NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
276 reportsClear category filter107,547 miles · Jun 24, 2009
EquipmentStructure
TL*THE CONTACT OWNS A 1999 FORD WINDSTAR. WHEN THE CONTACT TOOK THE VEHICLE IN FOR SERVICE, THE MECHANIC NOTICED RUST IN THE SUBFRAME COMING FROM THE AIR CONDITIONING. CONDENSATION FROM THE AIR CONDITIONING ON THE PASSENGER SIDE WAS DRIPPING ONTO THE SUBFRAME, WHICH CAUSED THE RUST. THE DEALER STATED THAT THERE WERE NO FAILUR…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD WINDSTAR. WHEN THE CONTACT TOOK THE VEHICLE IN FOR SERVICE, THE MECHANIC NOTICED RUST IN THE SUBFRAME COMING FROM THE AIR CONDITIONING. CONDENSATION FROM THE AIR CONDITIONING ON THE PASSENGER SIDE WAS DRIPPING ONTO THE SUBFRAME, WHICH CAUSED THE RUST. THE DEALER STATED THAT THERE WERE NO FAILURES AND THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR. THE MANUFACTURER ALSO STATED THAT THE CONTACT WOULD BE LIABLE. THE VEHICLE WILL BE REPAIRED AT THE CONTACT'S EXPENSE FOR A LITTLE MORE THAN $3,000. THE FAILURE MILEAGE WAS 107,547 AND CURRENT MILEAGE WAS 107,560.
NHTSA ODI #10274864
128,000 miles · Jun 14, 2009
Structure
WHEN HAVING THE BALL JOINTS REPLACED AND AN ALIGNMENT DONE, OUR MECHANIC NOTED THAT THE ENGINE CRADLE IS SEVERELY RUSTED AND NEEDS TO BE REPLACED. HE CLAIMED THAT IT WAS FAR WORSE THAN IT EVER SHOULD BE AND IF THIS WAS A GM, THEY WOULD TAKE CARE OF IT. HOWEVER, THIS IS A FORD AND THEY WILL DO NOTHING. *TR
NHTSA ODI #10273729
98,000 miles · Jun 12, 2009
Structure
1999 FORD WINDSTAR- WAS HEARING A LOT OF DEEP SOUNDING SQUEAKING FROM THE PASSENGER FRONT SIDE. ALSO SOME CRACKING SOUNDS WHEN ACCELERATING FROM A STOP. HAD A MECHANIC LOOK AND FOUND THE SUBFRAME WAS VERY BADLY RUSTED. WE REPLACED THE SUBFRAME. THE REPAIR SHOP TOOK PICTURES FOR US AND WE WERE HORRIFIED TO SEE HOW SEVERE THE …
Read full complaint
1999 FORD WINDSTAR- WAS HEARING A LOT OF DEEP SOUNDING SQUEAKING FROM THE PASSENGER FRONT SIDE. ALSO SOME CRACKING SOUNDS WHEN ACCELERATING FROM A STOP. HAD A MECHANIC LOOK AND FOUND THE SUBFRAME WAS VERY BADLY RUSTED. WE REPLACED THE SUBFRAME. THE REPAIR SHOP TOOK PICTURES FOR US AND WE WERE HORRIFIED TO SEE HOW SEVERE THE SITUATION ACTUALLY WAS. IT WAS VERY CLOSE TO RUSTING COMPLETELY THROUGH. 1999 WINDSTAR WITH 98,000 MILES. COST TO REPAIR WAS APROX. $1500. THE CAR RIDES VERY SMOOTH NOW THAT IT HAS BEEN REPAIRED. BIG DIFFERENCE IN THE FEEL. WAS NOT AWARE HOW BOUNCY THE CAR WAS RIDING. NOW IT FEELS ALMOST LIKE A NEW SUSPENSION. *TR
NHTSA ODI #10273591
