NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
153 reportsClear category filter48,500 miles · Jan 29, 2012
Electrical SystemSteering
CAR WILL NOT SHUT OFF AFTER REMOVING KEY FROM IGNITION TAKES A MINUTE FOR CAR TO SHUT OFF CAR WOULD NOT START NEXT MORNING INTRUNENT PANEL SHOWS MULTIPAL PROBLEMS HAVE READ ONLINE CONSUMERS WITH SAME PROBLEMS WHO IS RESPONSIBLE FOR THIS ISSUE.NEED HELP HAVE HAD VEHICLE FPR THREE WEEKS WAS NOT TOLD BY DEALER ABOUGHT PROBLEMS WITH…
Read full complaint
CAR WILL NOT SHUT OFF AFTER REMOVING KEY FROM IGNITION TAKES A MINUTE FOR CAR TO SHUT OFF CAR WOULD NOT START NEXT MORNING INTRUNENT PANEL SHOWS MULTIPAL PROBLEMS HAVE READ ONLINE CONSUMERS WITH SAME PROBLEMS WHO IS RESPONSIBLE FOR THIS ISSUE.NEED HELP HAVE HAD VEHICLE FPR THREE WEEKS WAS NOT TOLD BY DEALER ABOUGHT PROBLEMS WITH ELECTRICAL HAVE PRINTED ALL OTHER COMPLAINTS ON LINE AND WILL SHOW TO DEALER I WOULD HOPE THAT GMC DOES NOT APPROVE WITH THESE ACTIONS.ALSO HAVE PROBLEM WITH SREERING IT MAKES A LOUD CLUNKING SOUND WHEN TURNING STEERING WHEEL THIS COUL BE A SERIOUS SAFETY ISSUE TO MY FAMILY. *TT
NHTSA ODI #10445740
50,000 miles · Dec 26, 2011
Air BagsElectrical System
REPEATED (AT LEAST 5 TIMES) LEAK ALONG THE AIRBAG DRIVER AND PASSENGER SIDE. DEALER SAYS THEY FIX IT AND THE PROBLEM REAPPEARS ON THE NEXT RAIN EVENT. CAUSING ELECTRICAL PROBLEMS AND MOLD PROBLEM IN THE CAR. *TR
NHTSA ODI #10441208
Mileage unknown · Dec 19, 2011
Electrical System
PURCHASED USED ACADIA 10/6/11 AND IN DECEMBER 2011 HAD TO HAVE BATTERY REPLACED BECAUSE WOULD NOT START. TWO WEEKS LATER CAR WOULD NOT START AGAIN. TOOK TO DEALERSHIP WHO DISCOVERED SUNROOF DRAIN HAD BEEN PLUGGED AND CAUSED THE WHOLE UNDERCARRIAGE TO FLOOD AND SHUT ALL ELECTRICAL POWER DOWN. I HEAR FROM PEOPLE THAT THERE HAD …
Read full complaint
PURCHASED USED ACADIA 10/6/11 AND IN DECEMBER 2011 HAD TO HAVE BATTERY REPLACED BECAUSE WOULD NOT START. TWO WEEKS LATER CAR WOULD NOT START AGAIN. TOOK TO DEALERSHIP WHO DISCOVERED SUNROOF DRAIN HAD BEEN PLUGGED AND CAUSED THE WHOLE UNDERCARRIAGE TO FLOOD AND SHUT ALL ELECTRICAL POWER DOWN. I HEAR FROM PEOPLE THAT THERE HAD BEEN A RECALL ON THE SUNROOF DRAIN FOR EXACTLY THIS PROBLEM. HOW CAN A DEALERSHIP SELL A CAR THAT HAS HAD A RECALL NOT TAKEN CARE OF?? *TR
NHTSA ODI #10440381
69,000 miles · Oct 24, 2011
Electrical SystemStructure
THE VEHICLE WAS LEASED NEW IN 2008 AND HAD WATER LEAKING AROUND SUNROOF. THE LEAK WAS REPAIRED HOWEVER BETWEEN 08-11 THERE WERE NUMEROUS DOCUMENTED ISSUES WITH ELECTRICAL PROBLEMS ON THIS CAR RELATING TO THE WATER LEAK. ON OCTOBER 11, 2011 I WAS DRIVING TO WORK IN THE VEHICLE AND ALL THE ELECTRICAL COMPONENTS SHUT OFF- RADIO, D…
Read full complaint
