IllustrationA WATER LEAK WHICH DUMPED WATER ONTO THE PASSENGER FLOOR BOARD ALSO CAUSED MY AC BLOWER MOTOR TO SHORT OUT. I AM NOT SURE IF THIS IS RELATED TO RECALL 03V087000 BUT I KNOW IT IS THE SAME PROBLEM AS COMPLAINT #10184014. *TR
2003 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 2003 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
740–25K
14925–50K
25250–75K
25375–100K
261100–150K
70150K+
1,059 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 316 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 313 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
56 crash reports12 fire reports45 injury reports
What owners actually said
1,223 reportsTL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT WHEN SHIFTING INTO DRIVE AND DEPRESSING THE ACCELERATOR, THE VEHICLE WOULD LUNGE FORWARD VIOLENTLY. HE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPAIRED THE FAILURE, BUT THE DEFECT RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT FURTHER REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT WHEN SHIFTING INTO DRIVE AND DEPRESSING THE ACCELERATOR, THE VEHICLE WOULD LUNGE FORWARD VIOLENTLY. HE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPAIRED THE FAILURE, BUT THE DEFECT RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 64,000 AND THE CURRENT MILEAGE WAS 76,000. THE VIN WAS UNAVAILABLE.
A WATER LEAK, POSSIBLY FROM A FAULTY SEAL, ONTO THE PASSENGER INTERIOR FLOOR BOARD ALSO CAUSED MY AC/HEATER BLOWER MOTOR TO SHORT OUT. MY HEATER SWITCH WILL ONLY WORK IN THE MAXIMUM POSITION. FROM WHAT I HAVE READ IT IS DUE TO A HEATER MOTOR RESISTOR, WHICH HAS CAUSED SIMILAR PROBLEMS FOR OTHER TAURUS OWNERS. I COULD NOT GET FOR…
Read full complaint
A WATER LEAK, POSSIBLY FROM A FAULTY SEAL, ONTO THE PASSENGER INTERIOR FLOOR BOARD ALSO CAUSED MY AC/HEATER BLOWER MOTOR TO SHORT OUT. MY HEATER SWITCH WILL ONLY WORK IN THE MAXIMUM POSITION. FROM WHAT I HAVE READ IT IS DUE TO A HEATER MOTOR RESISTOR, WHICH HAS CAUSED SIMILAR PROBLEMS FOR OTHER TAURUS OWNERS. I COULD NOT GET FORD TO ACT EVEN THOUGH A RELATED RECALL EXISTED UNDER 03V087000. *TR
MY 2003 FORD TAURUS HAS 39,464. I GOT IN IT TO GO TO WORK, STARTED IT, PUT IT IN REVERSE AND CAR WOULD NOT MOVE. I TRIED DRIVE AND NOTHING. I HAVE BEEN DOING RESEARCH ON THIS PROBLEM, AND FIND THIS ISSUE IS VERY COMMON IN THE 03 TAURUS, AND OTHER FORD VEHICLES WITH THIS TRANSMISSION. I WAS LUCKY ENOUGH NOT TO BE DRIVING WHEN THI…
Read full complaint