99,000 miles · May 26, 2009
StructureSuspension
ON MAY 22 MY 1999 FORD WINDSTAR VAN STARTED TO MAKE A SQUEALING/WHINING NOISE AT APPROXIMATELY 10:30 IN THE MORNING DURING WHAT SHOULD HAVE BEEN A 40 MINUTE DRIVE TO MY MOTHERS HOUSE. DUE TO THE WEIRD NOISE I STOPPED AND CHECKED THE AIR PRESSURE IN MY TIRE (RIGHT REAR) WHERE THE SOUND SEEMED TO BE ORIGINATING FROM. THE PRESSURE …
Read full complaint
ON MAY 22 MY 1999 FORD WINDSTAR VAN STARTED TO MAKE A SQUEALING/WHINING NOISE AT APPROXIMATELY 10:30 IN THE MORNING DURING WHAT SHOULD HAVE BEEN A 40 MINUTE DRIVE TO MY MOTHERS HOUSE. DUE TO THE WEIRD NOISE I STOPPED AND CHECKED THE AIR PRESSURE IN MY TIRE (RIGHT REAR) WHERE THE SOUND SEEMED TO BE ORIGINATING FROM. THE PRESSURE WAS A LITTLE LOW SO I TOPPED IT OFF AND CONTINUED ON MY TRIP. THE SOUND CONTINUED AND I DECIDED TO STOP AT A SERVICE STATION ABOUT 20 MORE MILES INTO THE TRIP. THE SERVICE STATION WAS LITTLE HELP, THEY CHECKED MY POWER STEERING FLUID, DROVE THE VAN AROUND THE PARKING LOT A COUPLE OF TIMES AND IT MADE NO NOISES. THE ATTENDANT TOLD ME HE DIDN'T HAVE ANY IDEA AS TO WHAT THE SOUND MIGHT BE AND ASKED IF I COULD RETURN IN AN HOUR WHEN HIS SUPERIOR WOULD BE THERE. I AGREED TO RETURN AFTER DROPPING OFF MY KIDS AT MY MOTHERS. AFTER GOING ON DOWN THE ROAD ABOUT ANOTHER TEN MILES I FELT THE STEERING WHEEL START TO FLOAT AND DRIFT AND MY BRAKES BECAME USELESS AND THE VAN CAME TO AN ABRUPT HALT AND THERE WAS A HUGE BANG AS THE ENTIRE REAR END OF THE VEHICLE BECAME DISABLED. AS WE ALL PILED OUT TO SEE WHAT WAS WRONG WE FOUND THE REAR WHEELS POINTING INWARD UNDER THE VAN AT A BACKWARDS ANGLE. SOME MEN CAME TO HELP ME WHO WERE NEARBY THEY INFORMED ME MY AXLE WAS SNAPPED. LOOKING UNDER THE VEHICLE I COULD CLEARLY SEE THEY WERE RIGHT. MY VAN WILL BE REPAIRED THIS WEEKEND. I CALLED FORD THEY BASICALLY TOLD ME TO EAT THE REPAIRS MYSELF. IN WV A YEARLY INSPECTION IS REQUIRED, I PASSED INSPECTION AT THE BEGINNING OF APRIL WHICH TELLS ME THERE WAS NOTHING VISUALLY WRONG WITH MY AXLE LESS THAN TWO MONTHS AGO. I FIND IT HARD TO BELIEVE THAT WITHOUT ANY OUTSIDE DAMAGE OR FORCE (ACCIDENTS, FORCE ECT) AN AXLE CAN JUST SNAP IN TWO. IF I HAD BEEN TRAVELING ANY FASTER MY 4 CHILDREN AND MYSELF WOULD HAVE BEEN KILLED OR HARMED AS AT THE MOMENT IT BROKE I HAD LITTLE CONTROL OVER THE VEHICLE AND THE BRAKES WERE FAILING. ONLY PEOPLE WITH CHILDREN BUY MINI-VANS, THIS IS SCARY. *TR
NHTSA ODI #10270011
77,817 miles · Mar 29, 2009
Structure
