NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
184 reportsClear category filter87,400 miles · Apr 9, 2013
Power Train
TL* THE CONTACT OWNS A 2007 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 40 MPH. IN ADDITION, THE GEAR SHIFTER COULD NOT BE MOVED INTO REVERSE. THE CHECK ENGINE WARNING LIGHT WAS ALSO ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION AND THE CONTACT WAS ADVISED THAT THE TRANSMISSION NEEDED …
Read full complaint
TL* THE CONTACT OWNS A 2007 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 40 MPH. IN ADDITION, THE GEAR SHIFTER COULD NOT BE MOVED INTO REVERSE. THE CHECK ENGINE WARNING LIGHT WAS ALSO ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION AND THE CONTACT WAS ADVISED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE TRANSMISSION WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 87,400.
NHTSA ODI #10505645
91,232 miles · Mar 31, 2013
Electrical SystemPower TrainVehicle Speed Control
AFTER SPENDING $370.51 AT MY LOCAL GMC DEALER FOR STABILITRAK ERRORS RESULTING IN LOW FUEL INPUT INTO THE ENGINE, WITH A MAXIMUM SPEED ALLOWABLE AT 35 MPH, MY 2007 GMC ACADIA IS ONCE AGAIN EXPERIENCING STABILITRAK ERRORS. THEY GENERALLY OCCUR WHEN I ROLL TO A STOP AT A STOPSIGN OR STOPLIGHT, BUT I AM VERY CONCERNED THAT THE TRA…
Read full complaint
AFTER SPENDING $370.51 AT MY LOCAL GMC DEALER FOR STABILITRAK ERRORS RESULTING IN LOW FUEL INPUT INTO THE ENGINE, WITH A MAXIMUM SPEED ALLOWABLE AT 35 MPH, MY 2007 GMC ACADIA IS ONCE AGAIN EXPERIENCING STABILITRAK ERRORS. THEY GENERALLY OCCUR WHEN I ROLL TO A STOP AT A STOPSIGN OR STOPLIGHT, BUT I AM VERY CONCERNED THAT THE TRANSMISSION WILL REDUCE SPEED WHEN I TRAVEL THE INTERSTATE. MY LOCAL GMC DEALER CLAIMED THIS PROBLEM WAS CAUSED BY A "CAM EXHAUST POSITION SENSOR FAULT" AND REPLACED THE "CAM EXHAUST POSITION SENSOR" ON 3-20-13 FOR $370.51. FOR ONE WEEK THIS REPAIR WORKED AND THERE WERE NO STABILITRAK ERRORS. TEN DAYS LATER, MY 2007 GMC ACADIA FWD IS WORSE THAN EVER, ENDANGERING ME AT NIGHT BY SHIFTING SUDDENLY INTO "STABILITRAK ERROR, LOW FUEL INPUT" MODE. I AM TERRIFIED THAT MY GMC DEALER WILL CHARGE ME MORE MONEY TO PRETEND-FIX THIS PROBLEM, AS THEY HAVE ME COMING IN FOR $400-$1,100 REPAIRS EVERY OTHER MONTH NOW SINCE THEY WANT TO SELL ME A NEW CAR. *TR
NHTSA ODI #10505149
74,419 miles · Mar 15, 2013
Power Train
NO PREVIOUS SYMPTOMS. COULD NOT GET THE VEHICLE TO GO IN REVERSE. GOT TOWED TO THE DEALER. DIAGNOSIS - WAVE PLATE FRACTURE. FOUND MANY MANY 2007 GMC ACADIA'S HAD THIS PROBLEM, THERE SHOULD HAVE BEEN A RECALL. THIS HAPPENED 1 YEAR AFTER THE WARRANTY EXPIRED, BUT ONLY 74419 MILES, AND NEVER DRIVEN IN EXTREME CONDITIONS AND NE…
Read full complaint
NO PREVIOUS SYMPTOMS. COULD NOT GET THE VEHICLE TO GO IN REVERSE. GOT TOWED TO THE DEALER. DIAGNOSIS - WAVE PLATE FRACTURE. FOUND MANY MANY 2007 GMC ACADIA'S HAD THIS PROBLEM, THERE SHOULD HAVE BEEN A RECALL. THIS HAPPENED 1 YEAR AFTER THE WARRANTY EXPIRED, BUT ONLY 74419 MILES, AND NEVER DRIVEN IN EXTREME CONDITIONS AND NEVER TOWED. *TR
NHTSA ODI #10503149
35,000 miles · Mar 9, 2013
Exterior LightingFuel/propulsion SystemPower Train
