DT*: THE CONTACT STATED WHILE ATTEMPTING TO DEPRESS THE BRAKE PEDAL AT 35 MPH, THE PEDAL WOULD NOT COMPLETELY DEPRESS. THE BRAKE PEDAL FELT AS IF IT WAS "ROCK-HARD". THE BRAKES DID NOT STOP THE VEHICLE. THREE YEARS PRIOR TO THIS INCIDENT A RECALL NOTIFICATION LETTER REGARDING THE ROTORS WAS RECEIVED FOR THIS VEHICLE AND THE…
Read full complaint
DT*: THE CONTACT STATED WHILE ATTEMPTING TO DEPRESS THE BRAKE PEDAL AT 35 MPH, THE PEDAL WOULD NOT COMPLETELY DEPRESS. THE BRAKE PEDAL FELT AS IF IT WAS "ROCK-HARD". THE BRAKES DID NOT STOP THE VEHICLE. THREE YEARS PRIOR TO THIS INCIDENT A RECALL NOTIFICATION LETTER REGARDING THE ROTORS WAS RECEIVED FOR THIS VEHICLE AND THE RECALL WORK WAS PERFORMED. HOWEVER, THE RECALL WORK DID NOT REMEDY THE PROBLEM. THE FREIGHTLINER RECALL #SF 258A-D. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR WITHOUT CHARGE UNDER THE RECALL. UPDATED 07/25/06. *JB
NHTSA ODI #10155354
20,879 miles · Dec 15, 2003
Electrical SystemService Brakes, Hydraulic
STARTER GROUND STRAP RUBBED HOLE IN STEEL BRAKE LINE LOCATED NEAR THE STARTER. THIS CAUSED A LOSS OF BRAKE FLUID AND BRAKE PRESSURE. *AK
NHTSA ODI #10049739
56,581 miles · Dec 15, 2003
Electrical SystemService Brakes, Hydraulic
STARTER GROUND STRAP RUBBED HOLE IN STEEL BRAKE LINE LOCATED NEAR THE STARTER. THIS CAUSED A LOSS OF BRAKE FLUID AND BRAKE PRESSURE. *AK
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.
Remedy: CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
ON CERTAIN SCHOOL BUSES CHASSIS EQUIPPED WITH CATERPILLAR ENGINES AND HYDRAULIC BRAKES. A BRAIDED GROUND STRAP FOR THE STARTER MAY RUB ON A STEEL CHASSIS BRAKE LINE POTENTIALLY CAUSING A FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE THE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE IT, IF NECESSARY. THE BRAIDED GROUND STRAP WILL BE REPLACED WITH AN INSULATED CABLE. THE RECALL BEGAN ON AUGUST 10, 2004. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN SCHOOL BUSES, THE BRAKE HOSES FROM THE CHASSIS TO FRONT BRAKE CHAMBERS COULD DEVELOP LEAKS DUE TO THE HOSE ROUTING THAT COULD OVERSTRESS THE HOSE DURING SHARP TURNS.
Consequence & remedy
Consequence: THE VEHICLE COULD HAVE REDUCED BRAKING CAPACITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR IMPROPER ROUTING. IF IMPROPER ROUTING IS FOUND, DEALERS WILL REPLACE AND CORRECT THE HOSE ROUTING. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
VEHICLE DESCRIPTION: BUS CHASSIS VEHICLES. AN ELECTRICAL PASS-THROUGH CONNECTOR MAY NOT FIT IN THE FIREWALL MOUNTING HOLE CORRECTLY, RESULTING IN THE CONNECTOR DISLODGING AND AN ELECTRICAL TERMINAL CONTACTING THE FIREWALL.
Consequence & remedy
Consequence: THIS CAN CAUSE AN ELECTRICAL SHORT AND POTENTIAL FIRE.
Remedy: DEALERS WILL INSPECT VEHICLES FOR PROPER MOUNTING OF THE ELECTRICAL PASS THROUGH AND CORRECT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02024 · Front Air Brake Hose Leakage
Opened Feb 22, 2002 · Closed Mar 25, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
2001 Freightliner FS-65 Problems, Complaints & Recalls | Skip That Year
Illustration