WE HAVE A 99 WINDSTAR WITH A BROKEN ENGINE CRADLE. MY WIFE WAS DRIVING THE VAN ALONG WITH MY SON TO A LOCAL RETAILER. SHE WAS IN THE MIDDLE LANE WHEN SHE HEARD A LOUD BANG UNDER THE VAN. MY SON WHO WAS SITTING TON THE PASSENGER SIDE SAID HE FELT IT UNDER HIS FEET. SHE WAS ABLE TO GET THE VAN TO THE SIDE OF THE ROAD EVEN THOUGH T…
Read full complaint
WE HAVE A 99 WINDSTAR WITH A BROKEN ENGINE CRADLE. MY WIFE WAS DRIVING THE VAN ALONG WITH MY SON TO A LOCAL RETAILER. SHE WAS IN THE MIDDLE LANE WHEN SHE HEARD A LOUD BANG UNDER THE VAN. MY SON WHO WAS SITTING TON THE PASSENGER SIDE SAID HE FELT IT UNDER HIS FEET. SHE WAS ABLE TO GET THE VAN TO THE SIDE OF THE ROAD EVEN THOUGH THE STEERING WAS VERY DIFFICULT. SHE WAS ABOUT 5 MILES FROM HOME SO DECIDED TO TAKE IT BACK HOME. SURPRISINGLY SHE WAS ABLE TO GET IT HOME. I CRAWLED UNDER THE UNIT AND IMMEDIATELY SAW THAT THE ENGINE CRADLE HAD SNAPPED ON THE PASSENGER SIDE REAR. IT WAS THEN THAT WE STOPPED DRIVING THE VAN DUE TO SAFETY CONCERNS. I DID SOME RESEARCH ON THE WEB AND THEY WERE SEVERAL COMPLAINTS IDENTICAL TO OURS. IT SEEMS THAT THE AC DRAIN HOSE IS SITUATED OVER THE EXACT LOCATION OF THE BREAK. APPARENTLY OVER A PERIOD OF TIME THIS CAUSES THE FRAME TO RUST OUT. I CALLED FORD TO COMPLAIN AND THEY SAID THAT THERE WAS NOTHING THEY COULD DO. I CALLED MY LOCAL FORD DEALER AND PASSED ON BUYING A NEW PART DUE TO THE COST. I HAD TO TAKE A DAY OFF FROM WORK AND GO JUNKYARD SHOPPING TO FIND A REPLACEMENT PART. I LOCATED ONE AND WE HAD THE UNIT TOWED TO LUCAS FORD IN BURLINGTON, N.J. WHERE MY WIFE WORKS PART TIME. THE PART WAS DELIVERED AND THE DEALER DID THE REPLACEMENT ALONG WITH A BAD RACK AND PINION UNIT THAT WAS DISCOVERED AT THE SAME TIME. THE UNIT HAD 77,817 ON THE ODOMETER AT THE TIME THE WORK WAS DONE. I CAN UNDERSTAND MECHANICAL ITEMS GOING BAD BUT THIS WAS A STRUCTURAL ITEM. THIS SITUATION COULD HAVE BEEN SO MUCH WORSE SAY HAD SHE BEEN ON THE INTERSTATE DOING 65 MPH INSTEAD OF ON A LOCAL ROAD DOING 40 MPH. I COULD SEE IF THIS WAS AN ISOLATED INCIDENT BUT IT ISN'T. I CONTACTED FORD ONE MORE TIME AND COMPLAINED AGAIN TO NO AVAIL. I HAVE ALWAYS OWNED FORDS AND PROBABLY ALWAYS WILL BUT THIS EXPERIENCE ALONG WITH ONE I HAD CONCERNING MY 1985 THUNDERBIRD CONTROL MODULE HAS LEFT A BAD TASTE IN MY MOUTH AS TO HOW THEY TAKE CARE OF THEIR CUSTOMERS. *TR
NHTSA ODI #10263535
124,000 miles · Mar 21, 2009
Structure
THE ENGINE CRADLE HAS RUSTED OUT ON MY 1999 WINDSTAR VAN. THIS HAS OCCURRED DUE TO A FAULTY DESIGN BY FORD. AFTER RESEARCH I FOUND THAT THE AIR CONDITIONER LEAKS ON THE CRADLE CREATING A COMMON PROBLEM OF THE CRADLE RUSTING OUT. THIS CAN BE AND HAS BEEN RESULTING IN CAR ACCIDENT DEATHS. I WAS LUCKY. I HAD THE CAR AT THE FORD DEA…
