Illustration2017 FORESTER 239ITS. CONSUMER WRITES IN REGARDS TO SAFETY RECALL 16V-336. CONSUMER STATED THAT PARTS WERE UNAVAILABLE TO PERFORM RECALL RELATED REPAIRS.
2016 Ford Transit
Owner reports · Recalls · Investigations
More warning signs than most Transit years
Owner complaints for the 2016 Ford Transit are substantially higher than the model-year median of 37.
About this comparison →How this year compares
Owner complaints by model year
Compare all Transit years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
1325–50K
1450–75K
1175–100K
21100–150K
13150K+
96 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports4 fire reports6 injury reports
Unknown Or Other complaints
23 reportsI was notified for a **recall** on the DRIVE SHAFT sometime early this year ( Feb / March 2021)... I have about 24,000 miles on the van. I also reported humming noise after reaching 35 to 40 mph... and then more noise ( humming noise ) after reaching 65 mph on the expressway. I took my van to Northgate Ford, where I purchased …
Read full complaint
I was notified for a **recall** on the DRIVE SHAFT sometime early this year ( Feb / March 2021)... I have about 24,000 miles on the van. I also reported humming noise after reaching 35 to 40 mph... and then more noise ( humming noise ) after reaching 65 mph on the expressway. I took my van to Northgate Ford, where I purchased new. They said they had the parts ordered etc. I left the van there for several days...Then I was notified that they put on the new replacement driveshaft,,,, assuming it was correct and BALANCED.... the service manager notified me that the replacement driveshaft installed was NOT BALANCED and was causing all kinds of vibration problems / issues... steering wheel, driving, etc.... upon taking the van back several times.... and getting a new corrected balance driveshaft, installed that. However,,, still more problems,,, humming and vibrations, etc. they looked at the DIFFERRENCIAL ,,,, and found that all the bearings were bad,,, had to wait 4 to 6 weeks to get replacements......I told them that anything that SPINS... and not balanced is causing more vibration problems through out the van,,, engine, transmission, exhaust system, brakes, name it,,, etc. I picked up the van on June 28, 2021.. note... they gave me an extended warranty until 2024 ( 3 years ) and milage of 75,000 miles... Looks like expecting more major problems, etc..... I still have the **humming noise over 35 mph... and getting louder... I have seen articles about possible exhaust / muffler baffles going bad, etc... now that they did the recall, etc.. my van is an accident waiting to happen... and with the humming noise... Now all I need to do is lose my hearing... bull ssssss... thanks
Engine dies without warning. Stalled in the middle of traffic, luckily this did not result in an accident. This has happened twice in the span of one month. April 25th 2021 and May 14th 2021. Ford dealer (Ford of Montebello) could not figure out why it does this (it has been doing this intermittently since the vehicle was purcha…
Read full complaint
Engine dies without warning. Stalled in the middle of traffic, luckily this did not result in an accident. This has happened twice in the span of one month. April 25th 2021 and May 14th 2021. Ford dealer (Ford of Montebello) could not figure out why it does this (it has been doing this intermittently since the vehicle was purchased new in 2016. It has done this in the past. I am taking the vehicle back to dealer (again) to see if they can figure it out this time around. Scan tool produces no engine fault codes. Vehicle drives perfectly fine after each incident.
SYNC 3 SYSTEM FREEZE AND DOES NOT LET YOU UP DATE. THE GPS FREEZE , PHONE CALL ARE DROP, BLUETOOTH DO NOT CONNECT AND SOME TIME WHEN IS CONNECTED DISCONNECT CASE.
WHILE DRIVING AT SPEED, IN TRAFFIC ON I95 IN FLORIDA THE VEHICLE SHUT OFF. IT DID START AGAIN.NO DASH LIGHTS NO WARNING JUST TURNED OFF.
THE OVERALL NOISE LEVEL WHILE DRIVING IS WAY ABOVE NORMAL. HUMMING SOUND WHILE DRIVING AT 40 TO 50 MPH PLUS. THE **DECIBEL** LEVEL IS HIGH. NOISE COMING THROUGH ALL THE DOORS AND DOOR SEALS, THE FLOOR, ETC., NOISE FROM THE TIRES. I MEASURED THE DECIBEL LEVELS ON THE LOCAL EXPRESSWAY DOING 65 TO 70 MPH. THE DECIBEL LEVEL AT …
Read full complaint
THE OVERALL NOISE LEVEL WHILE DRIVING IS WAY ABOVE NORMAL. HUMMING SOUND WHILE DRIVING AT 40 TO 50 MPH PLUS. THE **DECIBEL** LEVEL IS HIGH. NOISE COMING THROUGH ALL THE DOORS AND DOOR SEALS, THE FLOOR, ETC., NOISE FROM THE TIRES. I MEASURED THE DECIBEL LEVELS ON THE LOCAL EXPRESSWAY DOING 65 TO 70 MPH. THE DECIBEL LEVEL AT THE *DOG HOUSE* WAS RUNNING BETWEEN 75 AND 80 DECIBELS. I HAVE BEEN TRYING TO PUT ADDITIONAL SELF STICKING DOOR SEALS ON ALL DOORS, 100% AROUND, COMPLETE, ETC. THIS HAS BEEN HAPPENING FOR THE PAST SEVERAL YEARS. SHORTLY AFTER I BOUGHT THE VEHICLE.
