HIGH PRESSURE FUEL LINES BROKE, CAUSING A BREAKDOWN, TOW AND REPAIR. LOSS OF FUEL ALSO. LINES WERE REPLACED AT AUTHORIZED DEALER WITH WHAT WAS AVAILABLE. THIS BREAKDOWN NOT INCLUDING FUEL LOSS RESULTED IN A LOST DAY AND $700 COSTS. 3 MONTHS LATER, WE RECEIVED RECALL NOTICE TO REPLACE THE LINES AGAIN. THE NOTICE SAYS WE COULD QU…
Read full complaint
HIGH PRESSURE FUEL LINES BROKE, CAUSING A BREAKDOWN, TOW AND REPAIR. LOSS OF FUEL ALSO. LINES WERE REPLACED AT AUTHORIZED DEALER WITH WHAT WAS AVAILABLE. THIS BREAKDOWN NOT INCLUDING FUEL LOSS RESULTED IN A LOST DAY AND $700 COSTS. 3 MONTHS LATER, WE RECEIVED RECALL NOTICE TO REPLACE THE LINES AGAIN. THE NOTICE SAYS WE COULD QUALIFY FOR REIMBURSEMENT, BUT WHEN I CALLED DETROIT DIESEL, THEY SAID NO. SEEMS THAT DEFECTIVE LINES WERE THE PROBLEM ALL ALONG, REGARDLESS OF THE TIME FRAME. *TR
NHTSA ODI #10268347
148,419 miles · Oct 12, 2006
Fuel System, Diesel
DT*: THE CONTACT STATED WHILE DRIVING 65MPH, THE FUEL LINE ASSEMBLY BURST WITHOUT WARNING AND BEGAN TO SPRAY DIESEL FUEL ONTO THE VEHICLE AND THE HIGHWAY. THE VEHICLE WAS PARKED ON THE SIDE OF THE HIGHWAY WITHOUT FURTHER INCIDENT. UPON INSPECTION OF THE VEHICLE, THE CONTACT DETERMINED THE FUEL LINES WERE FRACTURED AND NEEDED …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 65MPH, THE FUEL LINE ASSEMBLY BURST WITHOUT WARNING AND BEGAN TO SPRAY DIESEL FUEL ONTO THE VEHICLE AND THE HIGHWAY. THE VEHICLE WAS PARKED ON THE SIDE OF THE HIGHWAY WITHOUT FURTHER INCIDENT. UPON INSPECTION OF THE VEHICLE, THE CONTACT DETERMINED THE FUEL LINES WERE FRACTURED AND NEEDED TO BE REPLACED. A NHTSA RECALL, #05V469000 REMEDY REPAIR TO THE ENGINE BY EMC RECALIBRATION AND REPLACEMENT OF THE FUEL LIFT PUMP WAS PERFORMED WHICH PERTAINED TO THE FUEL SYSTEM. HOWEVER, THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER AN ADDITIONAL REPAIR WITHOUT CHARGE UNDER THE RECALL. THE MANUFACTURER WAS ALERTED.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
Consequence & remedy
Consequence: THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 FREIGHTLINER BUSINESS CLASS C2, FCCC B2 CHASSIS, S2 CHASSIS, AND MC CHASSIS MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.
Consequence & remedy
Consequence: THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.
Remedy: DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE.
Consequence & remedy
Consequence: A FRACTURED FUEL LINE MAY LEAK DIESEL FUEL POSSIBLY RESULTING IN A FIRE OR FUEL MAY BE SPILLED ON THE ROAD CAUSING A SLIPPERY SURFACE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.
DAIMLER TRUCKS IS RECALLING 28,764 MY 2001 THROUGH 2008 FCCC B2 AND FS65 SCHOOL BUS CHASSIS, FCCC FB65 CONVENTIONAL BUSES, AND STERLING ACTERRA, FREIGHTLINER FLN, AND BUSINESS CLASS M2 HEAVY TRUCKS, BUILT FROM JANUARY 26, 2000, THROUGH MARCH 24, 2008, MANUFACTURED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. THESE AXLE ASSEMBLIES MAY HAVE BEEN PRODUCED WITH A THIN SPINDLE NUT WHICH MAY LEAD TO INCORRECT END PLAY, CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.
Consequence & remedy
Consequence: CONTINUED OPERATION MAY LEAD TO WHEEL SEPARATION AND POSSIBLY A VEHICLE CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS IS RECALLING 62,000 MY 2005-2007 FREIGHTLINER BUSINESS CLASS, CENTURY CLASS, COLUMBIA, CORONADO, FLD, CLASSIC, STERLING A-LINE, L-LINE, AND WESTERN STAR 4900 TRUCKS. A FRACTURED FUEL LINE COULD LEAK DIESEL FUEL.
Consequence & remedy
Consequence: IF A LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS, FUEL MAY IGNITE AT A HOT ENGINE SURFACE AND/OR FUEL MAY BE SPILLED ON THE ROAD SURFACE.
Remedy: HIGH PRESSURE FUEL LINES AND TRANSFER TUBES WILL BE INSPECTED AND REPLACED FREE OF CHARGED. THE RECALL BEGAN ON JULY 9, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Consequence & remedy
Consequence: THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN TRUCKS EQUIPPED WITH FONTAINE MODIFICATION RIGHT HAND STEERING CONTROL AND EQUIPPED WITH SIT DOWN DUAL DRIVE CONVERSIONS, THE PINCH BOLT THAT SECURES THE LOWER STEERING SHAFT CONNECTION TO THE LH MITER BOX MAY HAVE BEEN IMPROPERLY TORQUED CAUSING THE BOLTS TO FALL OUT.
Consequence & remedy
Consequence: THIS MAY CAUSE A LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND REPLACE THE LOWER STEERING SHAFT PINCH BOLT AT THE CONNECTION AND BOLTS ON THE STEERING CROSS SHAFT WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 17, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
CERTAIN 2005 THOMAS BUILT FS-65 AND C-2 SCHOOL BUSES AND 2005 FREIGHTLINER ARGOSY, COLUMBIA, CENTURY ST, AND M2 BUSINESS CLASS TRUCKS MANUFACTURED BETWEEN JUNE 4 AND JULY 8, 2005. THE SPINDLES IN THE REAR AXLE HOUSING WERE OVERHEATED DURING THE HEAT TREATMENT PROCESS. INCORRECTLY HEAT TREATED SPINDLES COULD RESULT IN A FRACTURE OF THE SPINDLE.
Consequence & remedy
Consequence: INCORRECTLY HEAT TREATED SPINDLES COULD FRACTURE, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: FREIGHTLINER WILL NOTIFY ITS CUSTOMERS AND INSPECT FOR THE HEAT TREAT DATE CODE ON THE END OF THE REAR SPINDLES AND REPLACE THE AXLE HOUSING IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN ON JANUARY 23, 2006. OWNERS MAY CONTACT FREIGHTLINER
CERTAIN 2004 AND 2005 THOMAS BUILT C2 SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2 HEAVY TRUCKS MANUFACTURED BETWEEN JUNE 2004 AND MARCH 2005. THE ANCHOR/PIVOT BOLT SUPPLIED WITH THE PARK BRAKE IS DEFECTIVE AND COULD FATIGUE FRACTURE PREMATURELY, RESULTING IN THE PARK BRAKE FAILING TO APPLY.
Consequence & remedy
Consequence: IF THE PARK BRAKE ANCHOR BOLT FATIGUES AND ULTIMATELY FRACTURES, THE PARK BRAKE MAY NOT FUNCTION AND THERE MAY BE NO INDICATION TO THE DRIVER OF THE MALFUNCTION WHEN THE PARK BRAKE IS SET. THIS MAY CAUSE THE VEHICLE TO ROLL AWAY WITHOUT WARNING, WHICH COULD RESULT IN A CRASH.
Remedy: FREIGHTLINER WILL NOTIFY ITS OWNERS AND INSPECT AND REPLACE DEFECTIVE ANCHOR BOLTS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10007 · Stop Lamps Intermittent
Opened Feb 3, 2010 · Closed May 23, 2010
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
Additional source detail variants (6)
Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
Exterior Lighting:brake Lights
This investigation was opened after ODI was contacted by a fleet alleging that in certain situations, such as a light brake peal application during a low speed operation, the brake lamps fail to illuminate on the rear of the bus.ODI confirmed the problem with two fleets.On April 29, 2010, Daimler filed a defect report concerning this issue. The stop lamps may be intermittent during light brake applications.They are still evaluating the remedial program and will furnish this information to ODI when it is available. This safety recallresolves the issue raised by this investigation. Hence, this investigation is closed.
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Additional source detail variants (3)
Suspension:front:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Suspension:front:wheel Bearing
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Wheels:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
2005 Freightliner Business Class M2 Problems, Complaints & Recalls | Skip That Year
Illustration