IllustrationWHILE SITTING AT AN INTERSECTION VEHICLE STALLED. CONSUMER TRIED TO RESTART AND IT MADE A HORRIBLE METAL CLINKING SOUND. CONSUMER DROVE CAR TO A MECHANIC, AND MECHANIC STATED THAT ENGINE NEEDED TO BE REPLACED. THERE WASA RECALL ON HEAD GASKET, BUT THIS VEHICLE WAS NOT INCLUDED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
1994 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1994 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 67 of 923 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 289 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports23 fire reports30 injury reports
What owners actually said
923 reportsNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHILE DRIVING AND WITHOUT WARNING VEHICLE WILL BEGIN TO STALL, RESULTING IN SHUT OFF. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED, AND CONFIRMED THERE WAS A RECALL ON FUEL SYSTEM. HOWEVER , RECALL WAS 2 YEARS OLD, AND IT WOULD NOT APPLY TO CONSUMER.*AK
GRADUALLY WHILE DRIVING OVER A TWO MONTH PERIOD, A PISTON IN TRANSMISSION CRACKED, RESULTING IN SYSTEM NOT ENGAGING AFTER DRIVING AND PARKING FOR TEN MINUTES OR MORE. WHEN DEPRESSING ACCELERATOR, VEHICLE WILL EITHER SLAM INTO GEAR/JERK DRIVER/OCCUPANTS OR WILL SLIP OUT OF GEAR WITH NO WARNING. *AK AFTER THE REPAIRS, CONSUMER WR…
Read full complaint
GRADUALLY WHILE DRIVING OVER A TWO MONTH PERIOD, A PISTON IN TRANSMISSION CRACKED, RESULTING IN SYSTEM NOT ENGAGING AFTER DRIVING AND PARKING FOR TEN MINUTES OR MORE. WHEN DEPRESSING ACCELERATOR, VEHICLE WILL EITHER SLAM INTO GEAR/JERK DRIVER/OCCUPANTS OR WILL SLIP OUT OF GEAR WITH NO WARNING. *AK AFTER THE REPAIRS, CONSUMER WROTE TO THE FORD COMPANY TO ADVISE OF THE FAILURE AND TO REQUEST RELIEF FROM PREMATURE FAILURE. FORD DENIED THE REQUEST. *JG
VEHICLE STARTED SHAKING AT 40 MPH. CONSUMER REPLACED SHARKS/ STRUTS, AND TIRES; BUT VEHICLE STILL SHAKES. DEALER STATED THERE WERE SEVERAL ENGINE MOUNTS BROKEN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
PLUG ON BACK OF HEADLIGHT SWITCH OVERHEATED, CAUSING THE SWITCH TO MALFUNCTION,RESULTING IN LOSS OF HEAD LIGHTS.*AK
PREMATURE WEAR OF ENGINE MOUNTS. ENGINE MOUNTS WERE REPLACED AT 44,000 MILES. DEALER WILL INSPECT AND REPAIR THEM. *AK AT 44747 MILES ON FEB 16 1998, WINDWARD FORD SERVICE WRITER INFORMED THE ORIGINAL OWNER THAT ENGINE MOUNT INSTALLED ON NEW VEHICLE WAS REDESIGNED AT TIME OF ASSEMBLY AT THE FACTORY. *JG
WHEN OPENING DRIVER'S DOOR INSTEAD OF STAYING OPEN IT WILL COME BACK AND HIT DRIVER'S LEG. THIS HAS HAPPENED NUMEROUS TIMES.*AK
THERE IS AN INTERMITTTNT FUEL SMELL INSIDE VEHICLE. DEALER HAS NOT EXAMINED VEHICLE. *AK
RIGHT REAR BRAKE LINE FAILED RESULTING IN COMPLETE LOSS OF BRAKES. TOWED TO GARAGE WHERE INSPECTIION SHOWED THEA LINE HAD RUSTED AND BURST. INSPECTION ALSO SHOWED SEVERE RUST ON BRAKE LINES FROM PROPORTIONING VALVE TO FRONT OF CAR . RUST IS IN AN AREA NOT EASILY OBSERVED BY NORMAL MAINTENACE INSPECTION AND COULD LEAD TO SUDDEN F…
Read full complaint
RIGHT REAR BRAKE LINE FAILED RESULTING IN COMPLETE LOSS OF BRAKES. TOWED TO GARAGE WHERE INSPECTIION SHOWED THEA LINE HAD RUSTED AND BURST. INSPECTION ALSO SHOWED SEVERE RUST ON BRAKE LINES FROM PROPORTIONING VALVE TO FRONT OF CAR . RUST IS IN AN AREA NOT EASILY OBSERVED BY NORMAL MAINTENACE INSPECTION AND COULD LEAD TO SUDDEN FAILURE OF BRAKE SYSTEM.*AK
Official recalls
498V323000 · Structure:frame And Members
Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
98V009000 · Exterior Lighting:headlights:switch
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
97V025000 · Vehicle Speed Control
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
97V019000 · Engine And Engine Cooling:cooling System:fan
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.