISSUE WITH GMC ACADIA'S AND IS THE SAME ISSUE THAT CAUSED GMC TO EXTEND THEIR POWERTRAIN WARRANTY ON 2009 MODEL ACADIA'S TO 120,000 MILE OR 10 YEARS. GMC IS NOT OFFERING TO EXTEND MY WARRANTY TO 120,000 MILES OR 10 YEARS EVEN THOUGH I'M EXPERIENCING THE SAME PROBLEM THAT CAUSED THEM TO EXTEND 2009 MODEL CARS. MY CAR WAS MANUFACTURED IN OCT 2009.
NHTSA ODI #10947737
Official recalls
4Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration