Seats. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports3 fire reports1 injury reports

Electrical System complaints

14 reports

Clear category filter

3,890 miles · May 12, 2021

Electrical SystemForward Collision Avoidance

Read full complaint

VEHICLE INSTRUMENT CLUSTER INTERMITTENTLY LOSES POWER, BOTH WHILE VEHICLE IS IN MOTION OR WHILE STOPPED. INSTRUMENT CLUSTER CEASES TO DISPLAY VEHICLE SPEED, ENGINE RPM, ENGINE TEMP, AND FUEL LEVEL, AS WELL AS ALL OTHER INFO THAT IS TYPICALLY DISPLAYED. THIS CONDITION CAN LAST SECONDS OR SEVERAL MINUTES AT A TIME. IF CRUISE CONTROL IS ACTIVE WHILE THE ISSUE OCCURS, CRUISE CONTROL CEASES TO FUNCTION AND THE VEHICLE STARTS TO SLOW DOWN UNEXPECTEDLY. WHEN THE INSTRUMENT CLUSTER REGAINS POWER, IT SOMETIMES FLASHES VARIOUS WARNINGS, SUCH AS "BLIND SPOT ASSIST ERROR," "TRANSMISSION NOT IN PARK," "PRE-COLLISION ASSIST ERROR," "ADAPTIVE CRUISE NOT AVAILABLE," AND "PARK ASSIST ERROR." THIS PROBLEM OCCURS INTERMITTENTLY, BUT HAS OCCURRED COUNTLESS TIMES SINCE THE VEHICLE WAS PURCHASED NEW IN JANUARY OF 2021.

NHTSA ODI #11416249

2,400 miles · Nov 19, 2020

Electrical System

VAN WAS STATIONARY ON STREET AND FAILED TO START TWO TIMES, BATTERY WAS FULLY CHARGED.

NHTSA ODI #11375400

612 miles · Feb 23, 2020

Electrical SystemSeats

Read full complaint

UPDATE TO COMPLAINT NO 11302124 DATED 2/26/2020 SPOKE WITH FORD CUST SERVICE REP REGARDING THE ISSUES AND WAS TOLD TO MAKE AN APPOINTMENT WITH DEALER TO CHECK OUT THE SEAT AND ELECTRIC SYSTEM. THE SERVICE DEPT CHECKED THE ISSUES ON 2/12/2020. THE SERVICE TECH VERIFIED THAT THE WIRE BUNDLE IS BEING DAMAGED BY THE SEAT BEING MOVED. THE SERVICE TECH WRAPPED THE BUNDLE WITH TAPE AND RE-ROUTED THE BUNDLE. THE SEAT WAS TESTED FORWARD AND BACK BUT I DON'T BELIEVE THE SWIVEL WAS TESTED. IT APPEARS THAT THE WIRE BUNDLE AND DRIVER'S SWIVEL SEAT NEEDS FURTHER TESTING AND REPAIRS TO ASSURE THAT THE SWIVEL SEAT IS NOT DAMAGING THE WIRE BUNDLE. DAMAGE TO THE DRIVER'S SEAT WIRE BUNDLE MIGHT AFFECT SEAT AIR BAG OPERATION CAUSING EITHER FAILURE TO DEPLOY OR DEPLOYING WHEN NOT NEEDED. DAMAGE ALSO MIGHT AFFECT SEAT BELT AND SEAT WEIGHT/ORIENTATION SENSORS. FOLLOWING ARE THE FORD SERVICE TECH NOTES FROM THE SERVICE WORK ORDER: CUSTOMER STATES WIRING BUNDLE UNDER DRIVER SEAT THAT IS BEING DAMAGE FROM THE SEAT MOVING BACK AND FORTH PLEASE CHECK AND ADVISE CAUSE 612 DRIVERS SEAT HARNESS IS CHAFFING ON SEAT RIVETS VERIFIED DRIVERS SEAT HARNESS IS CHAFFING ON SEAT RIVETS. HAD SERVICE WRITER TAKE PICTURES OF DAMAGE. CHECKED OASIS NO TSB'S, SSM'S, OR GSB'S RELATED. WRAPPED HARNESS WITH HIGH TEMP CLOTH ELECTRICAL TAPE AND RE-ROUTED HARNESS TO CLEAR SEAT RIVETS. TESTED SEAT FORWARD AND BACK TO VERIFIED CHAFFING CONCERN IS NO LONGER PRESENT. THE SERVICE WRITER ALSO CHECKED WITH FORD REGARDING THE FUEL PUMP AND ENGINE SYSTEMS ACTIVATING WHEN THE DRIVER'S DOOR IS OPENED AND WHEN THE KEY IS INSERTED IN THE IGNITION. THE SERVICE WRITER TOLD ME THAT HE WAS TOLD THAT THIS IS NORMAL FOR THE 2020 TRANSIT AND CANNOT BE CHANGED. THIS SHOULD BE CONFIRMED SINCE THIS BEHAVIOR ADDS ADDITIONAL WEAR/TEAR TO THE ENGINE SYSTEMS AND COULD BE A POTENTIAL FIRE HAZARD.