NO RECALL FOR DEFECTIVE TRANSMISSIONS? BOUGHT 2007 ACADIAR USED, 2600 MILES /FELT TRANSMISSION PROBLEMS EARLY ON. VERY NOTICEABLE JERK AT 40MPH. IN AND OUT OF DEALERSHIP SINCE. LAST FEW MONTHS CAR HAS BEEN IN TO DEALER FREQUENTLY RE CAR BUCKING AT STOP LIGHTS REALLY ROUGH THOUGHT ENGINE GOING TO DIE. EVERY TIME NOTHING SHO…
Read full complaint
NO RECALL FOR DEFECTIVE TRANSMISSIONS? BOUGHT 2007 ACADIAR USED, 2600 MILES /FELT TRANSMISSION PROBLEMS EARLY ON. VERY NOTICEABLE JERK AT 40MPH. IN AND OUT OF DEALERSHIP SINCE. LAST FEW MONTHS CAR HAS BEEN IN TO DEALER FREQUENTLY RE CAR BUCKING AT STOP LIGHTS REALLY ROUGH THOUGHT ENGINE GOING TO DIE. EVERY TIME NOTHING SHOWED IN CODES, EMERGENCY TRIP TO DOCTOR/HEAVY TRAFFIC MAIN ARTERY/CAN'T GET OVER 20MPH/ENGINE SCREAMING/ MAKE IT TO DR. (OMG) TOWED TO DEALERSHIP. TRANSMISSION GONE. I COULD HAVE HAD A SERIOUS ACCIDENT. FINALLY HEARD SOMETHING ABOUT A WAVE PLATE. FOR 5 YRS I'VE SAID SOMETHING WRONG. NO ONE SAID THESE WERE CONSTANT PROBLEMS WITH ACADIAS. THEY ISSUED RECALLS FOR A LEAK IN THE SUN ROOF. NO RECALL FOR DEFECTIVE TRANSMISSIONS? KNOWN DEFECTIVE WAVE PLATES? I HAVE EXTENDED WARRANTY, BUT MANY DON'T. WARRANTY OR NOT, THIS SAFETY HAZARD SHOULD BE FIXED BY GMC AT THEIR EXPENSE. A RECALL IS MANDATED. JUST ASK THE OWNERS. . . *TR
NHTSA ODI #10502205
Mileage unknown · Mar 7, 2013
Electrical SystemPower Train
I WAS DRIVING MY CAR WHEN ALL OF A SUDDEN IT WOULDN'T ACCELERATE ABOVE (20MPH?). I WAS FORCED TO PARK IT AT AN APARTMENT COMPLEX AND GET IT TOWED TO THE DEALER. NOW LESS THAN 6 MONTHS AFTER PAYING OUT OF POCKET FOR THAT REPAIR, I AM HAVING THE SAME PROBLEM. *TR
NHTSA ODI #10502027
73,390 miles · Feb 4, 2013
Power Train
STARTED SHIFTING WEIRD, THEN RPM'S WOULD SPIKE AS CAR WAS SHIFTING. CAR THEN WOULD NOT GO INTO ANY GEAR AND LEFT STRANDED ON SIDE OF ROAD. HAD TO HAVE VEHICLE TOWED TO DEALERSHIP WHERE IT WAS FOUND TO HAVE A BROKEN WAVE PLATE, DAMAGING NUMEROUS GEARS AND TORQUE CONVERTER. PRESSURE CONTROL MODULE WHICH IS PART OF THE VALVE BODY…
Read full complaint
STARTED SHIFTING WEIRD, THEN RPM'S WOULD SPIKE AS CAR WAS SHIFTING. CAR THEN WOULD NOT GO INTO ANY GEAR AND LEFT STRANDED ON SIDE OF ROAD. HAD TO HAVE VEHICLE TOWED TO DEALERSHIP WHERE IT WAS FOUND TO HAVE A BROKEN WAVE PLATE, DAMAGING NUMEROUS GEARS AND TORQUE CONVERTER. PRESSURE CONTROL MODULE WHICH IS PART OF THE VALVE BODY WAS BAD. HAD TO REPLACE ENTIRE TRANSMISSION, ALL SEALS, GASKETS. ALSO FOUND OUT WHEN REPLACING THAT THE THERMOSTAT HOUSING WAS LEAKING COOLANT, SO HAD TO HAVE THAT REPLACED AT SAME TIME. THIS AT A COST TO US OF OVER $3500.00. HAVE READ ONLINE THAT THIS IS A VERY COMMON ISSUE WITH THIS VEHICLE. WE WERE 7 MONTHS OUT OF OUR 5 YEAR/100,000 MILE WARRANTY AND GM WOULD NOT HELP IN THE LEAST. *TR
NHTSA ODI #10496391
41,000 miles · Feb 1, 2013
Power TrainStructureSuspension
I HAVE OWNED THIS CAR FOR ABOUT A YEAR AND SINCE I HAVE OWNED IT HAVE HAD NOTHING BUT PROBLEMS. FIRST THE STRUTS WERE BLOWN, THE DASH LIGHTS WOULD GO FROM BRIGHT TO DIM, THE STEERING WHEEL MADE A CLICKING NOISE, THE WINDOWS LEAK...THIS CAR ONLY HAS 41,000 MILES I MEAN COME ON! NOW THE TRANSMISSION HAS COMPLETELY FAILED AND AFTER…
Read full complaint
