Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 93 of 825 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 214 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
69 crash reports12 fire reports45 injury reports
What owners actually said
825 reports
Mileage unknown · Oct 6, 2004
Air BagsCrash
WHEN THE CONSUMER APPLIED THE BRAKES, THE PEDAL WENT TO THE FLOOR. THE CONSUMER COLLIDED WITH ANOTHER DRIVER. BOTH FRONTAL AIR BAGS DID DEPLOY, BUT THE AIR BAGS DEPLOYED IN THE UPRIGHT POSITION AND HIT THE WINDSHIELD AND CAUSED THE WINDSHIELD TO SHATTER. THE VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. PLEASE F…
Read full complaint
WHEN THE CONSUMER APPLIED THE BRAKES, THE PEDAL WENT TO THE FLOOR. THE CONSUMER COLLIDED WITH ANOTHER DRIVER. BOTH FRONTAL AIR BAGS DID DEPLOY, BUT THE AIR BAGS DEPLOYED IN THE UPRIGHT POSITION AND HIT THE WINDSHIELD AND CAUSED THE WINDSHIELD TO SHATTER. THE VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10092342
75,000 miles · Oct 6, 2004
Exterior Lighting
CONSUMER STATED HEADLIGHT LENSES PRODUCED A THICK FILM. AS A RESULT, THE OF THE VISIBILITY OF THE DRIVER BECOMES IMPAIRED. DEALER STATED THAT IT WAS NORMAL PROCEDURE. *AK HEAD LIGHT LENS ARE NO LONGER CLEAR. *TC
NHTSA ODI #10090169
Mileage unknown · Sep 10, 2004
Electrical SystemFuel System, Gasoline
WHILE DRIVING 45 MPH VEHICLE STALLED. VEHICLE WAS TAKEN TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL PUMP AND FUSE NEEDED TO BE REPLACED, AND REPLACED IT. HOWEVER, THE PROBLEM RECURRED, AND MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10091819
175,000 miles · Aug 31, 2004
Suspension
WHILE REVERSING CONSUMER FOUND A PIECE OF THE BROKEN COIL SPRING ON THE GROUND OF THE GARAGE. THE DRIVER SIDE COIL SPRING BROKE AND THE COIL PUNCTURED THE FRONT DRIVER SIDE TIRE. RECALL 04V332000 WAS ISSUED BUT THIS VEHICLE WAS NOT INVOLVED IN THE RECALL DUE TO VIN. *AK *NM
NHTSA ODI #10083561
24,000 miles · Aug 9, 2004
Service Brakes, Hydraulic
STEERING WHEEL AND AUTOMOBILE WOBBLES WHEN APPLYING BRAKES. *AK
NHTSA ODI #10086474
Mileage unknown · Aug 5, 2004
Suspension
WHILE DRIVING AT 30 MPH,CONSUMER HEARD A LOUD NOISE COMING FROM WHEEL ON PASSENGER'S SIDE, AND SUDDENLY CONSUMER LOST CONTROL OF VEHICLE. CONSUMER DROVE IMMEDIATELY TO THE SHOULDERS. CONSUMER WENT UNDERNEATH OF THE VEHICLE AND SAW THAT COIL SPRING ON THE PASSENGER'S SIDE BROKE. *AK
NHTSA ODI #10087244
92,000 miles · Aug 2, 2004
Vehicle Speed Control
WHILE DRIVING OUT OF A TOW BOOTH VEHICLE SUDDENLY ACCELERATED AND LURCHED AT HIGH SPEED. CONSUMER WAS ABLE TO GAIN CONTROL, AND PULLED THE VEHICLE OVER. DEALER WAS NOTIFIED, BUT WAS UNABLE TO FIND THE CAUSE OF THE PROBLEM. *AK
NHTSA ODI #10084040
185,724 miles · Jul 27, 2004
Power Train
THE CONSUMER COMPLAINED ABOUT TRANSMISSION FAILURE. WHILE DRIVING, THE TRANSMISSION SUDDENLY MALFUNCTIONED. IT WAS CALLED SUDDEN TRANSMISSION FAILURE OF CLUTCH PLATES WHICH CAUSED THE PARK PIN PLATE NOT TO STAY IN POSITION. THE CONSUMER WAS TOLD BY THE MANUFACTURER AND DEALER THAT THE PIN DID NOT STAY ENGAGED IN THE PARK POSIT…
Read full complaint