Read full complaint
THE ENGINE CRADLE HAS RUSTED OUT ON MY 1999 WINDSTAR VAN. THIS HAS OCCURRED DUE TO A FAULTY DESIGN BY FORD. AFTER RESEARCH I FOUND THAT THE AIR CONDITIONER LEAKS ON THE CRADLE CREATING A COMMON PROBLEM OF THE CRADLE RUSTING OUT. THIS CAN BE AND HAS BEEN RESULTING IN CAR ACCIDENT DEATHS. I WAS LUCKY. I HAD THE CAR AT THE FORD DEALERSHIP IN ENGLEWOOD FLORIDA(BAY HARBOR FORD) FOR ANOTHER PROBLEM AND THEY WENT TO PUT MY CAR ON THE LIFT AND THE CRADLE BROKE BECAUSE OF THE RUST. THEY ARE REPLACING THE CRADLE AND THEN CONTINUING ON THE REPAIRS. THE COST TO ME IS EXPECTED AROUND $2,200 OR MORE. THEY HAVE ORDERED A USED CRADLE. FORD INSPECTED MY CAR BEFORE I PURCHASE IT AND NEVER TOLD ME ABOUT THIS RUST PROBLEM. I PURCHASED THE VAN IN 2007- OCT BASED ON THEIR BLESSING THAT IT WAS A SOUND, SAFE VEHICLE AND WOULD LAST ME FOR AT LEAST ANTHER 200,000 MILES. *TR
NHTSA ODI #10262660
135,000 miles · Jan 27, 2009
Structure
WHILE DRIVING IN A RESIDENTIAL AREA, STEERING WHEEL JERKED TO THE RIGHT AND TRANSMISSION SEEMED TO ENTER NEUTRAL. UPON INSPECTION, FOUND THAT THE WELD THAT ANCHORS THE CONTROL ARM TO THE ENGINE CRADLE/SUBFRAME HAD BROKEN. CONTROL ARM PULLED AWAY FROM THE CRADLE AND DISLODGED THE RIGHT HALFSHAFT LEAVING VEHICLE IMMOBILE. VEHICLE …
Read full complaint
WHILE DRIVING IN A RESIDENTIAL AREA, STEERING WHEEL JERKED TO THE RIGHT AND TRANSMISSION SEEMED TO ENTER NEUTRAL. UPON INSPECTION, FOUND THAT THE WELD THAT ANCHORS THE CONTROL ARM TO THE ENGINE CRADLE/SUBFRAME HAD BROKEN. CONTROL ARM PULLED AWAY FROM THE CRADLE AND DISLODGED THE RIGHT HALFSHAFT LEAVING VEHICLE IMMOBILE. VEHICLE HAS NOT YET BEEN REPAIRED. A NON-MOVING, FRICTIONLESS PART SHOULD NOT BREAK UNDER NORMAL USE. *TR
NHTSA ODI #10256488
Mileage unknown · Jan 18, 2009
Structure
PAINT PEELING OFF 1999 FORD WINDSTAR. *TR
NHTSA ODI #10255466
80,000 miles · Jan 8, 2009
Structure
THE FRONT SUBFRAME RUSTED THROUGH ON BACK PASSENGER SIDE. THE REST OF THE VEHICLE IS RUST FREE FOR THE MOST PART. THE CAR HAS 80,300 MI . ITS A 1999 FORD WINDSTAR. *TR
NHTSA ODI #10254257
125,000 miles · Dec 29, 2008
Structure
1999 FORD WINDSTAR SE FAILED PENNSYLVANIA STATE INSPECTION,DUE TO ROTTING METAL ON FRONT SUBFRAME,LOCATED NEAR WERE CONNECTION TO UNI-BODY EXIST. SUBFRAME HAS ROTTED A HOLE AND IS CONTINUING TO DETERIORATE. PASSENGER SIDE. *TR
NHTSA ODI #10253030
Official recalls
11Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.
