SOME QUESTIONS, I WAS NOT SURE ABOUT SUCH AS THE DRIVETRAIN, ETC. IN MOST CASES I SAID I DID NOT NOTIFY THE MANUFACTURER, BUT, DID NOTIFY THE DEALER. MOST OF THE COMPLAINTS REGARD MANUF. DEFECTS & MAY NOT BE SAFETY-RELATED EXCEPT FOR THE 1 ABOUT THE PARK PAWL RECALL #96S51; IN THIS CASE, I HAD DONE SEARCH OF RECALLS ON MY CAR M…
Read full complaint
SOME QUESTIONS, I WAS NOT SURE ABOUT SUCH AS THE DRIVETRAIN, ETC. IN MOST CASES I SAID I DID NOT NOTIFY THE MANUFACTURER, BUT, DID NOTIFY THE DEALER. MOST OF THE COMPLAINTS REGARD MANUF. DEFECTS & MAY NOT BE SAFETY-RELATED EXCEPT FOR THE 1 ABOUT THE PARK PAWL RECALL #96S51; IN THIS CASE, I HAD DONE SEARCH OF RECALLS ON MY CAR MAKE & MODEL THRU CERTAIN INTERNET WEB PAGES & FOUND THERE WERE 5-6 RECALLS ON MY VEHICLE. I CALLED FORD CUST. SVC. & GAVE MY VIN # TO FIND OUT WHICH ONES APPLIED TO MY CAR. I FOUND 2 OF THEM APPLIED TO MY VIN #. I SUSPECT THAT FORD IS NOT NOTIFYING ME OF THESE RECALLS. ONE RECALL--NOT SAFETY RELATED, #98B23, I FOUND OUT ABOUT FROM A SVC. MGR. @ A DEALERSHIP. WHEN I CALLED FORD CST. SVC. & TOLD THEM I HADN'T BEEN NOTIFIED, REP SAID THEY HAD SENT THE LETTER 2 WEEKS PRIOR. WHEN I ASKED FOR A COPY OF THE RECALL LTR, I GOT A BIG RUN-AROUND ABOUT HOW FMC COULD NOT SEND ME A DUPE LETTER SINCE THERE WAS STILL 1 FLOATING AROUND IN THE U.S.P.S.(EVEN THOUGH THE LTR WAS SPECIFIC TO MY VIN #). I FINALLY RAISED ENOUGH "CAIN" TO GET THEM TO SEND ME THE LTR, BUT, IT WAS 2 LATE, MY CAR WAS ALREADY EFFECTED BY THE "HEATING & COOLING" RECALL. THE NEXT RECALL, #96S51, WHICH IS SAFETY-RELATED;I WAS NOT NOTIFIED OF; FORD CST. SVC. SAID THIS RECALL SVC. HAD BEEN PERFORMED AT BOOMERSHINE FORD IN DULUTH, GA ON 3/15/97. WHEN I TOLD THEM THIS WAS NOT POSSIBLE SINCE I WAS NOT NOTIFIED OF THE RECALL, CS SAID POSSIBLY I HAD TAKEN THE CAR IN FOR ANOTHER SVC. & IT WAS DISCOVERED BY THE SERVICE TECH THAT THERE WAS AN "OPEN RECALL" & THEY PERFORMED THE SVC. @ THAT TIME. I DO NOT HAVE RECORD OF THIS NOR DOES THE DEALER. IN ORDER FOR ME TO FIND OUT IF THE SVC WAS PERFORMED, IT WOULD BE @ MY EXPENSE. FORD CS TOLD ME TO HAVE THE DEALER TO CONTACT THE REGIONAL REP FOR THEM AND HAVE THE WORK AUTHORIZED, HOWEVER, NEITHER OF THEM ARE WILLING TO GIVE ME THE NAME OF THE REG. REP. I CONTACTED BOTH FORD CS AND THE SVC. MGR. @ THE DEALER. EACH LEAVES IT UP TO THE OTHER TO
NHTSA ODI #729734
Mileage unknown · Jul 17, 2000
Equipment
THE AIR CONDITIONER CLUTCH STOPPED CYCLING ON AND OFF, CONSTANTLY ON, CLUTCH WAS REPLACED BECAUSE THE BEARINGS BURNT OUT AND THE CLUTCH CEASED UP AND THEN BURNT THE SERPENTINE BELT. THE SYSTEM WORKED FOR A WEEK AND WENT OUT AGAIN AFTER THE CLUTCH AND THE AC CYCLING SWITCH WAS REPLACED, THE VEHICLE IS IN FOR THE THIRD REPLACEMENT…
Read full complaint
THE AIR CONDITIONER CLUTCH STOPPED CYCLING ON AND OFF, CONSTANTLY ON, CLUTCH WAS REPLACED BECAUSE THE BEARINGS BURNT OUT AND THE CLUTCH CEASED UP AND THEN BURNT THE SERPENTINE BELT. THE SYSTEM WORKED FOR A WEEK AND WENT OUT AGAIN AFTER THE CLUTCH AND THE AC CYCLING SWITCH WAS REPLACED, THE VEHICLE IS IN FOR THE THIRD REPLACEMENT, THE MECHANIC CAN NOT FIGURE OUT WHY THE SYSTEM IS FAILING. *MJS
NHTSA ODI #784746
Mileage unknown · Oct 19, 1999
Equipment
MY COMPRESSOR FOR MY AC IS NOT WORKING ANY MORE. I AM TRYING TO FIND OUT IF THIS IS A COMMON PROBLEM WITH MY MODEL OF CAR, AND IF THERE IS ANY WAY TO HAVE FORD COVER FOR THE REPAIR. MY CAR IS ONLY A 1996 WITH REASONABLE MILEAGE AND THE AC SHOULD NOT BREAK DOWN ALREADY. CAN YOU HELP ME? OR GUIDE ME TO SOMEONE WHO COULD?