I HAVE OWNED THIS CAR FOR ABOUT A YEAR AND SINCE I HAVE OWNED IT HAVE HAD NOTHING BUT PROBLEMS. FIRST THE STRUTS WERE BLOWN, THE DASH LIGHTS WOULD GO FROM BRIGHT TO DIM, THE STEERING WHEEL MADE A CLICKING NOISE, THE WINDOWS LEAK...THIS CAR ONLY HAS 41,000 MILES I MEAN COME ON! NOW THE TRANSMISSION HAS COMPLETELY FAILED AND AFTER READING OTHER WEBSITES IT SOUNDS LIKE I WILL BE PAYING $4,000 DOLLARS. I AM A NEW MOM AND HAVE 3 STEP KIDS. I CAN'T FEEL SAFE IN MY CAR BECAUSE I'M WORRIED ABOUT IT BREAKING DOWN CONSTANTLY. NOW I HAVE TO DUMP ALL THIS MONEY THAT I DON'T HAVE INTO IT. I REALLY JUST WANT TO CUT MY LOSSES, BUT IS THAT REALLY THE BEST THING TO DO? I'M STUCK WITH THIS JUNKER CAR AND I COULDN'T FEEL MORE SORRY FOR ALL THESE OTHER PEOPLE HAVING THE SAME ISSUES. I'M ABSOLUTELY MISERABLE. THANKS GMC YOU SUCK. *TR
NHTSA ODI #10496110
52,800 miles · Jan 25, 2013
EnginePower Train
VEHICLE HAS ABOUT 50,000 MILES BUT A FEW MONTHS OUT OF WARRANTY AND STARTED GIVING ME PROBLEM SHIFTING GEAR. RESEARCHED THE PROBLEM AND FOUND A LOT OF SIMILAR COMPLAINTS OUT THERE BUT GM IS REFUSING TO TAKE RESPONSIBILITY AND MAKING OWNERS PAY TO FIX THE PROBLEM. TRANSMISSION IS DEFECTIVE. *TR
NHTSA ODI #10494654
59,004 miles · Jan 24, 2013
Exterior LightingPower Train
2007 GMC ACADIA. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH THE VEHICLE HEADLIGHTS AND THE TRANSMISSION. *SMD THE CONSUMER STATED ON DECEMBER 17, 2011, THE LEFT HEADLIGHT BURNED UP FOR NO APPARENT REASON. THE LOCAL DEALER QUOTED HIM $1,213.59. HE WAS ABLE TO GET THE HEADLIGHT FIXED FOR$ 695.67. ON DECEMBER 2, 2012 THE TRANSM…
Read full complaint
2007 GMC ACADIA. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH THE VEHICLE HEADLIGHTS AND THE TRANSMISSION. *SMD THE CONSUMER STATED ON DECEMBER 17, 2011, THE LEFT HEADLIGHT BURNED UP FOR NO APPARENT REASON. THE LOCAL DEALER QUOTED HIM $1,213.59. HE WAS ABLE TO GET THE HEADLIGHT FIXED FOR$ 695.67. ON DECEMBER 2, 2012 THE TRANSMISSION FAILED. THE CONSUMER HAD A REBUILT TRANSMISSION INSTALLED AT A COST OF $ 3,737.25.
NHTSA ODI #10494181
66,712 miles · Jan 22, 2013
Power Train
PRIOR TO HAVING THE TRANSMISSION BREAK DOWN THE VEHICLE HAD BEEN SHIFTING HARD FROM 2ND GEAR TO 3RD GEAR. STARTING UP A SMALL GRADE FROM A STAND STILL THE TRANSMISSION SUDDENLY BEGAN SLIPPING AT ABOUT 20MPH. THE VEHICLE WOULD NOT SHIFT AND THE ENGINE LIGHT CAME ON. I WAS ONLY ABOUT 1 MILE FROM HOME SO I DROVE IT HOME AT ABOUT 25…
Read full complaint
PRIOR TO HAVING THE TRANSMISSION BREAK DOWN THE VEHICLE HAD BEEN SHIFTING HARD FROM 2ND GEAR TO 3RD GEAR. STARTING UP A SMALL GRADE FROM A STAND STILL THE TRANSMISSION SUDDENLY BEGAN SLIPPING AT ABOUT 20MPH. THE VEHICLE WOULD NOT SHIFT AND THE ENGINE LIGHT CAME ON. I WAS ONLY ABOUT 1 MILE FROM HOME SO I DROVE IT HOME AT ABOUT 25MPH. AT HOME I PUT IT IN REVERSE AND IT WOULD NOT GO INTO REVERSE. TOOK IT TO A TRANSMISSION SHOP THE NEXT DAY, THEY CALLED ME BACK LATER THAT DAY AND TOLD ME IT NEEDED A NEW TRANSMISSION. THEY ARE DOING THE JOB FOR $3200. *TR
NHTSA ODI #10494385
Official recalls
5Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Feb 21, 2007
ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.
Remedy: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration