Illustration1992 GEO STORM MANUAL TRANSMISSION. WHEN ENGINE GETS HOT ( SUMMER MONTHS ) ENGINE IDLE INCREASES TO 2,500 - 3,500 RPM. MUST USE FOOT TO PULL UP ON ACCELARATOR. CAR BEGINS TO OVERHEAT LURCHES FORWARD. CAR ALSO STALLS WITHOUT WARNING. HEARD IT HAS TO DO WITH FAULTY ECM. VERY DANGEROUS SITUATION. *JB
1991 Geo Storm
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Geo Storm do not stand out strongly from the model-year median of 50.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Storm years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 90 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports1 fire reports11 injury reports
Electrical System complaints
19 reportsTHIS IS THE 2ND ECM CONTROL MODULE IN 2 YEARS. . .BOTH WERE NEW WITH ONLY A YEAR WARRANTY. . .PROBLEM ONLY SHOWS UP IN THE SUMMER. *AK
GENERAL MOTORS USED A SHRINKING SEALANT ON THE COMPUTER BOARDS IN THESE CARS WHICH THEY HAVE SINCE QUITE USING AND ADMIT IT WAS A PROBLEM, BUT STILL USE IT ON THE REPLACEMENT PARTS WHEN THIS SHRINKS IT PULLS THE COMPONENTS ON BOARD LOOSE, CAUSING POOR IDLE/ HESITATION AND STALLING EVEN DURING ACCELERATION (IE WHEN PULLING OUT IN…
Read full complaint
GENERAL MOTORS USED A SHRINKING SEALANT ON THE COMPUTER BOARDS IN THESE CARS WHICH THEY HAVE SINCE QUITE USING AND ADMIT IT WAS A PROBLEM, BUT STILL USE IT ON THE REPLACEMENT PARTS WHEN THIS SHRINKS IT PULLS THE COMPONENTS ON BOARD LOOSE, CAUSING POOR IDLE/ HESITATION AND STALLING EVEN DURING ACCELERATION (IE WHEN PULLING OUT IN TRAFFIC). *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
I WAS COMING DOWN A 2 LANE AND IT JUST STOPPED AND GOT REAR ENDED WHEN IT SHUT OFF IT WAS THE ECM SHORTED BECAUSE OF SEALANT FROM FACTORY. *AK
FOR THE LAST 4YRS. I HAVE HAD TROUBLE AT START-UP,IDLE,DRIVABILITY OF THE ENGINE. ALL SENSORS RELATED TO THE IGNITION HAD BEEN CHECKED OR REPLACED. NOW ON 12/1/01 THE ALTERNATOR OVER CHARGED THE ELECTRICAL SYSTEM CAUSING A COMPLETE BURN-UP OF THE ECM,MAIN CIRCUIT PANEL AND SOME OF THE WIRING HARNESS. NEITHER THE 50AMP MAIN FUS…
Read full complaint
FOR THE LAST 4YRS. I HAVE HAD TROUBLE AT START-UP,IDLE,DRIVABILITY OF THE ENGINE. ALL SENSORS RELATED TO THE IGNITION HAD BEEN CHECKED OR REPLACED. NOW ON 12/1/01 THE ALTERNATOR OVER CHARGED THE ELECTRICAL SYSTEM CAUSING A COMPLETE BURN-UP OF THE ECM,MAIN CIRCUIT PANEL AND SOME OF THE WIRING HARNESS. NEITHER THE 50AMP MAIN FUSE OR THE 30AMP ECM FUSE BLEW (LIKE THEY SHOULD HAVE) STOPPING THE 160 AMPS FROM THE ALTERNATOR. *AK
I SENT ONE COMPLAINT TODAY, WITH SOME ERRORS. I AM SENDING THIS COMPLAINT TO CORRECT THESE ERRORS, AND ALSO TO COMPLAIN A LITTLE MORE. I CAN BARELEY MAKE IT TO SCHOOL IN MY CAR WITHOUT WORRING IF IT IS GOING TO DIE OR NOT. SEVERAL TIMES IT HAS DIED IN THE MIDDLE OF BUSY INTERSECTIONS NOT ONLY PUTTING MYSELF IN DANGER, BUT ALSO T…
