NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
176 reportsClear category filter65,000 miles · Mar 20, 2012
Vehicle Speed Control
WHILE DRIVING, THE ACCELERATOR BECAME STUCK WHICH ALMOST CAUSED AN ACCIDENT. IT HAS OCCURRED NUMEROUS TIMES SINCE THE FIRST DATE PLUS IT HAS OCCURRED AT DIFFERENT SPEEDS. I HAVE BEEN ABLE TO DEAL WITH IT, BY PLACING THE AUTO IN NEUTRAL AND HITTING THE GAS PEDAL A FEW TIMES WHICH CAUSES THE RPM'S TO DECREASE TO NORMAL. I DON'T…
Read full complaint
WHILE DRIVING, THE ACCELERATOR BECAME STUCK WHICH ALMOST CAUSED AN ACCIDENT. IT HAS OCCURRED NUMEROUS TIMES SINCE THE FIRST DATE PLUS IT HAS OCCURRED AT DIFFERENT SPEEDS. I HAVE BEEN ABLE TO DEAL WITH IT, BY PLACING THE AUTO IN NEUTRAL AND HITTING THE GAS PEDAL A FEW TIMES WHICH CAUSES THE RPM'S TO DECREASE TO NORMAL. I DON'T KNOW WHICH AUTO COMPONENT IS CAUSING THIS PROBLEM, BUT I RECENTLY READ IN THE PAPER THAT IT MIGHT BE A FAULTY CRUISE CONTROL CABLE.
NHTSA ODI #10453062
Mileage unknown · Mar 20, 2012
Engine And Engine CoolingSeat BeltsVehicle Speed Control
2006 FORD TAURUS. CONSUMER STATES IDLE, ACCELERATION ISSUES AND PROBLEM WITH SEAT BELT *TGW THE CONSUMER STATED AFTER MANY REPAIRS, THE MECHANICS WERE NOT ABLE TO CONFIRM THE CAUSE OF THE PROBLEM. THE CONSUMER ALSO STATED THE SEAT BELT TENSIONERS LOCKED UP WHICH MADE THE SEAT BELTS INOPERABLE. *JB
NHTSA ODI #10453050
65,000 miles · Mar 19, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE INCREASED ACCELERATION AND PROCEEDED THROUGH AN INTERSECTION HAPHAZARDLY. THE VEHICLE EVENTUALLY REDUCED SPEED AFTER APPLYING THE BRAKE PEDAL FORCEFULLY NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLI…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE INCREASED ACCELERATION AND PROCEEDED THROUGH AN INTERSECTION HAPHAZARDLY. THE VEHICLE EVENTUALLY REDUCED SPEED AFTER APPLYING THE BRAKE PEDAL FORCEFULLY NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE FAILURE OCCURRED SEVERAL TIMES. ALSO, ON A SEPARATE OCCASION WHEN DRIVING WITH THE CRUISE CONTROL ACTIVATED, THE CRUISE CONTROL SUDDENLY BECAME INOPERATIVE. AFTER THE CRUISE CONTROL MALFUNCTION THE UNINTENDED ACCELERATION NO LONGER PERSISTED. THERE WAS CURRENTLY AN OPEN INVESTIGATION ASSOCIATED WITH NHTSA ACTION NUMBER PE12005 (VEHICLE SPEED CONTROL:CABLES). THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS 65,000. UPDATED 04/26/12*LJ UPDATED 04/30/12
NHTSA ODI #10452158
130,953 miles · Mar 18, 2012
Vehicle Speed Control
WHILE DRIVING ,THE GAS PEDAL STICKS, I TRY TO PUT ON THE BRAKES THE CAR JUST KEEPS GOING UNTIL I PRESS THE BRAKES HARD. I PRESS THE PEDAL REAL SHARP AND IT MAY IDLE DOWN. *TR
NHTSA ODI #10452095
34,000 miles · Mar 16, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WOULD INTERMITTENTLY BECOME STUCK WHILE DRIVING AT 30 MPH OR HIGHER. THE FAILURE OCCURRED OVER A PERIOD OF A YEAR AND A HALF. THERE WOULD BE A HIGH RATE OF ENGINE RPMS AND THE VEHICLE WOULD CONTINUE TO ACCELERATE WHEN THE BRAKES WERE APPLIED. …
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WOULD INTERMITTENTLY BECOME STUCK WHILE DRIVING AT 30 MPH OR HIGHER. THE FAILURE OCCURRED OVER A PERIOD OF A YEAR AND A HALF. THERE WOULD BE A HIGH RATE OF ENGINE RPMS AND THE VEHICLE WOULD CONTINUE TO ACCELERATE WHEN THE BRAKES WERE APPLIED. THE CONTACT HAD TO APPLY REPEATED PRESSURE TO THE BRAKE PEDAL TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 34,000.