MY 2003 FORD TAURUS HAS 39,464. I GOT IN IT TO GO TO WORK, STARTED IT, PUT IT IN REVERSE AND CAR WOULD NOT MOVE. I TRIED DRIVE AND NOTHING. I HAVE BEEN DOING RESEARCH ON THIS PROBLEM, AND FIND THIS ISSUE IS VERY COMMON IN THE 03 TAURUS, AND OTHER FORD VEHICLES WITH THIS TRANSMISSION. I WAS LUCKY ENOUGH NOT TO BE DRIVING WHEN THIS HAPPENED, AS A LOT OF THE PEOPLE I HAVE READ ABOUT. THE PROBLEM BEING A DEFECTIVE TORQUE CONVERTER. I UNDERSTAND THAT YOU OPENED AN INVESTIGATION IN JULY OF 2009, WITH APRROX. 3000 REPORTS OF THIS PART FAILING. FORD NEEDS TO HAVE A RECALL ON THESE PARTS, BEFORE SOMEONE IS KILLED. THIS IS MY FIRST STEP IN COMPLAINING ABOUT THIS MATTER, BUT IT IS NOT MY LAST. *TR
I WAS DRIVING ON A MAJOR HIGHWAY WITH MY CHILDREN AND ALL OF A SUDDEN MY CAR'S TRANSMISSION LIGHT CAME ON, MY CAR STARTED BUCKING, AND SOON LOST POWER AND I WAS FORCED TO PUT MY CAR IN PARK IN HEAVY TRAFFIC AND RESTART IT. *KB
AT APPROXIMATELY 126000 MILES FIRST OF TWO COIL SPRINGS BROKE IN THE FRONT DRIVER'S SIDE OF THE CAR. HAD BOTH FRONT COIL SPRINGS REPLACED. THREE WEEKS LATER WAS BACKING OUT OF PARKING SPACE AT WORK ONLY TO HAVE THE TRANSMISSION PUMP FAIL. CAR ACTED EXACTLY AS DESCRIBED IN MANY OTHER COMPLAINTS HERE, SUDDEN LOSS OF POWER, HIGH E…
Read full complaint
AT APPROXIMATELY 126000 MILES FIRST OF TWO COIL SPRINGS BROKE IN THE FRONT DRIVER'S SIDE OF THE CAR. HAD BOTH FRONT COIL SPRINGS REPLACED. THREE WEEKS LATER WAS BACKING OUT OF PARKING SPACE AT WORK ONLY TO HAVE THE TRANSMISSION PUMP FAIL. CAR ACTED EXACTLY AS DESCRIBED IN MANY OTHER COMPLAINTS HERE, SUDDEN LOSS OF POWER, HIGH ENGINE REV AND AN INABILITY OF THE CAR TO WORK IN ANY GEAR. HAD THE CAR TOWED TO MY MECHANIC AND WAS THEN TOLD THAT NOT ONLY DID THE TRANSMISSION NEED TO BE REBUILT BUT I ALSO HAD A REAR COIL SPRING THAT NOW WAS BROKEN. HAVE PURCHASED MANY FORD VEHICLES BUT THIS IS ENOUGH TO MAKE YOU LOOK AT A DIFFERENT MANUFACTURER. *TR
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING WATER UNDER THE FRONT PASSENGER SEAT. THE CONTACT WAS UNAWARE OF WHERE THE WATER WAS COMING FROM. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR A LOCAL MECHANIC. THE CONTACT BELIEVED THAT THE AIR CONDITIONER BLOWER RESISTER MALFU…
Read full complaint
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING WATER UNDER THE FRONT PASSENGER SEAT. THE CONTACT WAS UNAWARE OF WHERE THE WATER WAS COMING FROM. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR A LOCAL MECHANIC. THE CONTACT BELIEVED THAT THE AIR CONDITIONER BLOWER RESISTER MALFUNCTIONED AND CAUSED THE WATER LEAK. THE CONTACT VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 106,349.