I WAS DRIVING ON THE INTERSTATE, GOING NORMAL SPEEDS, PRESSED ON THE GAS PEDAL TO GET AROUND A SEMI AND MY ACCELERATOR PEDAL SNAPPED. THE PLASTIC ARM THAT ATTACHES IT TO THE INNER PART IS ALL PLASTIC AND THE VAN IS ONLY 3 YRS OLD AND ONLY 70K MILES. LUCKILY I WAS ABLE TO GET OVER TO THE SIDE OF THE INTERSTATE BUT NOW MY VEHICLE …
Read full complaint
I WAS DRIVING ON THE INTERSTATE, GOING NORMAL SPEEDS, PRESSED ON THE GAS PEDAL TO GET AROUND A SEMI AND MY ACCELERATOR PEDAL SNAPPED. THE PLASTIC ARM THAT ATTACHES IT TO THE INNER PART IS ALL PLASTIC AND THE VAN IS ONLY 3 YRS OLD AND ONLY 70K MILES. LUCKILY I WAS ABLE TO GET OVER TO THE SIDE OF THE INTERSTATE BUT NOW MY VEHICLE IS STRANDED WITH NO WAY TO GET IT HOME. *DT *BF *JB
HYDRAULIC JACK RAM BROKE AND COLLAPSED DUE TO NUT BEING LEFT LOOSE AT MANUFACTURING. VEHICLE WAS STATIONARY. REPLACEMENT JACK HAS SAME ISSUE OF LOOSE NUT
THE WINDSHIELD ON THE TOP SIDE IS LOOSE. WHEN CLOSE THE DOOR THE AIR PRESSURE PUSHES THE WINDSHIELD OUT. WATER ALSO LEAKS INTO THE VEHICLE AS WELL.
ELECTRICAL THROTTLE BODY FAILED DURING DRIVING. LOST ALL POWER.
Official recalls
2125V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
21V631000 · Parking Brake:conventional:mechanical:linkage And Cable
Aug 11, 2021
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence & remedy
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
19V767000 · Power Train:driveline:driveshaft
Oct 25, 2019
Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V-408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V-408.
19V333000 · Seats
Apr 29, 2019
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1-800-443-4540 or New England at 1-800-886-9247.
19V329000 · Seats
Apr 26, 2019
Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014.
19V313000 · Seats
Apr 18, 2019
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
19V271000 · Equipment Adaptive/mobility
Apr 3, 2019
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.
19V247000 · Seats
Mar 28, 2019
Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1-800-544-5587.
19V238000 · Seats
Mar 26, 2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
19V229000 · Seats
Mar 22, 2019
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
19V205000 · Seats
Mar 18, 2019
Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1-800-408-8550.
19V183000 · Equipment Adaptive/mobility
Mar 6, 2019
Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014. Fenton's number for this recall is RI61396.
19V332000 · Seats
Mar 1, 2019
Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2016-2018 Ram ProMaster and Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats. When the seat back cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Prime-Time Specialty Vehicles has notified owners, and Freedman dealers have inspected and repaired the foldaway seats, free of charge. The recall began November 16, 2018. Owners may contact Freedman customer service at 1-800-443-4540 or Prime-Time Specialty Vehicles at 1-574-293-9191.
19V103000 · Power Train:driveline:driveshaft; Power Train:driveline:universal Joint
Feb 21, 2019
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence & remedy
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Additional source detail variants (2)
Power Train:driveline:driveshaft
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Power Train:driveline:universal Joint
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
18V782000 · Seats
Nov 6, 2018
National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1-508-222-2272.
18V275000 · Electrical System:wiring
Apr 30, 2018
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Note: This is an expansion of recall 17V-668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
17V668000 · Electrical System:wiring
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S34.
17V408000 · Power Train:driveline:driveshaft
Jun 26, 2017
Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S15.
16V618000 · Engine And Engine Cooling:engine:diesel; Fuel System, Diesel
Aug 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence & remedy
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Additional source detail variants (2)
Fuel System, Diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Engine And Engine Cooling:engine:diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
16V188000 · Air Bags:side/window
Apr 4, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
Consequence & remedy
Consequence: A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S13.
16V111000 · Seat Belts: Rear/other:buckle Assembly
Feb 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
Consequence & remedy
Consequence: An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ18001 · Zipcar Rental Concerns
Opened Apr 2, 2018 · Closed Sep 25, 2024
Status: closed (inferred from source dates) · Power Train:driveline:driveshaft
NHTSA opened this audit query to determine whether Zipcar, Inc. (Zipcar) complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental car company not rent, lease, or sell a recalled vehicle until the safety defect or noncompliance is remedied. 49 U.S.C. § 30120(i). Based on NHTSA’s inquiry, including information provided by Zipcar, NHTSA asserted that, during 2017 and 2018, Zipcar rented certain unremedied recalled vehicles in violation of the Safety Act. In October 2023, NHTSA and Zipcar entered into a Consent Order in which Zipcar agreed to pay a total civil penalty of $300,000. The total civil penalty included a payment of $150,000 as a Non-Deferred Amount. Zipcar also agreed to a sum of $150,000 as an Abeyance Amount, to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order. The requirements of the Consent Order include performance obligations that relate to process improvements to Zipcar’s recall compliance procedures and its training materials. Zipcar agreed to conduct an audit of all Zipcar vehicles with an open recall within 150 days after the Effective Date of the Consent Order. Zipcar also agreed to quarterly meetings with NHTSA staff to discuss the progress of the performance obligations and issues or concerns from either party. This audit query investigation, AQ18001, is closed. Closure of this AQ has no bearing on the terms of the Consent Order, including Zipcar’s ongoing performance obligations or other legal obligations, and does not represent a determination by NHTSA about Zipcar’s performance under the Consent Order to date.