NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
74 reportsClear category filter178,000 miles · Feb 28, 2019
Engine
MY ACADIA IS THROWING P0008 CODE. IT BEGAN HAVING POWER ISSUES NOT BEING ABLE TO ACCELERATE AND PULLING UP THE SMALLEST HILLS. ALL OF THIS STARTED GOING 70MPH DOWN THE INTERSTATE. NOT A GOOD SPOT OR TIME TO DECELERATE. ALSO STARTED HAVING A VERY ROUGH IDLE. IT IS AT A GMC DEALER NOW AND AM BEING TOLD TIMING CHAIN WILL HAVE T…
Read full complaint
MY ACADIA IS THROWING P0008 CODE. IT BEGAN HAVING POWER ISSUES NOT BEING ABLE TO ACCELERATE AND PULLING UP THE SMALLEST HILLS. ALL OF THIS STARTED GOING 70MPH DOWN THE INTERSTATE. NOT A GOOD SPOT OR TIME TO DECELERATE. ALSO STARTED HAVING A VERY ROUGH IDLE. IT IS AT A GMC DEALER NOW AND AM BEING TOLD TIMING CHAIN WILL HAVE TO BE REPLACED. WAS TOLD THIS IS A KNOWN PROBLEM AND SHOULD REPORT IT SINCE IT IS THE SAME PROBLEM ON THE 2009 AND THOSE WERE COVERED UNDER WARRANTY }:(
NHTSA ODI #11183155
130,000 miles · Feb 26, 2019
Engine
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 70 MPH, THE VEHICLE DECELERATED. THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE OVER TO THE SHOULDER WITHOUT POWER STEERING OR BRAKING ABILITY. ALSO, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE DEALER AND MANUFACTURER WERE NOT…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 70 MPH, THE VEHICLE DECELERATED. THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE OVER TO THE SHOULDER WITHOUT POWER STEERING OR BRAKING ABILITY. ALSO, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNKNOWN.
NHTSA ODI #11182638
53,366 miles · Feb 25, 2019
Engine
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HENDRICK BUICK GMC CARY (115 TEAM HENDRICK WAY, CARY, NC 27511, (919) 234-7784) WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HENDRICK BUICK GMC CARY (115 TEAM HENDRICK WAY, CARY, NC 27511, (919) 234-7784) WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,366.
NHTSA ODI #11182279
Mileage unknown · Feb 6, 2019
Engine
CHECK ENGINE LIGHT IS ON. VEHICLE IS SHOWING A P0008 CODE WITH 92,000 MILES THIS IS A CRANKSHAFT MISALIGNMENT THAT I WAS TOLD MEANS THE TIMING CHAIN WILL NEED TO BE REPLACED. THIS IS APPARENTLY A WIDESPREAD ISSUE AMONGST GMC ACADIA OWNERS.
NHTSA ODI #11174873
105,000 miles · Oct 9, 2018
Engine
MY TIMING CHAIN WAS REPLACED UNDER WARRANTY 4 YEAR AND 50,000 MILES AGO. NOW I AM HAVING TO REPLACE IT AGAIN. I CONTACT GMC ABOUT RECALL10287 PREMATURE CHAIN WEAR FOR REPROGRAMMING OF THE ENGINE CONTROL MODULE. I WAS TOLD THIS DOES NOT APPLY TO MY YEAR AND THERE WAS NO PART LISTED BECAUSE IT JUST A GENERAL STATEMENT. NOT SURE WH…
Read full complaint
MY TIMING CHAIN WAS REPLACED UNDER WARRANTY 4 YEAR AND 50,000 MILES AGO. NOW I AM HAVING TO REPLACE IT AGAIN. I CONTACT GMC ABOUT RECALL10287 PREMATURE CHAIN WEAR FOR REPROGRAMMING OF THE ENGINE CONTROL MODULE. I WAS TOLD THIS DOES NOT APPLY TO MY YEAR AND THERE WAS NO PART LISTED BECAUSE IT JUST A GENERAL STATEMENT. NOT SURE WHERE TO GO FROM HERE. HERE IS MY CASE # FOR GMC 8-4704107640. I AM STILL AWAITING THE PART INFORMATION FROM THEM.