I OWN A 2003 FORD TAURUS WITH 85,172 MILES ON IT. ON A RECENT TRIP OUT OF TOWN, THE TRANSMISSION WENT OUT WITH NO WARNING,AND WE HAD TO BE TOWED HOME OVER 100 MILES. AFTER SOME RESEARCH ,I HAVE FOUND THAT MANY OWNERS OF 2003 FORD TAURUS' HAVE HAD THE SAME PROBLEM WITH NO WARNING OF THE TRANSMISSION GOING OUT. IT APPEARS TO BE …
Read full complaint
I OWN A 2003 FORD TAURUS WITH 85,172 MILES ON IT. ON A RECENT TRIP OUT OF TOWN, THE TRANSMISSION WENT OUT WITH NO WARNING,AND WE HAD TO BE TOWED HOME OVER 100 MILES. AFTER SOME RESEARCH ,I HAVE FOUND THAT MANY OWNERS OF 2003 FORD TAURUS' HAVE HAD THE SAME PROBLEM WITH NO WARNING OF THE TRANSMISSION GOING OUT. IT APPEARS TO BE AN INTERNAL PROBLEM IN THE TRANSMISSION ITSELF. I FOUND 164 COMPLAINTS ON THE CAR COMPLAINTS/FORD WEBSITE CONCERNING THIS TRANSMISSION PROBLEM. IT COST ME OVER $3600 TO HAVE THE TRANSMISSION REPLACED. THAT IS OVER HALF WHAT THE BLUE BOOK VALUE IS ON MY CAR! I WANT TO KNOW IF FORD HAS LOOKED INTO THIS PROBLEM ON THE TRANSMISSIONS? WITH THAT MANY 2003 FORD TAURUS TRANSMISSIONS GOING OUT, SEEMS TO ME THERE SHOULD BE AN INVESTIGATION OR A RECALL ON THEM. I WOULD APPRECIATE SOMEONE CHECKING INTO THIS PROBLEM. I REALLY LOVE MY TAURUS, BUT AM VERY UPSET THAT THE TRANSMISSION WENT OUT ON A CAR THAT HAS BEEN TAKEN CARE OF BY FORD DEALERSHIPS FOR EVERYTHING FROM OIL CHANGES TO BRAKES, AIR CONDITIONER, ETC. ALWAYS HAD THE SERVICE DONE AT THE INTERVALS THAT FORD MOTOR COMPANY DETERMINED NEEDED TO BE DONE. THE FORD DEALERSHIP IS THE ONLY ONES THAT HAVE DONE ANY SERVICE ON MY CAR OTHER THAN TIRES.I FEEL THAT I HAVE DONE EVERYTHING TO KEEP MY CAR IN PERFECT CONDITION AND AM TERRIBLY DISAPPOINTED THAT THIS PROBLEM HAPPENED. PLEASE WOULD YOU CHECK INTO THIS PROBLEM AND SEE IF THERE SHOULD BE A RECALL ON THESE TRANSMISSIONS?? THIS IS A SAFETY ISSUE TO ME! IF THE CAR HAD STOPPED WHILE WE WERE DRIVING 70 MPH ON THE FREEWAY, IT COULD HAVE BEEN DEADLY TO US AND OTHERS! THANK YOU! *TR
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT WAS DRIVING 5 MPH, WHEN THE FRONT DRIVER SIDE TIRE BLEW. THE VEHICLE WAS STOPPED AND THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE COIL SPRING WAS FRACTURED AND HAD PIERCED THE TIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE COIL SPRING WAS REPAIRED. THE MANU…
Read full complaint
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT WAS DRIVING 5 MPH, WHEN THE FRONT DRIVER SIDE TIRE BLEW. THE VEHICLE WAS STOPPED AND THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE COIL SPRING WAS FRACTURED AND HAD PIERCED THE TIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE COIL SPRING WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 68,250.