NHTSA ODI #10451950
Mileage unknown · Mar 16, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN INCREASE IN THE ENGINE RPMS AND THE VEHICLE JERKED FORWARD. THE CONTACT ALSO STATED THAT THE ACCELERATOR PEDAL BECAME STUCK AND SHE HAD TO TAP THE PEDAL TO RELEASE IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT …
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN INCREASE IN THE ENGINE RPMS AND THE VEHICLE JERKED FORWARD. THE CONTACT ALSO STATED THAT THE ACCELERATOR PEDAL BECAME STUCK AND SHE HAD TO TAP THE PEDAL TO RELEASE IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THEY COULD NOT DUPLICATE OR DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. . UPDATED 04/26/12*LJ UPDATED 04/3012
NHTSA ODI #10451926
91,000 miles · Mar 15, 2012
Vehicle Speed Control
WHEN DRIVING, THE VEHICLE WOULD NOT DECELERATE WHEN PRESSURE WAS TAKEN OFF THE ACCELERATOR PEDAL. THIS TYPICALLY OCCURRED AROUND 55 MPH. IT FELT AS IF THE CRUISE CONTROL WAS ON, BUT IT WAS NOT. WHEN THE VEHICLE WOULD NOT DECELERATE ON ITS OWN, I WOULD APPLY THE BRAKE TO COME TO A COMPLETE STOP. WHEN I WOULD STOP, THE ENGINE …
Read full complaint
WHEN DRIVING, THE VEHICLE WOULD NOT DECELERATE WHEN PRESSURE WAS TAKEN OFF THE ACCELERATOR PEDAL. THIS TYPICALLY OCCURRED AROUND 55 MPH. IT FELT AS IF THE CRUISE CONTROL WAS ON, BUT IT WAS NOT. WHEN THE VEHICLE WOULD NOT DECELERATE ON ITS OWN, I WOULD APPLY THE BRAKE TO COME TO A COMPLETE STOP. WHEN I WOULD STOP, THE ENGINE WAS REMAIN AT APPROXIMATELY 2,000 RPMS. THIS PROBLEM WAS INTERMITTENTLY, BUT DID OCCUR APPROXIMATE 10 TIMES OVER THE COURSE OF A WEEK (UNTIL THE PROBLEM WAS CORRECTED AT A MECHANIC SHOP). FURTHERMORE, THE CRUISE CONTROL NO LONGER WORKED. A CERTIFIED MECHANIC FOUND THAT THE WIRE HAD BROKEN/DETACHED WITHIN THE CRUISE CONTROL/THROTTLE ASSEMBLY. THIS WIRE WAS THE REASON WHY THE CRUISE CONTROL NO LONGER WORKED AND WHY THE THROTTLE WAS GETTING "STUCK." THE ENTIRE CRUISE CONTROL ASSEMBLY HAD TO BE REPLACED. THIS FIXED THE PROBLEM. *TR
NHTSA ODI #10451853
77,285 miles · Mar 15, 2012
Vehicle Speed Control
MANY TIMES WHILE DRIVING ONLY (NOT PARKED WITH MOTOR RUNNING), THE ACCELERATOR BECOMES STUCK/JAMMED AND MUST BE TAPPED SEVERAL TIMES TO UNSTICK WHAT SEEMS TO BE A GHOST-DRIVEN PEDAL. THE VEHICLE WILL SOMETIMES UNSTICK WHILE MOVING, BUT I HAVE BEEN SCARED TO THE POINT OF STOPPING THE VEHICLE SINCE IT WON'T UNSTICK AND PUT IT INTO…
Read full complaint
MANY TIMES WHILE DRIVING ONLY (NOT PARKED WITH MOTOR RUNNING), THE ACCELERATOR BECOMES STUCK/JAMMED AND MUST BE TAPPED SEVERAL TIMES TO UNSTICK WHAT SEEMS TO BE A GHOST-DRIVEN PEDAL. THE VEHICLE WILL SOMETIMES UNSTICK WHILE MOVING, BUT I HAVE BEEN SCARED TO THE POINT OF STOPPING THE VEHICLE SINCE IT WON'T UNSTICK AND PUT IT INTO PARK AND HIT THE GAS AGAIN. THIS DOES UNSTICK THE GAS PEDAL. *TR
NHTSA ODI #10451764
126,981 miles · Mar 14, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE CONTINUED TO ACCELERATE, ALTHOUGH THE ACCELERATOR PEDAL WAS NOT DEPRESSED. THE CONTACT STATED THAT HE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE BY SHIFTING TO NEUTRAL AND ENGAGING THE BRAKES. THE VEHICLE WAS TAKEN TO A DEALER, WH…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE CONTINUED TO ACCELERATE, ALTHOUGH THE ACCELERATOR PEDAL WAS NOT DEPRESSED. THE CONTACT STATED THAT HE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE BY SHIFTING TO NEUTRAL AND ENGAGING THE BRAKES. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE THROTTLE CABLE WAS FRACTURED AND THE THROTTLE BODY AND CABLE ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 126,981 AND THE CURRENT MILEAGE WAS 150,000. ..UPDATED 04/16/12 *BF ACCORDING TO THE REPAIR INVOICE, THE CABLE WAS BROKEN. THE DEALER REPLACED THE CABLE AND THROTTLE BODY. UPDATED 05/17/12
NHTSA ODI #10451689
80,000 miles · Mar 14, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ACCELERATOR PEDAL BECAME JAMMED AND CAUSED THE VEHICLE TO ABNORMALLY ACCELERATE. THE CONTACT ATTEMPTED TO DECELERATE BUT THE VEHICLE WOULD NOT STOP. THE CONTACT HAD TO SHIFT INTO NEUTRAL AND RESTART THE VEHICLE. ONCE STARTED,…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ACCELERATOR PEDAL BECAME JAMMED AND CAUSED THE VEHICLE TO ABNORMALLY ACCELERATE. THE CONTACT ATTEMPTED TO DECELERATE BUT THE VEHICLE WOULD NOT STOP. THE CONTACT HAD TO SHIFT INTO NEUTRAL AND RESTART THE VEHICLE. ONCE STARTED, THE ENGINE WOULD RACE AND THE RPM'S WOULD INCREASE EXCESSIVELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED THE CONTACT THAT THE CRUISE CONTROL CABLE NEEDED TO BE DISCONNECTED. THE VEHICLE WAS DISCONNECTED REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10451604
NHTSA investigations
1PE12005 · Stuck Throttle
Opened Mar 7, 2012 · Closed Oct 22, 2012
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables
Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do
Additional source detail variants (2)
Vehicle Speed Control:cables
Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do
Vehicle Speed Control
Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do
Illustration