THE VEHICLE WAS LEASED NEW IN 2008 AND HAD WATER LEAKING AROUND SUNROOF. THE LEAK WAS REPAIRED HOWEVER BETWEEN 08-11 THERE WERE NUMEROUS DOCUMENTED ISSUES WITH ELECTRICAL PROBLEMS ON THIS CAR RELATING TO THE WATER LEAK. ON OCTOBER 11, 2011 I WAS DRIVING TO WORK IN THE VEHICLE AND ALL THE ELECTRICAL COMPONENTS SHUT OFF- RADIO, DIRECTIONALS, GAGES, LIGHTS. THE CAR REMAINED RUNNING AND WITHIN SECONDS THE ELECTRICAL WAS RESTORED. IT HAS CONTINUED TO SHUT ON AND OFF INTERMITTENTLY SINCE THEN. I BROUGHT THE CAR TO THE DEALER AND WAS TOLD THEY WERE UNABLE TO DIAGNOSE THE PROBLEM AND THAT I SHOULD BRING IT BACK IF IT HAPPENED AGAIN. ON THE WAY HOME IT HAPPENED AGAIN. I BROUGHT IT BACK ON OCT. 12 AND THE SAME THING HAPPENED THE WHOLE DRIVE TO THE DEALER. THEY HAVE SINCE HAD THE CAR AND TELL ME THEY DO NOT KNOW WHAT THE PROBLEM IS OR HOW TO FIX IT. I AM BEING LEFT TO DRIVE AN UNSAFE VEHICLE AND AM TOLD MY ONLY OPTION IS TO TRADE IT IN. *TR
NHTSA ODI #10432590
53,000 miles · Jul 26, 2011
Electrical SystemStructure
AIR COND TURNS ON BUT WILL NOT BLOW. MECHANIC REMOVES COVER AND MY BLOWER MOTOR IS STANDING IN 3 INCHES OF WATER. ANY MORE WATER WOULD HAVE LEAKED ONTO THE FLOOR OF MY CAR. WATER IN AN ELECTRICAL COMPONENT IS NOT SAFE. IF I GET WATER INSIDE, I WILL ALSO HAVE MOLD OR MILDEW. THIS IS NOT SAFE FOR US TO BREATHE. I DO NOT FEEL …
Read full complaint
AIR COND TURNS ON BUT WILL NOT BLOW. MECHANIC REMOVES COVER AND MY BLOWER MOTOR IS STANDING IN 3 INCHES OF WATER. ANY MORE WATER WOULD HAVE LEAKED ONTO THE FLOOR OF MY CAR. WATER IN AN ELECTRICAL COMPONENT IS NOT SAFE. IF I GET WATER INSIDE, I WILL ALSO HAVE MOLD OR MILDEW. THIS IS NOT SAFE FOR US TO BREATHE. I DO NOT FEEL THIS SHOULD BE MY COST. THIS IS MANUFACTURING OR ENGINEERING NEGLIGENCE. IT IS NOT NORMAL WEAR AND TEAR. *TR
NHTSA ODI #10415222
27,000 miles · Jul 18, 2011
Electrical System
TL* THE CONTACT OWNS A 2008 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHUT OFF ONCE THE KEY WAS TURNED TO THE OFF POSITION. THE CONTACT COULD REMOVE THE KEY FROM THE IGNITION, BUT THE VEHICLE CONTINUED TO RUN UNTIL THE BATTERY DIED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT…
Read full complaint
TL* THE CONTACT OWNS A 2008 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHUT OFF ONCE THE KEY WAS TURNED TO THE OFF POSITION. THE CONTACT COULD REMOVE THE KEY FROM THE IGNITION, BUT THE VEHICLE CONTINUED TO RUN UNTIL THE BATTERY DIED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE ENGINE CONTINUED TO RUN DUE TO AN ELECTRICAL SHORTAGE CAUSED BY A WATER LEAK. THE DEALER REPLACED THE MOLDING AROUND THE SUN ROOF WHERE THE WATER WAS LEAKING IN FROM. THE FAILURE CONTINUED, AS WATER CONTINUED TO LEAK INTO THE VEHICLE AND THE ENGINE CONTINUED TO RUN WHEN THE KEY WAS REMOVED FROM THE IGNITION. THE CONTACT ALSO STATED THE HEADLIGHTS WERE MALFUNCTIONING AS WELL. THE FAILURE MILEAGE WAS 27,000.