POWER WINDOWS WILL NOT ROLL UP OR DOWN, MIRRORS DO NOT WORK, INSIDE LIGHTS ARE OUT. FORD REPLACED GEM MODULE A COUPLE OF YEARS BEFORE FOR THE SAME PROBLEM COSTING ME MONEY AT THAT TIME. WHEN THE WINDOWS WOULD NOT ROLL UP OR DOWN, FORD WOULD REPLACE FUSE AND IN A FEW MINUTES THE FUSE WOULD BLOW, AGAIN AND AGAIN THEY DID THIS AN…
Read full complaint
POWER WINDOWS WILL NOT ROLL UP OR DOWN, MIRRORS DO NOT WORK, INSIDE LIGHTS ARE OUT. FORD REPLACED GEM MODULE A COUPLE OF YEARS BEFORE FOR THE SAME PROBLEM COSTING ME MONEY AT THAT TIME. WHEN THE WINDOWS WOULD NOT ROLL UP OR DOWN, FORD WOULD REPLACE FUSE AND IN A FEW MINUTES THE FUSE WOULD BLOW, AGAIN AND AGAIN THEY DID THIS AND NOW THEY ARE NOT INTERESTED IN FIXING THE PROBLEMS SINCE THE VEHICLE IS OLDER AND NOT UNDER WARRANTY AND THEY CLAIM FIXING IT WOULD COST MORE THAN THE VEHICLE IS WORTH. I HAVE A VERY GOOD VEHICLE AND WOULD LIKE TO USE THE WINDOWS AND MIRRORS AND ESPECIALLY THE LIGHTS INSIDE AND I FEEL THIS IS DEFINITELY A SAFETY HAZARD TO ME SINCE I TRAVEL ALONE A LOT EACH YEAR. I HAVE CONTACTED FORD AND THEY REPEATLY STATE THAT THEY DO NOT HAVE ANY RECALLS AND ARE NOT AWARE OF SUCH PROBLEMS. I EVEN SENT THEM WEBSITES FROM PEOPLE WHO ARE HAVING THESE PROBLEMS WITH THE WINDOWS. ALL YOU HAVE TO DO IS GOGGLE: TAURUS WINDOW PROBLEMS AND THERE ARE NUMEROUS OWNERS WITH THIS PROBLEM. HOPE YOU CAN HELP WITH THIS MATTER AS FORD IS NOT LISTENING TO US..... *TT
Official recalls
304V105000 · Engine And Engine Cooling
Mar 2, 2004
ON CERTAIN VEHICLES, THE AIR FILTER PAPER IN THESE VEHICLES CAN SMOLDER OR BURN.
Consequence & remedy
Consequence: THIS CAN LEAD TO DAMAGE TO THE AIR INDUCTION SYSTEM ON THESE VEHICLES AND/OR AN UNDERHOOD FIRE.
Remedy: DEALERS WILL REPLACE THE AIR FILTER ELEMENT. OWNER NOTIFICATION BEGAN ON MARCH 10, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
04V106000 · Exterior Lighting:brake Lights:switch
Mar 2, 2004
CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.
Consequence & remedy
Consequence: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.
Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
03V087000 · Visibility:windshield
Mar 10, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." THE WINDSHIELDS MAY POTENTIALLY EXHIBIT INCREASED WIND NOISE, WATER LEAKAGE, AND SQUEAKS AND RATTLES.
Consequence & remedy
Consequence: POTENTIAL LOSS OF WINDSHIELD RETENTION MAY ALSO REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE WINDSHIELDS. OWNER NOTIFICATION BEGAN ON MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD/MERCURY AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE12033 · Speed Control Cable Damage
Opened Oct 24, 2012 · Closed Jun 26, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Additional source detail variants (3)
Vehicle Speed Control:cables
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
EA08018 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Jun 30, 2011
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front suspension coil spring fractures. ODI is also aware of four minor crashes related to the alleged defect resulting in one minor injury.With greater than eight years of exposure, a large subject vehicle population and approximately 2,052 reported front tire punctures caused by fractured coil springs (at all speeds), there have been no reported severe crashes, deaths or injuries related to the alleged defect. The real world consequences of these defective coil springs have been a small number of minor control problems that resulted in minor damage; suggesting that the effect of the defect on vehicle control is minor.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor this issue and will take further action if warranted by the circumstances. See the EA08-018 Engineering Analysis Closing Report for more details.
DP06005 · Engine Stalling Ffv
Opened Dec 4, 2006 · Closed Dec 28, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:auxillary Tank; Fuel System, Gasoline:storage:auxillary Tank:selector Devices; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Gasoline:storage:tank Assembly:mounting; Fuel System, Other; Fuel System, Other:delivery; Fuel System, Other:delivery:fuel Pump; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System; Fuel System, Other:storage; Fuel System, Other:storage:fuel Gauge System; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging; Fuel System, Other:storage:tank Assembly:mounting; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Additional source detail variants (23)
Fuel System, Gasoline:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:injectors
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank:selector Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:fuel Gauge System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:filling/charging
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
RQ03008 · Brake Light Switch Failure
Opened Oct 23, 2003 · Closed Mar 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Additional source detail variants (5)
Exterior Lighting:brake Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:brake Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.