NHTSA ODI #11139213
155,000 miles · Sep 21, 2018
Electrical SystemEngineSteering
THIS HAS HAPPENED ABOUT TEN TIMES NOW ALL WITHIN THE PAST 3-4 MONTHS. I WILL BE DRIVING AND GO TO MAKE A TURN AND THE STEERING WHEEL LOCKS UP AND THE ENGINE DIES. THE BRAKES STILL WORK SO I AM ABLE TO STOP THE CAR, TURN THEY KEY OFF AND RESTART IT. IT HAD HAPPENED TO ME ONCE ON THE HIGHWAY AND THE REST OF THE TIMES HAVE BEEN STO…
Read full complaint
THIS HAS HAPPENED ABOUT TEN TIMES NOW ALL WITHIN THE PAST 3-4 MONTHS. I WILL BE DRIVING AND GO TO MAKE A TURN AND THE STEERING WHEEL LOCKS UP AND THE ENGINE DIES. THE BRAKES STILL WORK SO I AM ABLE TO STOP THE CAR, TURN THEY KEY OFF AND RESTART IT. IT HAD HAPPENED TO ME ONCE ON THE HIGHWAY AND THE REST OF THE TIMES HAVE BEEN STOP AND GO TURNS IN THE CITY BUT ONCE WAS WHILE TURNING LEFT ONTO ON CMONG TRAFFIC AND MY CAR DIED IN THE MIDDLE OF IT. I TOOK IT TO 3 DIFFERENT AUTO PLACES AND ALL TOLD ME THEY COULDN'T FIND THE PROBLEM. I THEN RESEARCHED THIS AND FOUND SEVERAL OTHER PEOPLE HAVING THIS SAME PROBLEM. I CONTACTED THEM AND THEY SET ME UP WITH A DEALERSHIP TO GET IT FIXED. GMC SAID IF IT WAS UNDER 150,000 MILES THEY WOULD PAY FOR IT AND IF IT WAS OVER THEN I WOULD STILL QUALIFY FOR A PAYMENT ASSISTANCE PROGRAM. HOWEVER A DAY AFTER DROPPING OFF MY CAR TO GET FIXED THE DEALERSHIP CALLED ME AND SAID THEY DON'T KNOW HOW TO FIX MY CAR AND TO COME GET IT OUT OF THEIR PARKING LOT. WE TOLD GMC ABOUT THIS AND THEY SAID IT'S NOT THERE PROBLEM. I'M AT A LOSS AT THIS POINT AS NO ONE SEEMS TO BE ABLE TO FIX THE CAR AND IT IS A DEATH TRAP FOR ME AND MY FAMILY. I'M ALSO NOT JUST GOING TO SELL TO THE CAR TO SOMEBODY LIKE THE DEALERSHIP ADVISED ME TO DO BECAUSE 'THEY WOULDN'T WANT THEIR SON OR DAUGHTER DRIVING THAT THING' (EVEN THOUGH THEY SEEM PERFECTLY FINE TO HAVE ME DRIVE IT OFF THEIR LOT ASAP AND NOT BE THEIR PROBLEM ANYMORE) BECAUSE I WOULDNT FEEL RIGHT SELLING A CAR TO SOMEONE KNOWING IT COULD KILL THEM THROUGH NO FAULT OF THEIR OWN. I DON'T KNOW WHAT TO DO HERE. THE RIGHT THING TO DO WOULD BE TO PUT THAT CAR IN THE JUNKYARD AND BUY A NEW ONE BUT I DON'T HAVE THE CASH. WOULD LIKE SOMEBODY TO TELL ME HOW TO FIX THIS.
NHTSA ODI #11130681
Mileage unknown · Jul 6, 2018
EnginePower Train
THE TIMING CHAIN NEEDS TO BE REPLACED ON THE 2010, WHICH IS THE SAME ISSUE GMC HAD WITH THE 2009S, HOWEVER, THE 2010 ISN'T COVERED, BUT THE 2009 WAS. I'VE READ THAT GMC KNOWS THAT THERE IS AN ISSUE, BUT THEY JUST AREN'T COVERING IT YET.
NHTSA ODI #11109845
Mileage unknown · Jun 8, 2018
Engine
TIMING CHAIN NEEDS TO BE REPLACES AND ISN'T COVERED ALTHOUGH IT'S THE SAME PARTS AS THE 2009 MODEL THAT IS COVERED BY THE EXTENDED WARRANTY. GMC IS AWARE OF THIS ONGOING ISSUE AND SHOULD COVER IT
NHTSA ODI #11100635
85,000 miles · Jan 29, 2018
EngineVehicle Speed Control
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 45 MPH, THE THROTTLE MALFUNCTIONED AND THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING ON MORE THAN ONE OCCASION. THE CONTACT STATED THAT THE VEHICLE ACCELERATED TO 95 MPH. THE CONTACT WAS ABLE TO SLOW THE VEHICLE DOWN BY DEPRESSING THE BRAKE PEDAL WITH BOTH FEET. BESSETTE MO…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC ACADIA. WHILE DRIVING 45 MPH, THE THROTTLE MALFUNCTIONED AND THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING ON MORE THAN ONE OCCASION. THE CONTACT STATED THAT THE VEHICLE ACCELERATED TO 95 MPH. THE CONTACT WAS ABLE TO SLOW THE VEHICLE DOWN BY DEPRESSING THE BRAKE PEDAL WITH BOTH FEET. BESSETTE MOTORS IN CARRINGTON, NORTH DAKOTA WAS MADE AWARE OF THE FAILURE AND REPLACED THE THROTTLE BODY, BUT THE FAILURE RECURRED. IN ADDITION, THE PEDAL POSITIONING SENSOR WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000. THE VIN WAS NOT AVAILABLE. *TT *TR
NHTSA ODI #11065668
79,000 miles · Oct 5, 2017
EnginePower Train
AT 60,000.00 THOUSAND MILES MY TIMING CHAINS NEEDED REPLACED (JUST LIKE THE 2009 WHICH HAS A RECALL) THEN AT 79,000 MILES MY WAVE PLATE CRACKED ON MY TRANSMISSION (WHICH THERE IS A RECALL ON THE 2009 MODEL FOR THE EXACT SAME THING) MY CAR WAS A EARLY 2010 MODEL AND IT LOOKS LIKE THE 2009 ISSUES ARE PROBLEMS ON MY CAR. I THIN…
Read full complaint
AT 60,000.00 THOUSAND MILES MY TIMING CHAINS NEEDED REPLACED (JUST LIKE THE 2009 WHICH HAS A RECALL) THEN AT 79,000 MILES MY WAVE PLATE CRACKED ON MY TRANSMISSION (WHICH THERE IS A RECALL ON THE 2009 MODEL FOR THE EXACT SAME THING) MY CAR WAS A EARLY 2010 MODEL AND IT LOOKS LIKE THE 2009 ISSUES ARE PROBLEMS ON MY CAR. I THINK IT'S INSANE THAT GM CAN'T STAND BEHIND THEIR WORK BETTER THAN THIS. THE RECALL'S SHOULD COVER THE 2010 MODELS THAT WERE MANUFACTURED WITH 2009 PARTS!!!
NHTSA ODI #11031912
Official recalls
4Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration