TL* THE CONTACT OWNS A 2008 FOUR WINDS HURRICANE. WHILE THE VEHICLE WAS STATIONARY, THERE WAS A BURNING ORDER COMING FROM THE TRANSFER SWITCH. THE CONTACT NOTICED THAT THE CASE WAS OVERHEATED AND THERE WERE BURN MARKS AROUND THE SWITCH. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSFER SWITCH FAILED AND …
Read full complaint
TL* THE CONTACT OWNS A 2008 FOUR WINDS HURRICANE. WHILE THE VEHICLE WAS STATIONARY, THERE WAS A BURNING ORDER COMING FROM THE TRANSFER SWITCH. THE CONTACT NOTICED THAT THE CASE WAS OVERHEATED AND THERE WERE BURN MARKS AROUND THE SWITCH. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSFER SWITCH FAILED AND THE OVERHEATING WAS SEVERE ENOUGH TO DAMAGE THE SHORE CORD AND CAUSED WIRES TO MELT. THE TRANSFER SWITCH WAS REPLACED HOWEVER, NONE OF THE DAMAGED PARTS WERE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V516000( ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 8,032. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10746664
35,900 miles · Sep 4, 2012
Electrical SystemCrash
THE CHASSIS BATTERY DISCONNECT SOLENOID FAILED WHILE DRIVING ON AN INTERSTATE ON-RAMP, CAUSING A COMPLETE LOSS OF ALL POWER, INCLUDING BRAKES, STEERING AND ALL LIGHTING. THE SOLENOID IS DESIGNED TO DISCONNECT THE BATTERY FOR LONG-TERM STORAGE. IT FAILED WITHOUT WARNING, BASICALLY UNHOOKING THE CHASSIS BATTERY FROM THE VEHICLE WH…
Read full complaint
THE CHASSIS BATTERY DISCONNECT SOLENOID FAILED WHILE DRIVING ON AN INTERSTATE ON-RAMP, CAUSING A COMPLETE LOSS OF ALL POWER, INCLUDING BRAKES, STEERING AND ALL LIGHTING. THE SOLENOID IS DESIGNED TO DISCONNECT THE BATTERY FOR LONG-TERM STORAGE. IT FAILED WITHOUT WARNING, BASICALLY UNHOOKING THE CHASSIS BATTERY FROM THE VEHICLE WHILE GOING DOWN THE ROAD. WHILE BROKEN DOWN, A TRACTOR-TRAILER SIDE-SWIPED OUR CARGO TRAILER AND RV CAUSING CONSIDERABLE DAMAGE. WE WERE LUCKY THAT WE WEREN'T AT HIGHWAY SPEEDS OR FAR MORE SERIOUS DAMAGE COULD HAVE OCCURRED, AND THE POTENTIAL FOR LOSS OF LIFE IS SIGNIFICANT. THERE SHOULD BE A RECALL OF ALL VEHICLES THAT USE THIS SOLENOID...UPDATED 10/09/12 *BF
Thor Motorcoach is recalling certain model year 2008-2010 motorhomes, manufactured June 1, 2007, through May 1, 2009 and equipped with an Iota ITS-50R Transfer Switch. The models affected are Four Winds brand models: Chateau, Dutchmen, Hurricane, Windsport, Magellan, Fun Mover, Presidio, and Mandalay. Wiring connections inside the transfer switch are not adequate and, as a result, the switch may overheat.
Consequence & remedy
Consequence: An overheated switch could cause it to fail and lead to a fire.
Remedy: Thor Motorcoach will notify owners and replace the Iota Transfer Switch, free of charge. The safety recall began on November 16, 2012. Owners may contact Thor at 1-877-500-1020.
FOUR WINDS IS RECALLING 684 MY 2002-2006 INFINITY, MY 2002-2007 WINDESPORT, MY 2004-2008 HURRICANE, MY 2006-2007 MEGALLAN AND MY 2008 FUN MOVER MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
FOUR WINDS IS RECALLING 49 MY 2007-2008 HURRICAN AND WINDSPORT MOTOR HOMES BUILT ON WORKHORSE RECREATIONAL VEHICLE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY. THE IMPROPER TORQUE MAY HAVE DAMAGED THE CASTLE NUT AND COMPROMISED THE INTEGRITY OF THE CONNECTION.
Consequence & remedy
Consequence: IF THE DRAG LINK WERE TO SEPARATE FROM THE PITMAN ARM, THE DRIVER WOULD NOT HAVE DIRECTIONAL CONTROL OF THE VEHICLE POSSIBLY CAUSING A CRASH.
Remedy: FOUR WINDS IS WORKING WITH WORKHORSE TO REPLACE AND PROPERLY TIGHTEN THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM (PLEASE SEE 08V442). OWNERS MAY CONTACT WORKHORSE AT 1-877-946-7731 OR FOUR WINDS AT 1-800-860-5658.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Four Winds Hurricane Problems, Complaints & Recalls | Skip That Year
Illustration