Consequence & remedy
Consequence: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Consequence & remedy
Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.
Consequence & remedy
Consequence: A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.
Consequence & remedy
Consequence: A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jan 26, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Aug 26, 2010
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Consequence & remedy
Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 15, 2001
VEHICLE DESCRIPTION: MINI VANS. CONTAMINANTS SUCH AS WATER, SALT, AND WINDSHIELD WASHER SOLUTION CAN ENTER THE WIPER MOTOR COVER ASSEMBLY THROUGH PINHOLES ON THE EXTERIOR OF THE COVER THAT ARE USED IN THE MOLDING PROCESS. IN ADDITION, ON CERTAIN OF THE VEHICLES BUILT BETWEEN FEBRUARY AND AUGUST 2000, A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT. EITHER OF THESE CONDITIONS COULD POTENTIALLY RESULT IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, SMOKE, OR IGNITION OF THE PLASTIC COVER MATERIAL. CONTAMINANT ENTRY COULD ALSO RESULT IN UNINTENDED WIPER MOTOR OPERATION.
Consequence & remedy
Consequence: SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER COVER WITH IMPROVED SEALING AND WATER RESISTANCE. OWNER NOTIFICATION BEGAIN AUGUST 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 15, 2001
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH AUXILIARY REAR AIR-CONDITIONING. IF THE AUXILIARY AIR-CONDITIONING BLOWER MOTOR STOPS TURNING WHILE IN THE MEDIUM-LOW BLOWER SPEED SETTING, THERE IS THE POTENTIAL THAT THE RESISTOR MAY BECOME HOT AND SMOKE.
Consequence & remedy
Consequence: THE MOTOR COULD POTENTIALLY CATCH ON FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER WIRE THAT WILL ENSURE THAT THE MEDIUM-LOW BLOWER SPEED SETTING IS PROTECTED BY THE THERMAL LIMITER. OWNER NOTIFICATION BEGAN AUGSUT 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Oct 30, 2000
VEHICLE DESCRIPTION: MINIVANS BUILT WITH INSTRUMENT CLUSTERS WITHOUT THE MESSAGE CENTER, FAIL TO COMPLY WITH THE REQUIREMENTS OF STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT DOORS ARE OPENED.
Consequence & remedy
Consequence: THE STANDARD REQUIRES THAT POWER OPERATED WINDOWS MAY BE CLOSED ONLY WHEN THE KEY IS IN THE "ON," "START," OR "ACCESSORY" POSITIONS, OR DURING THE INTERVAL BETWEEN THE TIME THE KEY IS TURNED OFF, AND THE OPENING OF EITHER OF THE VEHICLE'S FRONT DOORS.
Remedy: DEALERS WILL RECONFIGURE THE VEHICLE FRONT END ELECTRONIC MODULE.
