IllustrationAT TIMES WHEN DRIVING CAR IN STREET CAR WILL AUTOMATICALLY DRIVE UP TO 50 MPH ON ITS OWN WITH YOUR FOOT OFF GAS PEDAL. AND WHEN YOU USE BRAKES TO STOP U CAN FEEL THE CAR STILL STRAINING TO ACCELERATE AND GO .
2004 Ford Taurus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Ford Taurus do not stand out strongly from the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
2225–50K
5550–75K
5975–100K
103100–150K
42150K+
315 reports with mileage · 60 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports13 fire reports19 injury reports
Unknown Or Other complaints
14 reportsTHE BRAKES ARE DANGEROUS AND THE WARNING LIGHTS STAY ON ALL THE TIME. THE UNDERCARRIAGE IS MESSED UP, I'VE HAD TO REPLACE SEVERAL FRONT TIRES DUE TO UNBALANCING ISSUES AND POPPING NOISES WHEN DRIVING STRAIGHT AND ON EVEN ROADS THAT HAVE GOTTEN WORSE. I HAD A BAD HEAD ON WRECK AND THE AIRBAGS DID NOT DEPLOY. I'M CONCERNED THEY WI…
Read full complaint
THE BRAKES ARE DANGEROUS AND THE WARNING LIGHTS STAY ON ALL THE TIME. THE UNDERCARRIAGE IS MESSED UP, I'VE HAD TO REPLACE SEVERAL FRONT TIRES DUE TO UNBALANCING ISSUES AND POPPING NOISES WHEN DRIVING STRAIGHT AND ON EVEN ROADS THAT HAVE GOTTEN WORSE. I HAD A BAD HEAD ON WRECK AND THE AIRBAGS DID NOT DEPLOY. I'M CONCERNED THEY WILL DEPLOY AT ANY MOMENT.
ENTERED CARD IN THE MORNING AND THE FLOOR BOARD WAS INEXPLICABLY SOAKED. AFTER STARTING THE CAR, THE HEAT WAS WOULD ONLY WORK WHEN THE BLOWER WAS SET ON HIGH, THE FIRST THREE SETTINGS DIDN'T TURN ON AT ALL.
AFTER EXITING THE HIGHWAY, BRAKING TO STOP A RED LIGHT, THE CAR PROCEEDED TO SLOWLY ACCELERATE ON ITS OWN. AFTER LETTING IT GO FOR A WHILE, IT TOPPED OUT AROUND 52MPH, AS IF THE CRUISE CONTROL WAS WORKING ON ITS OWN. I KEPT PRESSING OFF, BUT THAT WOULDN'T WORK. THE CAR STOPPED REVVING RPMS WHEN I PUT IT IN NEUTRAL.
TAKATA POWER STEERING PUMP , IN MOTION WE KEEP REPLACING POWER STEERING OIL ,IT'S NOT LEAKING UT BUT CAN'T EVEN STEER THE CAR SO IT'S PARKED.
WHEN DOOR CLOSED TEST LIGHT WITH MILEAGE WON'T SHOW???
ON AUGUST 5TH, WHILE DRIVING NORTH ON HWY 378 THE CAR STARTING SLOWING DOWN AS IF TO STOP, THEN IT COMPLETELY SHUT OFF. WE WERE DRIVING ABOUT 30 MPH AT THE TIME. AFTER SHUTTING OFF I CONTINUE TO TRY AND GET IT TO FIRE UP BUT IT DIDN'T UNTIL 1HR. LATER. AFTER REACHING MY DESTINATION, I WAITED 3 HRS. TO CRANK BUT, I COULDN'T. I'…
Read full complaint
ON AUGUST 5TH, WHILE DRIVING NORTH ON HWY 378 THE CAR STARTING SLOWING DOWN AS IF TO STOP, THEN IT COMPLETELY SHUT OFF. WE WERE DRIVING ABOUT 30 MPH AT THE TIME. AFTER SHUTTING OFF I CONTINUE TO TRY AND GET IT TO FIRE UP BUT IT DIDN'T UNTIL 1HR. LATER. AFTER REACHING MY DESTINATION, I WAITED 3 HRS. TO CRANK BUT, I COULDN'T. I'VE REPLACED NEW FUEL PUMP ASSEMBLY AND GAS TANK, ALONG WITH A NEW FILTER. I DID ALL THIS AND THE CAR STILL WON'T RUN. FRUSTRATED, PLEASE HELP!!!!!