NHTSA ODI #10413362
73,259 miles · May 22, 2011
Electrical SystemStructure
2008 GMC ACADIA SLT HAS SEVERE WATER LEAKAGE INSIDE THE CABIN THAT CAUSE SIGNIFICANT DAMAGE TO INTERIOR CARPETING AND PANELS. ELECTRICAL PROBLEMS ALSO BEGIN TO HAPPEN SUCH AS BACK UP ASSIST DISABLED, AIR BAG LIGHT FLASHING, REAR WINDSHIELD WIPERS NOT SHUTTING OFF AND MORE I AM SURE WILL HAPPEN AS WATER ENTERS THE CABIN AND AREAS…
Read full complaint
2008 GMC ACADIA SLT HAS SEVERE WATER LEAKAGE INSIDE THE CABIN THAT CAUSE SIGNIFICANT DAMAGE TO INTERIOR CARPETING AND PANELS. ELECTRICAL PROBLEMS ALSO BEGIN TO HAPPEN SUCH AS BACK UP ASSIST DISABLED, AIR BAG LIGHT FLASHING, REAR WINDSHIELD WIPERS NOT SHUTTING OFF AND MORE I AM SURE WILL HAPPEN AS WATER ENTERS THE CABIN AND AREAS THAT YOU CANNOT SEE. THIS IS A POTENTIALLY DANGEROUS CONDITION THAT NEEDS TO BE RECALLED AND ADDRESSED BY GENERAL MOTORS. FIRE HAZARDS AND INJURIES DUE TO MALFUNCTIONING EQUIPMENT MIGHT OCCUR. THERE ARE VIDEOS AND PLENTY OF COMPLAINTS FROM OTHER OWNERS ON THE INTERNET OF THIS SAME ISSUE AND I AM SHOCKED THAT NO ACTIONS HAVE BEEN MADE BY GM. *TR
NHTSA ODI #10402334
64,373 miles · Aug 7, 2010
Electrical SystemExterior Lighting
I OWN A 2008 GMC ACADIA WITH MELTING HEADLIGHTS. THE PLASTIC HOUSING IS MELTING AND THE BULBS ARE MELTING INTO THE SOCKETS. I HAVE HAD PROBLEMS FOR MANY MONTHS WITH THE ELECTRICAL SYSTEM INCLUDING REPLACING 3 BATTERIES IN 1 1/2 YEARS. I HAVE HAD THE VEHICLE CHECKED BY THE DEALER WHICH FINDS "NO PROBLEM" WITH THE ELECTRICAL …
Read full complaint
I OWN A 2008 GMC ACADIA WITH MELTING HEADLIGHTS. THE PLASTIC HOUSING IS MELTING AND THE BULBS ARE MELTING INTO THE SOCKETS. I HAVE HAD PROBLEMS FOR MANY MONTHS WITH THE ELECTRICAL SYSTEM INCLUDING REPLACING 3 BATTERIES IN 1 1/2 YEARS. I HAVE HAD THE VEHICLE CHECKED BY THE DEALER WHICH FINDS "NO PROBLEM" WITH THE ELECTRICAL SYSTEM, AND NO EXPLANATION FOR THE BATTERY LIFE. WITH INTENSE HEAT THAT WOULD BE NECESSARY TO CAUSE THIS SOCKET TO MELT, METAL AND ALL, IS OF GREAT CONCERN, AND IS A POTENTIAL FIRE HAZARD. THIS VEHICLE ALSO WAS INVOLVED IN A RECENT RECALL FOR POSSIBLE FIRE WITH HEATED WINDSHIELD WIPERS (NOW DISCONNECTED). HOPEFULLY, THIS CAN BE INVESTIGATED, SO THAT NO ONE GETS HURT. *TR
NHTSA ODI #10347968
Mileage unknown · Jul 21, 2010
Electrical System