THE CONSUMER COMPLAINED ABOUT TRANSMISSION FAILURE. WHILE DRIVING, THE TRANSMISSION SUDDENLY MALFUNCTIONED. IT WAS CALLED SUDDEN TRANSMISSION FAILURE OF CLUTCH PLATES WHICH CAUSED THE PARK PIN PLATE NOT TO STAY IN POSITION. THE CONSUMER WAS TOLD BY THE MANUFACTURER AND DEALER THAT THE PIN DID NOT STAY ENGAGED IN THE PARK POSITION. HE WAS TOLD BY DEALER THAT FORD WAS AWARE OF THIS PROBLEM AND THERE WAS A RECALL ON THIS PROBLEM, BUT BECAUSE HE LIVED IN CANADA HE NEVER RECEIVED THR RECALL NOTICE. THE CONSUMER PURCHASED THE VEHICLE IN CANADA. THE CONSUMER SPENT ABOUT $5000-6000 IN REPAIRS ON SOMETHING THAT WAS RECALLED AND NO ONE WANTED TO HELP HIM BECAUSE OF WHERE HE LIVED. *AK *SC *JB
NHTSA ODI #10076013
Mileage unknown · Jul 20, 2004
Fuel System, Gasoline
THE CONSUMER STATED THE VEHICLE CUT OFF WHEN SHE MADE A STOP. SHE ALSO STATED THAT SOMETIMES THE VEHICLE WAS HARD TO RE-START. THE VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS AND WAS TOLD THAT EVENTUALLY THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. *JB
NHTSA ODI #10083337
Mileage unknown · Jul 14, 2004
Steering
WHILE DRIVING IN RAINY CONDITIONS BATTERY INDICATOR LIGHT FLASHED ON, AND STEERING WHEEL LOCKED IN PLACE. CONSUMER WOULD HAVE TO APPLY BRAKES TO COME TO A STOP, AND SIT FOR A FEW SECONDS WITHOUT ANY INDICATION THAT STEERING WHEEL WOULD UNLOCK. *AK THIS PROBLEM OCCURS MOST TIMES WHEN IT RAINS AND THE VEHICLE GOES THROUGH WAT…
Read full complaint
WHILE DRIVING IN RAINY CONDITIONS BATTERY INDICATOR LIGHT FLASHED ON, AND STEERING WHEEL LOCKED IN PLACE. CONSUMER WOULD HAVE TO APPLY BRAKES TO COME TO A STOP, AND SIT FOR A FEW SECONDS WITHOUT ANY INDICATION THAT STEERING WHEEL WOULD UNLOCK. *AK THIS PROBLEM OCCURS MOST TIMES WHEN IT RAINS AND THE VEHICLE GOES THROUGH WATER. *NM
VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.
Consequence & remedy
Consequence: IF THIS SHIPPING PLUG IS DISPLACED, FUEL LEAKAGE CAN RESULT. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE CORRECT FUEL TANK.
THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL WITH THE SHIFT LEVER IN THE PARK POSITION.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.
Consequence & remedy
Consequence: UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT CAN RESULT IN PERSONAL INJURY AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.
THE FUEL PRESSURE REGULATOR LOCATED ON THE FUEL RAIL IN THE ENGINE COMPARTMENT HAS A VACUUM DIAPHRAGM THAT WAS DAMAGED DURING MANUFACTURE OF THE REGULATOR.
Consequence & remedy
Consequence: IF THE DIAPHRAGM TEARS OR RUPTURES, LIQUID FUEL COULD ENTER THE INTAKE MANIFOLD PLENUM THROUGH THE VACUUM LINE RESULTING IN EITHER RELEASE OF FUEL FROM THE AIR CLEANER ASSEMBLY OR THE EXHAUST SYSTEM. FUEL RELEASE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PRESSURE REGULATOR. THOSE REGULATORS PRODUCED DURING THE SUSPECT TIME PERIOD WILL BE REPLACED.
THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PARK PAWL OCCASIONALLY NOT ENGAGING WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE PARK POSITION. THIS COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.
THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SWITCH MALFUNTIONS, THE BRAKE SYSTEM WARNING LAMP WILL EITHER REMAIN ILLUMINATED CONTINUOUSLY OR FAIL TO LIGHT AS INTENDED WHEN THE FLUID LEVEL FALLS TO A CERTAIN LEVEL. IN EITHER CASE, THE VEHICLE OPERATOR WOULD NOT BE WARNED OF A LOW BRAKE FLUID LEVEL CONDITION.
Remedy: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 Ford Taurus Problems, Complaints & Recalls | Skip That Year
Illustration