Jun 14, 1999
VEHICLE DESCRIPTION: MINIVANS. THE BRAKE FLUID MASTER CYLINDER IS RECESSED AND ORIENTED IN THE ENGINE COMPARTMENT SO THAT THE BRAKE FLUID WARNING STATEMENT EMBOSSED ON BOTH THE TOP OF THE FILLER CAP AND THE SIDE OF THE RESERVOIR BODY ARE NOT ENTIRELY VISIBLE BY DIRECT VIEW. THESE VEHICLES MAY NOT FULLY COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE PROVIDED WITH NEW LABELS AND INSTALLATION INSTRUCTIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA10007 · Front Subframe Corrosion Failures
Opened Dec 20, 2010 · Closed Mar 17, 2011
Status: closed (inferred from source dates) · Structure:frame And Members; Suspension
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
Additional source detail variants (2)
Structure:frame And Members
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
Suspension
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
PE10026 · Front Subframe Corrosion Failures
Opened Jul 20, 2010 · Closed Dec 20, 2010
Status: closed (inferred from source dates) · Structure:frame And Members; Suspension
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
Additional source detail variants (2)
Structure:frame And Members
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
Suspension
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
PE10016 · Rear Axle Cracking
Opened May 13, 2010 · Closed Sep 22, 2010
Status: closed (inferred from source dates) · Suspension
In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September 1, 1997 through February 28, 2003 and either sold or currently registered in high corrosion (Salt-Belt) states where the use of salt and other corrosive chemicals may be used to treat snow/ice covered roads.The following states are included in Ford's recall:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. The subject vehicles utilize a Stamped/Formed axle assembly manufactured by Benteler automotive Corporation of Galesburg, MI.According to Ford, after many years of vehicle service in the Salt-Belt states, corrosion can weaken the rear axle, making it susceptible to torsional stress.There is a risk that the combined effects of corrosion and stress can lead to cracks which, if undetected, can propagate and result in a complete fracture of the axle.A completely fractured axle can affect vehicle handling and increase the risk of a crash.To correct the safety defect, Ford will initially inspect all of the subject vehicles brought into Ford/Lincoln-Mercury dealerships for possible cracked axles.Owners of vehicles without cracked axles will be notified when to return for the installation of reinforcement brackets to extend the axle durability in the presence of corrosion.Owners who have vehicles with cracked axles will either be offered a repair or alternative transportation until parts become available. On May 13, 2010, the Office of Defects Investigation (ODI) opened PE10-016 to investigate complaints of rear axle cracking in MY 1999 through 2003 Ford Windstar minivans.Combining ODI and Ford complaint data, ODI is aware of a total 891 complaints alleging rear axle cracking in the subject vehicles.Over a third of the complaints (334) allege that the cracking progressed to a complete fracture of the rear axle, including 8 allegations of crashes resulting in 3 injuries. Approximately 57 percent of the subject vehicles (524,661) were sold in Salt-Belt states covered by Ford's recall and Ford estimates that approximately 463,000 of these remain in service.Ninety-six percent of the complaints (858) and all of the complaints alleging complete fracture were from the recall region.The action taken by Ford is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
EA08021 · Engine Compartment Fires
Opened Sep 17, 2008 · Closed Oct 14, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Additional source detail variants (7)
Electrical System
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Electrical System:wiring
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE08035 · Engine Compartment Fires
Opened May 13, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (3)
Electrical System
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Electrical System:wiring
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
PE04022 · Power Sliding Door Opening
Opened Mar 3, 2004 · Closed Jul 1, 2004
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:door:hinge And Attachments
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Structure:body:door
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Structure:body:door:hinge And Attachments
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03004 · Wheel Stud Fracture
Opened Apr 10, 2003 · Closed Aug 30, 2004
Status: closed (inferred from source dates) · Wheels; Wheels:lugs/nuts/bolts/studs
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Wheels
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Wheels:lugs/nuts/bolts/studs
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02085 · Wheel Stud Fracture
Opened Nov 18, 2002 · Closed Apr 10, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:lugs/nuts/bolts/studs
ANALYSIS OF ODI AND FORD DATA HAS IDENTIFIED 1619 INCIDENTS OF WHEEL STUD FRACTURE IN MY 1998 THROUGH 2000 FORD WINDSTAR VEHICLES, INCLUDING 69 WHEEL SEPARATIONS AND 11 CRASHES.FORD HAS NOT BEEN ABLE TO IDENTIFY ANY DESIGN OR MANUFACTURING DEFECTS IN ITS ANALYZIS OF THE PROBLEM.FORD MAINTAINS THAT THE FAILURES ARE CAUSED BY EITHER:(1) INADVERTENT OVERTORQUING OF LUG NUTS DURING REMOVAL OR INSTALLATION; OR (2) FATIGUE DUE TO INSUFFICIENT CLAMP LOAD BETWEEN THE WHEEL AND THE BRAKE ROTOR OR DRUM AND HUB ASSEMBLY.ACCORDING TO FORD, CORROSION, DIRT, OR DAMAGE PRESENT ON THE ROAD WHEEL AT THE NUT INTEFACE COULD CONTRIBUTE TO THE LATTER CONDITION. ANALYSIS OF ODI COMPLAINT DATA INDICATES THAT THE SUBJECT VEHICLES EXPERIENCE WHEEL STUD FAILURES AT SIGNIFICANTLY HIGHER RATES THAN PEER MINIVANS.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER ASSESS THE FREQUENCY, SCOPE, AND TREND OF THE ALLEGED DEFECT CONDITION IN MY 1997 THROUGH 2000 WINDSTAR MINIVANS.