2008 GMC ACADIA. CONSUMER EXPRESSES DISCONTENT REGARDING VEHICLE RECALL *TGW THE CONSUMER STATED HE CONTACTED GM ABOUT HAVING THE PROBLEM WITH THE HEATED WASHER FLUID SYSTEM REPAIRED RATHER THAN PERMANENTLY DISABLED. THE REPRESENTATIVE INFORMED THE CONSUMER THERE WAS NO OPTION OF HAVING THE HWFS REPAIRED. *JB
NHTSA ODI #10344373
47,000 miles · Mar 18, 2009
Electrical SystemEquipment
EXISTING ODI ID NUMBER REFERENCES FOR 2007 ACADIAS: 10255735, 10254149, 10248331, 10211267, 10210839, 10210533. EXISTING ODI ID NUMBER REFERENCES FOR 2008 ACADIAS: 10246694, 10243591, 10241649, 10230134, 10229896, 10212682. THE ABOVE ODI ID NUMBERS SIGNIFY EXISTING COMPLAINTS IDENTIFYING WATER LEAKS AND RESULTING DAMAGE IN 07 &…
Read full complaint
EXISTING ODI ID NUMBER REFERENCES FOR 2007 ACADIAS: 10255735, 10254149, 10248331, 10211267, 10210839, 10210533. EXISTING ODI ID NUMBER REFERENCES FOR 2008 ACADIAS: 10246694, 10243591, 10241649, 10230134, 10229896, 10212682. THE ABOVE ODI ID NUMBERS SIGNIFY EXISTING COMPLAINTS IDENTIFYING WATER LEAKS AND RESULTING DAMAGE IN 07 & 08 GMC ACADIAS. GM INSTITUTED RECALL CAMPAIGN #08207: CUSTOMER SATISFACTION - SUNROOF WATER LEAK-INSTALL DRAIN TUBE EXTENSIONS DATED: AUG 27, 2008. CAMPAIGN WAS PRECEDED BY NUMEROUS TSBS LINKED TO THE SAME TYPE OF WATER LEAK. *** PURCHASED CERTIFIED VEHICLE ON 3/4/09. TSB #08027 PERFORMED PRIOR TO CERTIFICATION AND SALE. SERVICE MANAGER STATED WATER WAS PRESENT IN THE REAR DOME LAMPS AND HEADLINER. RETURNED TO DEALER 3/5/09 FOR WATER IN THE PASSENGER FLOOR AREA. TSB # 080857003A WAS PERFORMED. PRIOR TITLE OWNED BY A COMMERCIAL ENTITY AND MOST LIKELY NEVER RESPONDED TO THESE ISSUES. PICKED UP VEHICLE ON 3/6/09. STILL TAKING IN RAIN WATER. TOOK BACK TO DEALER ON 3/9/09. DOOR SEALS REPLACED AND RETURNED ON 3/11/09. HAS NOT RAINED SINCE THIS POSTING BUT CONCERN IS FOR ELECTRICAL INTEGRITY ON VEHICLE AS WATER LEAKAGE WAS CONCENTRATED NEAR MAIN FUSE BLOCK NEAR KICK PANEL AND MAIN WIRING HARNESS UNDER PASSENGER FLOOR AREA. MOLD IS ALSO A CONCERN AS DEALER HAS NOT REPLACED CARPETING OR HEADLINER BUT ONLY CLEANED AFFECTED AREA. VEHICLE IS USED FOR TRANSPORT OF FAMILY OVER LONG DISTANCES AND AN ELECTRICAL FAILURE DURING ON ROAD USE CAN BE CATASTROPHIC. *TR
NHTSA ODI #10262349
Official recalls
5Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration