Power Train. Review the 279 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

22 crash reports13 fire reports24 injury reports

Power Train complaints

279 reports

Clear category filter

143,000 miles · Apr 19, 2016

Power Train

Read full complaint

WHILE DRIVING, THE VEHICLE BEGAN TO IDLE SPORADICALLY. EVENTUALLY, IT STARTED TO IDLE AND NOT SHIFT INTO THE NEXT GEAR. FINALLY, THE CHECK ENGINE LIGHT CAME ON. WHEN TOOK IT TO A REPAIR SHOP DETERMINE THE CODES ASSOCIATED WITH THE CHECK ENGINE LIGHT, AND FOUND P0700 AND P0776 CODES. THESE CODES REFERENCE A WELL KNOWN PROBLEM ENCOUNTERED IN THE 2008 GMC ACADIA. THE WAVEPLATE MAY BE BROKEN, AND CAUSE ISSUE IN THE 3RD, 5TH, AND R GEARS. SO, NOW THE VEHICLE DOESN'T SHIFT INTO ANY GEAR, AND I WILL HAVE TO PAY OUT OF POCKET ($4K) FOR AN ISSUE THAT GM KNOWS IS AN ISSUE, AND HAS SINCE CORRECTED IN THE LATER YEAR MODELS. I CALLED GM TO SEE IF THEY WOULD OFFER ANY TYPE OF ASSISTANCE, AND WAS TOLD NO, DUE TO THE MILEAGE ON MY VEHICLE. I AM CURRENTLY AT 143,000 MILES. REGARDLESS OF THE MILES ON MY VEHICLE, IF GM PLACED A FAULTY PART IN THEIR VEHICLES, THEY SHOULD BE REQUIRED TO PLACE A RECALL TO FIX IT, AND NOT HAVE IT BE THE CONSUMER'S RESPONSIBILITY!

NHTSA ODI #10860285

110,000 miles · Mar 31, 2016

EnginePower Train

Read full complaint

TL* THE CONTACT OWNS A 2008 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER AND WAS NO LONGER OPERABLE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC AGAIN WHERE THE ENGINE WAS REPLACED AGAIN. THE FAILURE RECURRED. IN ADDITION, THE ENGINE OIL COAGULATED AND THE AIR BAG LIGHT REMAINED ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 110,000.

NHTSA ODI #10852753

Mileage unknown · Feb 5, 2016

Electrical SystemPower TrainUnknown Or Other

Read full complaint

MY 2008 GMC ACADIA LEAKS WHEN IT RAINS, THE FLOOR BOARDS FILL WITH WATER & WATER COMES THROUGH THE INTERIOR LIGHTS CAUSING THEM TO SHORTEN, BLINK. THE POWER WINDOWS GOT STUCK WOULDN'T GO DOWN ALMOST SMASHED MY KIDS HAND. THE WORSE PART DRIVING ON INTERSTATE AT 65-70 TRAFFIC SLOWS TO 40 AND YOUR VEHICLE DOESN'T GO ALMOST CAUSING THE WORSE ACCIDENT EVER. SEEMS THIS WAVE PLATE, SHIFT SOLENOID IS A MANUFACTURER DEFECT ESPECIALLY SINCE I WAS ONLY A FEW MONTHS AFTER INITIAL PURCHASE AND THE TRUCK WAS RETURNED TO DEALER FOR SAME ISSUE SO THAT MEANS THE TRANSMISSION THEY REPLACED THE BAD ONE WITH WAS SO BAD OR REACHED ITS TIME OUT MILEAGE. THIS SHOULD BE A RECALL IF IT HAPPENED SHORTLY AFTER PURCHASE (PURCHASED USED) THEN IT HAPPENS AGAIN WITH THE REPLACEMENT TRANSMISSION AND ALL THE THREADS IN HAVE READ EVERY OWNER IS EXPERIENCING THIS, SOMEONE WILL HAVE BAD ACCIDENT POSSIBLY DEATH. DOES DEATH HAVE TO OCCUR FOR US TO GET BETTER RESOLVE AND MAKE GMC TAKE CARE OF THIS. OVER $5,000 WAS TOUGH TO CHRISTMAS TIME

NHTSA ODI #10824590

100,000 miles · Jan 28, 2016

Power Train

TL* THE CONTACT OWNS A 2008 GMC ACADIA. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE TRANSMISSION WOULD INTERMITTENTLY BECAME STUCK IN GEAR AND THE VEHICLE WOULD NOT DRIVE FORWARD OR IN REVERSE. THE VEHICLE WAS RESTARTED AND OPERATED AS NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE TRANSMISSION …

Read full complaint

NHTSA ODI #10822843

115,000 miles · Jan 18, 2016

Power Train

Read full complaint

PURCHASED VEHICLE FROM DEALER WITH 72000 MILES WITH 4YR/48000 MILE WARRANTY. WARRANTY RAN OUT THIS SUMMER, MILEAGE IS NOW 133000 MILES. PROBLEM HAS BEEN INTERMITTENT SINCE EARLY LAST YEAR, BUT MECHANICS WERE NOT ABLE TO HELP BECAUSE PROBLEMS WERE NOT 'PRESENTING' AS THE CHECK ENGINE LIGHT WOULD GO ON AND OFF AT DIFFERENT TIMES (JUST AS THE RECALLED SERVICE AIR BAG LIGHT DID!). IN DECEMBER 2015, THE CHECK ENGINE BEGAN STAYING ON ALL THE TIME AND THE GEARS DID NOT SHIFT CORRECTLY. THE TCM IS MESSED UP, WHICH IS A VERY COMMON PROBLEM WITH ALL ACADIAS, APPARENTLY. WE HAD A VERY SCARY ISSUE ON XMAS EVE WITH THE GEARS DOWNSHIFTING WHILE WE WERE ON THE HIGHWAY AND IT WOULDN'T LET ME GO OVER 20MPH! WE TOOK IT TO FIRST DEALERSHIP OVER AN HOUR AWAY AND THE GUY CAME OUT WITH A HANDHELD COMPUTER, PUT IN ON OUR CAR, SAID IT IS OUR TCM AND $3800 TO FIX IT. HE NEVER PUT ANYTHING IN THE COMPUTER, SO WE DIDN'T HAVE AN OFFICIAL DIAGNOSIS. WE SPOKE WITH GM AND THEY SAID TO GET THE DIAGNOSIS AND THEY WOULD SEE ABOUT HELPING US TO COVER IT. SO, WE GOT THE DIAGNOSIS TODAY, IT IS THE TCM AND NO HELP. THEY SAID IT IS OUT OF WARRANTY, GM WON'T COVER IT, IT IS UP TO THE DEALER TO COVER IT, ETC. WE HAVE BEEN TOLD SO MANY DIFFERENT STORIES ABOUT WHY THEY WON'T COVER IT, JUST THAT THEY WON'T. OUR VIN NUMBER IS LITERALLY 6000 OFF OF THE RECALL LIST! IT IS A COMMON PROBLEM AND SHOULD HAVE BEEN A NATIONAL RECALL! DOES ANYONE KNOW OF A CLASS ACTION LAWSUIT? I WOULD LOVE TO BE A PART OF ONE.

NHTSA ODI #10820788

90,000 miles · Jan 5, 2016

Power Train

Read full complaint

THE TRANSMISSION IN MY 2008 GMC ACADIA IS CURRENTLY AT THE DEALER WITH CODES PO752 AND PO700 WHICH ARE THE SHIFT SOLENOID AND THE TRANSMISSION CONTROL SYSTEM. I WAS STUCK IN FIRST GEAR DRIVING THE TRUCK. THE NHTSA REFERENCE #10052215 AND TSB REFERENCE #SB-13120 EXPLAINS THE EXACT PROBLEM THAT OCCURRED WITH MY TRUCK. GMC AND THE DEALER ARE SAYING THAT I HAVE TO PAY APPROX. $2500.00 WHICH IS A 65% TO 35% SPLIT WITH THE DEALERSHIP ( MINE BEING THE 65%). I SHOULDN'T HAVE TO PAY FOR A SAFETY ISSUE THAT HAS BEEN CLEARLY IDENTIFIED BY THE NHTSA. I AM JUST ANOTHER DISSATIFIED CUSTOMER WITH GM AND WOULD LIKE TO ADD MY EXPERIENCE AND TRUCK PROBLEM TO YOUR DATA BASE. THIS PROBLEM HAS BEEN HAPPENING FOR THE PAST MONTH OR SO. ALSO, THERE IS ALREADY A RECALL THAT GM HAS SENT OUT ON THE WAVE PLATES LOCATED IN THE TRANSMISSION. WHICH THEY HAVE EXTENDED THE WARRANTY TO 10 YEARS OR 120000 MILES. THE WAVE PLATES ARE BEGINNING TO WEAR CAUSING PREMATURE DEBRIS IN THE TRANSMISSION CAUSING THE SOLENOIDS TO STICK. ALTHOUGH THE DEALER IS SAYING THE WAVE PLATES ARE NOT WORN.