NHTSA ODI #713541
Mileage unknown · Jun 24, 1999
EquipmentExterior LightingLatches/locks/linkages
CABLES THAT CONNECTS TO THE GAS PEDAL BROKE WHILE ACCELERATING ONTO THE HIGHWAY. NLM
NHTSA ODI #546378
Mileage unknown · Oct 2, 1998
Engine And Engine CoolingEquipmentFuel System, Gasoline
THE VEHICLE CONTINUES TO OVERHEAT; THE "HOT" NEEDLE ZOOMS TO "H" WITHOUT WARNING AND THE AIR CONDITIONER SPEWS OUT HOT AIR; UPON STOPPING, COOLANT ERUPTS FROMTHE RESERVE TANK AND SPILLS OUT IN VOLUME ONTO THE PAVEMENT AND THE CAR BECOMES UNDRIVEABLE.
NHTSA ODI #780649
Mileage unknown · Mar 3, 1998
EquipmentFuel System, Gasoline
VEHICLE CONTINUES TO EXPERIENCE HARD STARTING/NO STARTING DUE TO FAULTY INJECTION SYSTEM.
NHTSA ODI #531654
Mileage unknown · Dec 30, 1997
EquipmentPower TrainService Brakes, Hydraulic
DRIVE TRAIN SHIFTS ERRATICALLY.
NHTSA ODI #527233
Mileage unknown · Aug 15, 1997
EquipmentSteeringStructure
DOOR HINGE ON CONSOLE BROKEN AND AIR CONDITIONER MAKE LOUD HUMMING NOISE AT HIGHWAY SPEEDS. STEERING LOCKS UP AND CAUSE CANNOT BE DETERMINED.
NHTSA ODI #522652
Mileage unknown · Nov 8, 1996
Equipment
WHEN THE AIR CONDITIONER IS ON, THE PASSENGERS IN THE VEHICLE EXPERIENCE A BURNING OF THE NOSES AND EYES. THE DEALER INSTALLED A DEODORIZER TO CLEAN OUT THE SYSTEM. *AK
NHTSA ODI #804749
Mileage unknown · Aug 27, 1996
Equipment
THERE'S A SMELLY ODOR IN THE A/C UNIT OF THE CAR AND IT GIVES HIS WIFE HEADACHES. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.
Consequence & remedy
Consequence: IF THIS SHIPPING PLUG IS DISPLACED, FUEL LEAKAGE CAN RESULT. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE CORRECT FUEL TANK.
THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL WITH THE SHIFT LEVER IN THE PARK POSITION.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.
Consequence & remedy
Consequence: UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT CAN RESULT IN PERSONAL INJURY AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.
THE FUEL PRESSURE REGULATOR LOCATED ON THE FUEL RAIL IN THE ENGINE COMPARTMENT HAS A VACUUM DIAPHRAGM THAT WAS DAMAGED DURING MANUFACTURE OF THE REGULATOR.
Consequence & remedy
Consequence: IF THE DIAPHRAGM TEARS OR RUPTURES, LIQUID FUEL COULD ENTER THE INTAKE MANIFOLD PLENUM THROUGH THE VACUUM LINE RESULTING IN EITHER RELEASE OF FUEL FROM THE AIR CLEANER ASSEMBLY OR THE EXHAUST SYSTEM. FUEL RELEASE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PRESSURE REGULATOR. THOSE REGULATORS PRODUCED DURING THE SUSPECT TIME PERIOD WILL BE REPLACED.
THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PARK PAWL OCCASIONALLY NOT ENGAGING WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE PARK POSITION. THIS COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.
THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SWITCH MALFUNTIONS, THE BRAKE SYSTEM WARNING LAMP WILL EITHER REMAIN ILLUMINATED CONTINUOUSLY OR FAIL TO LIGHT AS INTENDED WHEN THE FLUID LEVEL FALLS TO A CERTAIN LEVEL. IN EITHER CASE, THE VEHICLE OPERATOR WOULD NOT BE WARNED OF A LOW BRAKE FLUID LEVEL CONDITION.
Remedy: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 Ford Taurus Problems, Complaints & Recalls | Skip That Year
Illustration