Read full complaint
I SENT ONE COMPLAINT TODAY, WITH SOME ERRORS. I AM SENDING THIS COMPLAINT TO CORRECT THESE ERRORS, AND ALSO TO COMPLAIN A LITTLE MORE. I CAN BARELEY MAKE IT TO SCHOOL IN MY CAR WITHOUT WORRING IF IT IS GOING TO DIE OR NOT. SEVERAL TIMES IT HAS DIED IN THE MIDDLE OF BUSY INTERSECTIONS NOT ONLY PUTTING MYSELF IN DANGER, BUT ALSO THE OTHER MOTRISTS AROUND ME. I AM A YOUNG KID ON A TIGHT BUDGET AND WOULD LIKE TO SEE SOMETHING DONE ABOUT THIS. THANK YOU. *AK
CAR HAS ERRATIC IDLE AT TIMES AND RPMS WILL STICK SOMETIMES WELL ABOVE NORMAL IDLE. IT IS ECU THAT IS CAUSING THE PROBLEM. QUITE A FEW OF MY FRIENDS EXPERIENCE THIS PROBLEM WITH THE GEO STORMS. A RECALL IS IN ORDER IF YOU ASK ME!*AK
THE ECM DIED, AND ACCORDING TO A SURVEY, A LOT OF OTHER PEOPLES HAVE ALSO, RECALL IT! *AK
CAR LOSES POWER WITH NO INDICATION OF A PROBLEM. ALL SPEEDS. BEEN CHASING PROBLEM FOR ALMOST 3 YEARS NOW. *AK
Official recalls
295V103007 · Seat Belts:front:buckle Assembly
May 24, 1995
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
Consequence & remedy
Consequence: THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.
Remedy: OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES AND CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. THEY SHOULD ENSURE THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUGGING ON THE BELT TO MAKE SURE THE LATCH IS SECURELY LOCKED, AND THEN PRESSING THE RELEASE BUTTON. THE LATCH PLATE SHOULD POP OUT OF THE BUCKLE WHEN THE BUTTON IS PRESSED. IF EITHER RELEASE BUTTON SHOWS A SIGN OF BREAKING OR CRACKING OR IF EITHER BUCKLE FAILS TO OPERATE PROPERLY, OWNERS SHOULD PROMPTLY CONTACT THEIR AUTHORIZED DEALER TO SCHEDULE AN APPOINTMENT TO HAVE THE BUCKLE REPLACED OR REPAIRED, FREE OF CHARGE. THE MANUFACTURER IS DEVELOPING A REMEDY DESIGNED TO PREVENT FAILURE OF THE BUTTONS THAT ARE NOT CURRENTLY BROKEN.
92V091001 · Air Bags
Jul 6, 1992
THE STEERING WHEEL CENTER HUB CAN FRACTURE DURING CERTAIN FRONTAL AND NEAR FRONTAL VEHICLE COLLISIONS.
Consequence & remedy
Consequence: FRACTURING OF THE STEERING WHEEL HUB CAN DECREASE THEDRIVER'S CONTROL OF THE VEHICLE AND COULD REDUCE THE CRASH PROTECTION OF THESTEERING SYSTEM AND THE DRIVER'S SIDE AIR BAG.
Remedy: A STEERING WHEEL REINFORCEMENT PLATE AND NUT WILL BE ADDED TO THE STEERING WHEEL HUB.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE95035 · Steering Column Loosening
Opened Jun 7, 1995 · Closed Oct 10, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA95014 · Seat Belt Buckles Failure
Opened Apr 25, 1995 · Closed Jul 28, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available