NHTSA ODI #11310965

506 miles · Jan 26, 2020

Electrical SystemSeats

Read full complaint

NOTICED THAT A PUMP (FUEL???) WAS CYCLING ON WHEN DRIVER DOOR WAS OPENED AND WHEN KEY WAS INSERTED IN IGNITION. PARKING LIGHTS ALSO TURN ON WHEN DOOR IS OPENED. THE PUMP HAS ALSO CYCLED ON FOR NO APPARENT REASON AFTER ENGINE HAS BEEN TURNED OFF. CHECKED BATTERY WHICH IS LOCATED UNDER DRIVER SEAT AND FOUND THAT ELECTRICAL CABLES THAT LEAD TO SEAT HAVE BEEN DAMAGED BY RIVETS HOLDING SWIVEL SEAT WHEN THE SEAT IS MOVED FORWARD AND BACK. CAREFULLY MOVED THE SEAT BACK GUIDING THE CABLE BUNDLE UNDER THE RIVETS. THE PUMP NOW DOES NOT TURN ON WHEN THE DOOR IS OPENED BUT STILL CYCLES WHEN THE IGNITION KEY IS INSERTED. HAVE MOVED THE TRANSIT OUT OF THE GARAGE DUE TO POTENTIAL FIRE HAZARD. PHOTOS OF WIRE CABLE ARE INCLUDED. TRANSIT WAS JUST PURCHASED ON 1/20/2020 AND THE SWIVEL SEATS ARE NEW FOR THE 2020 MODEL.

NHTSA ODI #11302124

Official recalls

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V499000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Jul 19, 2023

Quality Vans (Quality Vans) is recalling certain 2020-2023 Ford Transit vans equipped with Onan QG 2800i EVAP generators, part number 2.8HGLAA-8303A. The fuel hose between the inline fuel filter and the Injection Pump Module (IPM) may not be properly secured, which can cause a gas leak.

Consequence & remedy

Consequence: A gasoline leak in the presence of an ignition source may increase the risk of fire.

Remedy: Dealers will inspect and replace the fuel hose and clamps as necessary, free of charge. Owner notification letters were mailed August 4, 2023. Owners may contact Quality Vans customer service at 1-480-464-7007.

21V978000 · Power Train:driveline:driveshaft

Dec 16, 2021

Ford Motor Company (Ford) is recalling certain 2020 Transit vehicles equipped with All Wheel Drive (AWD). The bolts that attach the rear driveshaft to the transfer case may become loose or damaged, which can result in separation of the driveshaft from the transfer case.

Consequence & remedy

Consequence: Driveshaft separation can result in a loss of drive power, or unintended movement while parked if the parking brake is not engaged, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the driveshaft bolts. If any loose bolts are found, the driveshaft, attachment hardware, transfer case flange kit, and seal will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S54.

21V631000 · Parking Brake:conventional:mechanical:linkage And Cable

Aug 11, 2021

Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.

Consequence & remedy

Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.

Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V415000 · Air Bags:side/window

Jul 17, 2020

Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.

Consequence & remedy

Consequence: In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.

Remedy: Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.

20V250000 · Seat Belts:front:retractor

May 5, 2020

National Van Builders, Inc. (National Van Builders) is recalling certain vehicles based on 2019-2020 Ford Transit and 2019 Ram Promaster vans equipped with Freedman GO-ES foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: National Van Builders will notify owners, and dealers will replace the retractors, free of charge. The recall began May 19, 2020. Owners may contact Freedman customer service at 1-800-443-4540 or National Van Builders customer service at 1-800-527-7477.

20V222000 · Seat Belts:front:retractor

Apr 20, 2020

TransitWorks is recalling certain Driverge vehicles based on 2019-2020 Ford Transit vans equipped with Freedman Seating Company (FSC) PT Foldaway and GO-ES 3-point Foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: TransitWorks will notify owners, and dealers will replace the retractors, free of charge. The recall began May 13, 2020. Dealers can contact Freedman Seating Company for parts and reimbursement information at 1-800-443-4540.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.