Seats. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports3 fire reports1 injury reports

Service Brakes complaints

5 reports

Clear category filter

Mileage unknown · Jun 18, 2026

Service Brakes

Rear brake issues. Upon taking off the brake pads on the driver's back the caliper piston would not turn in as it should. So I ordered a new one. Then I started on the passenger rear. When I tried to press and turn the piston back in it did the same thing as the other one. The piston came out of the passenger rear caliper. …

Read full complaint

NHTSA ODI #11745147

Mileage unknown · Jun 16, 2026

Power TrainService Brakes

The bolts holding the axle together to the driveshaft failed on the rear right wheel, nearly causing an accident but fortunately it was 6am with little traffic on the interstate. The axle came out and destroyed our driveshaft, requiring a full replacement. We have had the vehicle serviced regularly since our purchase.

NHTSA ODI #11744442

33,000 miles · Jun 23, 2025

Power TrainService Brakes

Read full complaint

The contact owns a 2020 Ford Transit. The contact stated that whenever the vehicle was started, the contact stated that several unknown warning lights and the ABS warning light were illuminated. The contact stated that the right front wheel activated, and the ABS activated while making a hard right turn. The contact was not depressing the brake pedal during the failure. In addition, the contact was informed that the brake lights remained activated. The contact stated that several functions were deactivated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 33,000.

NHTSA ODI #11668587

Mileage unknown · Jun 20, 2024

Service Brakes

Read full complaint

We own a fleet of these vans and 5 out of the last 7 purchased from 2020-2023 have had total rear brake system failure. The calipers are not retracting and are overheating and freezing up the rear brake system. In some cases leaving our employee(s) stranded on the side of the road in the middle of winter storm waiting to get towed putting their safety at risk. The problem has been reproduced as it has happened on 5 of the last 7 vehicles we purchased. Our local Ford dealer has inspected these issues and we contacted the Ford Consumer phone today - spoke with Rena at Ford on 6/19/24 at approximately 2pm - 2:15pm PDT. No warning lamps or message alerts. Brakes are making a squeaky noise and hot smell prior to seizing. We have had to pay thousands of dollars for some of these repairs and towing. We wanted to alert Ford and you as we are noticing an alarming trend. In speaking with Ford Motor Company, they correlate this issue as a maintenance issue but if it was a maintenance issue, the front brakes would have failed before the rear. I will be completing this form for the additional VIN numbers. Thank you.

NHTSA ODI #11595458

Mileage unknown · Jun 19, 2024

Service Brakes

Read full complaint

NHTSA ODI #11595368

Official recalls

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V499000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Jul 19, 2023

Quality Vans (Quality Vans) is recalling certain 2020-2023 Ford Transit vans equipped with Onan QG 2800i EVAP generators, part number 2.8HGLAA-8303A. The fuel hose between the inline fuel filter and the Injection Pump Module (IPM) may not be properly secured, which can cause a gas leak.

Consequence & remedy

Consequence: A gasoline leak in the presence of an ignition source may increase the risk of fire.

Remedy: Dealers will inspect and replace the fuel hose and clamps as necessary, free of charge. Owner notification letters were mailed August 4, 2023. Owners may contact Quality Vans customer service at 1-480-464-7007.

21V978000 · Power Train:driveline:driveshaft

Dec 16, 2021

Ford Motor Company (Ford) is recalling certain 2020 Transit vehicles equipped with All Wheel Drive (AWD). The bolts that attach the rear driveshaft to the transfer case may become loose or damaged, which can result in separation of the driveshaft from the transfer case.

Consequence & remedy

Consequence: Driveshaft separation can result in a loss of drive power, or unintended movement while parked if the parking brake is not engaged, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the driveshaft bolts. If any loose bolts are found, the driveshaft, attachment hardware, transfer case flange kit, and seal will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S54.

21V631000 · Parking Brake:conventional:mechanical:linkage And Cable

Aug 11, 2021

Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.

Consequence & remedy

Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.

Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V415000 · Air Bags:side/window

Jul 17, 2020

Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.

Consequence & remedy

Consequence: In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.

Remedy: Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.

20V250000 · Seat Belts:front:retractor

May 5, 2020

National Van Builders, Inc. (National Van Builders) is recalling certain vehicles based on 2019-2020 Ford Transit and 2019 Ram Promaster vans equipped with Freedman GO-ES foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: National Van Builders will notify owners, and dealers will replace the retractors, free of charge. The recall began May 19, 2020. Owners may contact Freedman customer service at 1-800-443-4540 or National Van Builders customer service at 1-800-527-7477.

20V222000 · Seat Belts:front:retractor

Apr 20, 2020

TransitWorks is recalling certain Driverge vehicles based on 2019-2020 Ford Transit vans equipped with Freedman Seating Company (FSC) PT Foldaway and GO-ES 3-point Foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: TransitWorks will notify owners, and dealers will replace the retractors, free of charge. The recall began May 13, 2020. Dealers can contact Freedman Seating Company for parts and reimbursement information at 1-800-443-4540.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.