MY 2004 FORD TAURUS ACCELERATED ON ITS OWN QUITE A FEW TIMES. AFTER GOGGLING THE PROBLEM I SAW THAT THERE HAD BEEN A RECALL. I CALLED FORD & WAS TOLD MY CAR WASN'T INCLUDED IN THE RECALL. THEY ALSO TOLD ME TO GET IT FIXED BECAUSE IT COULD BE DANGEROUS. I KNOW THAT BECAUSE I WAS ALMOST IN A FEW ACCIDENTS BECAUSE OF THE SUDDEN ACC…
Read full complaint
MY 2004 FORD TAURUS ACCELERATED ON ITS OWN QUITE A FEW TIMES. AFTER GOGGLING THE PROBLEM I SAW THAT THERE HAD BEEN A RECALL. I CALLED FORD & WAS TOLD MY CAR WASN'T INCLUDED IN THE RECALL. THEY ALSO TOLD ME TO GET IT FIXED BECAUSE IT COULD BE DANGEROUS. I KNOW THAT BECAUSE I WAS ALMOST IN A FEW ACCIDENTS BECAUSE OF THE SUDDEN ACCELERATION. I'D HAVE TO PULL OVER, IF NOT AT A RED LIGHT OR STOP SIGN, PUT THE CAR IN PARK & HIT THE ACCELERATOR A FEW TIMES. I ACTUALLY HAD TO TURN THE CAR OFF & BACK ON ONCE TO GET THE RPMS DOWN. I HAD THE CRUISE CONTROL CABLE TOTALLY REMOVED. THE CRUISE HADN'T WORKED IN YRS. MY MOM OWNED THE CAR BEFORE I DID. I'D LIKE TO KNOW WHY MY TAURUS WASN'T IN THE RECALL. *TR
THE CAR JUMPS WHEN STOPPED AT A LIGHT. YOU HAVE TO LEAVE PLENTY OF ROOM BETWEEN CARS OR IT WILL JUMP INTO A CAR. ALSO, WE HAVE HAD TO REPLACE THE ALTERNATOR AND BATTERY SEVERAL TIMES. THE ALTERNATOR WAS 3 TIMES AND THE BATTERY 5 TIMES. ALL OF THE SUDDEN OUT CRUISE CONTROL WENT OUT AND AFTER THAT IS WHEN THE JUMPING STARTED. H…
Read full complaint
THE CAR JUMPS WHEN STOPPED AT A LIGHT. YOU HAVE TO LEAVE PLENTY OF ROOM BETWEEN CARS OR IT WILL JUMP INTO A CAR. ALSO, WE HAVE HAD TO REPLACE THE ALTERNATOR AND BATTERY SEVERAL TIMES. THE ALTERNATOR WAS 3 TIMES AND THE BATTERY 5 TIMES. ALL OF THE SUDDEN OUT CRUISE CONTROL WENT OUT AND AFTER THAT IS WHEN THE JUMPING STARTED. HARD TO START AND IT JUMPS WHILE IDLING IN PARK AS WELL AS ALL OTHER GEARS. TRANSMISSION REPLACE 4 YEARS AGO. *JS
ON 12.02.2012, I WAS STOPPED AT AN INTERSECTION; AT A RED LIGHT; THE LANE TO THE ENTRANCE TO THE FREEWAY; AT THAT MOMENT AND TIME I DID ACTIVATE THE REAR WINDOW DEFOGGER ELECTRICAL PUSH BUTTON SWITCH FOR THE VEHICLE REAR WINDOW. AS SOON AS THE SIGNAL LIGHT WAS GREEN; WITHIN APPROXIMATELY LESS THAN TWO MINUTES, I DROVE OFF AND EN…
Read full complaint
ON 12.02.2012, I WAS STOPPED AT AN INTERSECTION; AT A RED LIGHT; THE LANE TO THE ENTRANCE TO THE FREEWAY; AT THAT MOMENT AND TIME I DID ACTIVATE THE REAR WINDOW DEFOGGER ELECTRICAL PUSH BUTTON SWITCH FOR THE VEHICLE REAR WINDOW. AS SOON AS THE SIGNAL LIGHT WAS GREEN; WITHIN APPROXIMATELY LESS THAN TWO MINUTES, I DROVE OFF AND ENTERED THE FREEWAY; UPON ENTERING THE FREEWAY AND IN THE SLOW LANE, I TURNED OFF THE REAR WINDOW DEFOGGER; IN APPROXIMATELY LESS THAN TWO OR THREE MINUTES WHILE IN MOTION/DRIVING; THERE WAS A LOUD BANG!. THE LOUD BANG, WAS A SOUND LIKE SOMETHING EXPLODED; I LOOKED INTO MY REARVIEW MIRROR AND SAW THAT I COULD BARELY MAKE OUT WHAT WAS BEHIND ME/TRAFFIC. I PULLED OFF THE FREEWAY AND FOUND THAT MY REAR WINDOW HAD SHATTERED/WAS BROKEN UP/CRACKED INTO PIECES, THE WINDOW DIDN'T COME APART; STAYED INTACT. THE REAR WINDOW DEFOGGER SYSTEM ELECTRICAL CONNECTION @ THE REAR WINDOW ON THE PASSENGER SIDE; THE CONNECTOR PLASTIC HOUSING WAS MELTED, BUT STAYED CONNECTED/INTACT. THE DRIVER SIDE ELECTRICAL CONNECTOR DETACHED/CAME OFF THE REAR WINDOW; THE CONNECTOR PLASTIC HOUSING WAS COMPLETELY MELTED.
Official recalls
104V330000 · Seats:front Assembly:power Adjust
Jul 8, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER ADJUSTABLE SEATS MAY HAVE BEEN INADEQUATELY WELDED.
Consequence & remedy
Consequence: THE SEAT MAY NOT PERFORM AS INTENDED DURING A CRASH WHICH COULD INCREASE THE RISK OF INJURY.
Remedy: DEALERS WILL REPLACE THE UPPER SUPPORT ASSEMBLY ON THE POWER SEATS. THE RECALL BEGAN ON JULY 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE12005 · Stuck Throttle
Opened Mar 7, 2012 · Closed Oct 22, 2012
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables
Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do
Additional source detail variants (2)
Vehicle Speed Control:cables
Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do
Vehicle Speed Control
Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do
DP06005 · Engine Stalling Ffv
Opened Dec 4, 2006 · Closed Dec 28, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:auxillary Tank; Fuel System, Gasoline:storage:auxillary Tank:selector Devices; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Gasoline:storage:tank Assembly:mounting; Fuel System, Other; Fuel System, Other:delivery; Fuel System, Other:delivery:fuel Pump; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System; Fuel System, Other:storage; Fuel System, Other:storage:fuel Gauge System; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging; Fuel System, Other:storage:tank Assembly:mounting; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Additional source detail variants (23)
Fuel System, Gasoline:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:injectors
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank:selector Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:fuel Gauge System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:filling/charging
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.