1996 Ford Taurus

HEADLIGHTS WOULD ONLY WORK SOME OF THE TIME. DEALER REPLACED DEFECTIVE HEADLIGHT SWITCH. THE ENGINE DEVELOPED A HIGH PITCHED SQUEAL, ALMOST LIKE A BELT SQUEAL. IT WAS DETERMINED THE CAM SYNCHRONIZER WAS DEFECTIVE. AT THAT TIME THE CAM POSITION SENSOR WAS ALSO FOUND TO BE DEFECTIVE. THE MAGNET WAS FALLING OUT. THE COOLANT OVERFLOW BOTTLE WAS DISCOLORED, LEAKING AND FULL OF CRACKS CAUSING ANTIFREEZE TO POUR OUT OF THE COOLING SYSTEM. FORD ACKNOWLEDGES THERE IS A BANK TO BANK COOLANT FLOW IMBALANCE ON SOME 1996 MODEL YEAR TAURUS LEADING TO CONTAMINATED/CORRODED COOLANT. RECALL 98B23 WAS PERFORMED. BUT THE DAMAGE WAS ALREADY DONE TO THE REST OF THE COOLING SYSTEM.

WE HAD PURCHASED OUR 1996 FORD TAURUS IN JULY OF 1999 WITH 30,000 ON THE ODOMETER [XXX]. NOT LONG AFTER THIS I HAD THE COOLING SYSTEM FLUSHED AND, AT ABOUT 40,000 MILES THE HEATER CORE GOES OUT. AT A COST OF $600 WE HAD IT REPLACED. SINCE THEN THE HEATER CORE HAS BEEN REPLACED 7 TIMES; THE LAST TIME BEING JANUARY 9, 2004 WITH 75,000 MILES ON THE ODOMETER. THE FIRST TIME THE HEATER CORE HAD BEEN REPLACED IT WAS DONE BY OUR LOCAL FORD DEALER AND WAS REPAIRED WITH A FORD PART. WE WERE TOLD THAT THE PART WOULD HAVE A 12 MONTH, 12,000 MILE WARRANTY, SO IF THE PART FAILS AGAIN IT WOULD BE COVERED BY FORD. THIS WAS A GOOD THING. THE PART ALWAYS FAILED BEFORE THE 12K MILES OR 12 MONTHS (NOTE: WE ALSO HAD THE RADIATOR REPLACED LAST SUMMER 2003 AT A COST OF $850). AFTER THIS LAST TIME IT WAS SUGGESTED BY THE DEALER THAT THEY WILL NO LONGER REPLACE IT, NOR WILL FORD. SINCE THIS CAR WAS MADE IT SEEMS, FROM WHAT I HAVE READ AND RESEARCHED THAT FORD HAD USED A DIFFERENT COOLANT WHICH AS CAUSED THESE PREMATURE FAILURES AND REFUSES TO DO ANYTHING ABOUT IT. FORD BLAMES IT ON ELECTROLYSIS; SAYING THAT IF THE COOLANT SYSTEM CONTAINS MORE THAN .4 VOLTS THAT IT CAN CAUSE PREMATURE FAILURE OF ANY PART OF THE COOLANT SYSTEM. I HAVE CHECKED THIS VOLTAGE EACH AND EVERY TIME BEFORE HAVING THE HEATER CORE REPLACED AND IT HAS ALWAYS BEEN BELOW .2 VOLTS. I DID NOT CHECK IT THIS TIME AND WAS TOLD BY THE DEALER THAT THEY MEASURED .7 VOLTS!? I PERSONALLY DO NOT BELIEVE THAT ELECTROLYSIS IS OR HAS EVER BEEN THE PROBLEM. FORD REFUSES TO DO ANY THING ABOUT THIS PROBLEM REGARDLESS OF THE CAUSE. IT WAS SUGGESTED THAT WE BUY ANOTHER CAR; THIS WAS NOT IN OUR PLANS BECAUSE THE CAR WILL BE PAID OFF IN JULY OF 2004; MY WIFE WAS LOOKING FORWARD TO NOT HAVING ANY MORE CAR PAYMENTS. SO MUCH FOR QUALITY IS JOB ONE! PLEASE NOTE: THE FORD DEALER HAS BEEN VERY HELPFUL IN TRYING TO RESOLVE THIS PROBLEM THANKS TO NO HELP FROM FORD.*AK UPDATED 07/30/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DEFECTIVE FREEZE PLUGS IN 1996 FORD 3.0 VULCAN ENGINE IN TAURUS SEDAN. ON TWO DIFFERENT OCCASIONS FREEZE PLUGS CORRODED THROUGH LETTING HOT ENGINE COOLANT SPILL ON TO MY HANDS CAUSING BURNS. THERE WAS A RECALL ISSUED BUT I WAS NEVER NOTIFIED AS THE CAR OWNER. COST OF REPAIR VEHICLE WAS OVER $500 THE ENGINE TRANSMISSION HAD TO BE REMOVED AND ALL FREEZE PLUGS WERE REPLACED. THIS COST SHOULD HAVE BEEN BORN BY FORD MOTOR CO. BUT WAS AN OUT OF POCKET EXPENSE FOR ME. *JB