Additional source detail variants (2)
Wheels
ANALYSIS OF ODI AND FORD DATA HAS IDENTIFIED 1619 INCIDENTS OF WHEEL STUD FRACTURE IN MY 1998 THROUGH 2000 FORD WINDSTAR VEHICLES, INCLUDING 69 WHEEL SEPARATIONS AND 11 CRASHES.FORD HAS NOT BEEN ABLE TO IDENTIFY ANY DESIGN OR MANUFACTURING DEFECTS IN ITS ANALYZIS OF THE PROBLEM.FORD MAINTAINS THAT THE FAILURES ARE CAUSED BY EITHER:(1) INADVERTENT OVERTORQUING OF LUG NUTS DURING REMOVAL OR INSTALLATION; OR (2) FATIGUE DUE TO INSUFFICIENT CLAMP LOAD BETWEEN THE WHEEL AND THE BRAKE ROTOR OR DRUM AND HUB ASSEMBLY.ACCORDING TO FORD, CORROSION, DIRT, OR DAMAGE PRESENT ON THE ROAD WHEEL AT THE NUT INTEFACE COULD CONTRIBUTE TO THE LATTER CONDITION. ANALYSIS OF ODI COMPLAINT DATA INDICATES THAT THE SUBJECT VEHICLES EXPERIENCE WHEEL STUD FAILURES AT SIGNIFICANTLY HIGHER RATES THAN PEER MINIVANS.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER ASSESS THE FREQUENCY, SCOPE, AND TREND OF THE ALLEGED DEFECT CONDITION IN MY 1997 THROUGH 2000 WINDSTAR MINIVANS.
Wheels:lugs/nuts/bolts/studs
ANALYSIS OF ODI AND FORD DATA HAS IDENTIFIED 1619 INCIDENTS OF WHEEL STUD FRACTURE IN MY 1998 THROUGH 2000 FORD WINDSTAR VEHICLES, INCLUDING 69 WHEEL SEPARATIONS AND 11 CRASHES.FORD HAS NOT BEEN ABLE TO IDENTIFY ANY DESIGN OR MANUFACTURING DEFECTS IN ITS ANALYZIS OF THE PROBLEM.FORD MAINTAINS THAT THE FAILURES ARE CAUSED BY EITHER:(1) INADVERTENT OVERTORQUING OF LUG NUTS DURING REMOVAL OR INSTALLATION; OR (2) FATIGUE DUE TO INSUFFICIENT CLAMP LOAD BETWEEN THE WHEEL AND THE BRAKE ROTOR OR DRUM AND HUB ASSEMBLY.ACCORDING TO FORD, CORROSION, DIRT, OR DAMAGE PRESENT ON THE ROAD WHEEL AT THE NUT INTEFACE COULD CONTRIBUTE TO THE LATTER CONDITION. ANALYSIS OF ODI COMPLAINT DATA INDICATES THAT THE SUBJECT VEHICLES EXPERIENCE WHEEL STUD FAILURES AT SIGNIFICANTLY HIGHER RATES THAN PEER MINIVANS.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER ASSESS THE FREQUENCY, SCOPE, AND TREND OF THE ALLEGED DEFECT CONDITION IN MY 1997 THROUGH 2000 WINDSTAR MINIVANS.
Illustration