NHTSA ODI #10818255

53,000 miles · Dec 8, 2015

Power Train

TL* THE CONTACT OWNS A 2008 GMC ACADIA. THE CONTACT STATED THAT WHILE THE VEHICLE IN THE DRIVE POSITION, IT REVERSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO A FAULTY WAVE PLATE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAI…

Read full complaint

NHTSA ODI #10808962

Mileage unknown · Dec 2, 2015

Power Train

Read full complaint

LETTER FROM CONGRESSMAN HUDSON ON BEHALF OF CONSTITUENT RE 2008 GMC ACADIA TRANSMISSION FAILURE. *SMD THE VEHICLE WAS RETURNED TO THE CONSUMER, AFTER THE REPAIRS WERE COMPLETED. HOWEVER, ABOUT 30 MILES IN ROUTE, VARIOUS WARNING SIGNS AND MESSAGES BEGAN APPEARING ON THE DASH. SOME OF THE MESSAGES READ SERVICE STABILITRAK, SERVICE TRACTION CONTROL, ALL WHEEL DRIVE OFF, CHECK RIGHT FRONT TIRE PRESSURE, AND OTHERS. INCLUDING THE ABS SIGN WAS FLASHING A SCARY AND CAUTIONARY YELLOW SYMBOL.

NHTSA ODI #10816100

Mileage unknown · Nov 27, 2015

Electronic Stability Control (esc)Power TrainUnknown Or Other

Read full complaint

TRANSMISSION STARTED GETTING SLUGGISH AROUND 88, 000 MILES. VEHICLE WOULDN'T CRANK DUE TO ELECTRICAL STABILIZER, NOW MY SUNROOF IS LEAKING. DEALERSHIP IS GOING TO CHARGE ME $275 DOLLAR TO UNBLOCK THE SUNROOF DRAINS WHAT A RIP OFF WHEN THIS IS THE THREE TIME I HAVE HAD THE DRAINS CLEANED AND THE SUNROOF STILL LEAK. THIS HAS TO BE A GMC PROBLEM THAT THEY REFUSE TO ACKNOWLEDGE. THE TRANSMISSION IS STILL UNDER THE GMC WARRANTY SO THANK GOD I DON'T HAVE TO PAY OUT OF POCKET FOR THAT. THE ELECTRICAL MODULES SEEM TO BE OKAY FOR NOW BUT AT ANY GIVING TIME THE VEHICLE MAY STOP WORKING. GMC SHOULD OWN UP TO THESE PROBLEMS AND LOOK OUT FOR THEIR CUSTOMERS.

NHTSA ODI #10807250

Mileage unknown · Nov 2, 2015

Power Train

Read full complaint

TL* THE CONTACT OWNS A 2008 GMC ACADIA. THE CONTACT STATED THAT THE TRANSMISSION WAS SLOW TO CHANGE GEARS AND THERE WAS AN ABNORMAL NOISE PRESENT. THE VEHICLE WAS TAKEN TO THE DEALER AND TEST DRIVEN, BUT THE DEALER WAS NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE AFTER HAVING THE VEHICLE FOR LONGER THAN A WEEK. THE CONTACT INDICATED THAT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ODI #10787832

Official recalls

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

14V118000 · Air Bags:side/window

Mar 17, 2014

General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

Consequence & remedy

Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.

Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12003 · Loss Of Headlamp Illumination

Opened Jun 4, 2012 · Closed Jul 24, 2014

Status: closed (inferred from source dates) · Exterior Lighting:headlights

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

Electrical System

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Engine And Engine Cooling:engine

Engine And Engine Cooling

Visibility:windshield Wiper/washer

Visibility:windshield Wiper/washer:switch/wiring