TO WHOM IT MAY CONCERN. I BOUGHT A FORD TAURUS 1996 FROM VENUNS FORD IN MILWAUKEE WISCONSIN. I HAVE ONLY HAD THIS CAR FOR SEVEN MONTHS AND THE GAS PEDAL WAS STICKING AND TAKING OFF VERY FAST AND SHIFTING ITS GEARS. THE MOTOR WAS RUMBLING AND SHAKING. I HAD TO REPAIR THE AXLES OF THE CAR. I HAD TO TAKE IT BACK EVERY MONTH BECAUSE OF THE ENGINE. THE WATER PUMP OVER HEATED AND THE GAS PEDAL IS STILL STICKING AND TAKING OFF VERY FAST TODAY. ALSO THE DEALER IS TRYING TO TAKE AWAY THE WARRANTY SO THEY WOULDN'T HAVE TO PAY FOR THE REPAIRS. I ASKED THE DEALER TO TAKE A FEDERAL INVESTIGATION BUT THEY REFUSED. I ASKED FOR AN EVEN EXCHANGE FOR A DIFFERENT CAR BUT THEY WANTED ME TO PAY FOR THIS CAR AND THE OTHER IF I GOT ONE. URGENTLY RESPOND TO MY COMPLAINT. *JB

THE SERVICE ENGINE SOON LIGHT ON THE DASH OF MY 1996 FORD TAURUS HAS BEEN ON FOR SEVERAL MONTHS. AFTER MANY DIAGNOSTIC TESTS THE PROBLEM IS STILL NOT RESOLVED. THE OBD COMPUTER IN THE VEHICLE IS READING FOR 4 OXYGEN SENSORS WHEN THIS VEHICLE ONLY HAS 3 OXYGEN SENSORS. THIS RESULTED IN THE VEHICLE FAILING EMISSIONS TESTING FOR THE STATE OF GEORGIA. *NLM

MY 17-YEAR-OLD SON WAS DRIVING TO EDINBURG, TEXAS ON A PRETTY BUSY STREET, WHEN OUT OF THE BLUE THE ENGINE STARTED TO FAIL. HE NEARLY GOT KILLED. THANK GOD THAT DIDN'T HAPPEN. THE CAR CRACKED THE HEAD, AND IS IN NEED OF MAJOR REPAIR. THIS HAS HAPPENED THREE TIMES SINCE THE CAR WAS BOUGHT. ABOUT A MONTH BEFORE THE LAST INCIDENT, I NOTICED THAT THE COOLANT WATER WAS A BROWN, ALMOST MUDDY COLOR AND TEXTURE. I FIGURED IT WAS JUST LEFT OVER DAMAGE FROM THE ENGINE REPAIRS IT HAD RECEIVED. AFTER DOING A LOT OF RESEARCH I FOUND THAT FORD HAD A CUSTOMER SATISFACTION NOTICE PROGRAM FOR A "BROWN COOLANT RECALL." I NEVER GOT THE NOTICE AND MY WARRANTY EXPIRED A LONG TIME AGO. THIS IS CLEARLY A FULL OUT ''RECALL.'' I WOULD LIKE FOR THE NHTSA TO GET FORD TO PAY FOR THE DAMAGES THAT THEY HAVE CAUSED. MANY PEOPLE ALL OVER THE INTERNET HAVE HAD THE SAME PROBLEM. I AM CURRENTLY STILL PAYING FOR THE CAR AND IT IS NOT FAIR FOR FORD TO GET AWAY WITH THIS NON-SENSE. MY SON COULD HAVE DIED ALL BECAUSE FORD DIDN''T PROPERLY NOTIFY ME. I WILL CALL FORD TOMORROW AND EXPLAIN WHAT HAPPENED. IF THEY DON''T HELP, AND THE NHTSA DOESN''T HELP EITHER, I WILL HAVE NO CHOICE BUT TO SUE FORD. THIS IS TOTAL NONSENSE. I'M NOT TRYING TO STEAL THEIR MONEY, I JUST WANT FOR THEM TO PAY FOR THEIR OWN SCREW UP.

PREVIOUSLY TO THIS ON 1/99, RECALL 98B23 WAS COMPLETED DEALING WITH THE RUSTY, CORROSIVE COOLANT CONDITION WHICH DEVELOPS IN THE 1996 TAURUS. NOW THE COOLANT RESERVOIR HAS DEVELOPED NUMEROUS STRESS CRACKS CAUSING ANTIFREEZE TO POUR OUT. THIS CAR ONLY HAS 60,000 MILES ON IT. AFTER FURTHER INSPECTIOIN IT APPEARS THE RADIATOR HAS ALSO DEVELOPED A LEAK.