IllustrationOIL PUMP FAILURE. *AK
1996 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 36 of 233 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports4 fire reports9 injury reports
Engine And Engine Cooling complaints
65 reportsWHILE DRIVING CONSUMER NOTICED SMOKE COMING FROM UNDER HOOD, TOOK VEHICLE DEALER WHO FOUND MANIFOLD HAD CRACKED. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
TIMING CHAIN COVER GASKET REPLACED UNDER RECALL IN 2000 , SUPPOSE TO STOP COOLANT LEAK, BUT MECHANIC NOW REPORTS THE PROBLEM IS HEAD GASKET, COMMON TO FORD'S 3.8 V6. *AK
HEAD GASKET LEAKING - CAR JUST TURNED 4 - FORD REFUSES TO COVER UNDER RECALL. *AK
TSB 97M91, REPLACED ALREADY 11/14/98, LEFT MYSELF AND DAUGHTER STRANDED IN MIDDLE OF DESERT. MANUFACTURER REFUSES TO COVER COSTS OF LOSS. NO SAFETY DEFECT LISTED IN SUMMARY. *AK
VEHICLE IS A LEMON. ENGINE WAS LEAKING OIL AND MAKING NOISE. DEALERSHIP TOLD CONSUMER THAT THE CRANKSHAFT INSIDE HAD TO BE REPLACED. ALSO THE TIRES HAD TO BE CHANGED EVERY THREE MONTHS BECAUSE TREADS ON TIRES WORE OUT. *AK
ENGINE CHECK LIGHT ON, DEALER REPLACED MASS AIR FLOW SENSOR. RETURNED TO DEALER 4 TIMES FOR GAS MILEAGE DOWN 10-20%, LOW IDLE AND STALLS, POOR DRIVEABILITY - FORD AND DEALER STATE CAR IS NORMAL - ALL DATA FROM PURCHASE DATE AVAILABLE - CLEARLY SHOWS NEGATIVE CHANGE AT TIME OF PART REPLACEMENT
BOTH CYLINDER HEADS AND INTAKE MANIFOLD FAILED CAUSING COOLANT LIGHT TO COME ON AND OFF WHILE DRIVING. NLM
Official recalls
296V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
96V007000 · Equipment:appliance:air Conditioner
Jan 16, 1996
UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.
Consequence & remedy
Consequence: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.