NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
140 reportsClear category filter77,000 miles · Aug 26, 2013
Exterior Lighting
TL* THE CONTACT OWNS A 1993 FORD TAURUS. THE CONTACT STATED WHILE DRIVING 70 MPH, THE HEADLIGHTS TURNED OFF SPORADICALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE HAD SURPASSED THE STATUE OF LIMITATIONS. THE VEHICLE WAS NOT REPAIRED…
Read full complaint
TL* THE CONTACT OWNS A 1993 FORD TAURUS. THE CONTACT STATED WHILE DRIVING 70 MPH, THE HEADLIGHTS TURNED OFF SPORADICALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE HAD SURPASSED THE STATUE OF LIMITATIONS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 77,000.
NHTSA ODI #10537234
160,000 miles · Nov 6, 2012
Exterior Lighting
HEADLIGHTS WENT OUT. FIDDLED DESPERATELY WITH THE ON/OFF SWITCH & GOT THEM TO COME BACK ON. WENT OUT SEVERAL TIMES OVER THE NEXT 30 MINUTES ... DISCOVERED TURNING OFF AND BACK ON FIXED. SUSPECTED IT HAD TO DO WITH THE HEAT. OVER THE TWO MONTH, RECURRED SEVERAL TIMES AFTER DRIVING FOR 30 MINUTES OR SO. ALSO FOUND THAT US…
Read full complaint
HEADLIGHTS WENT OUT. FIDDLED DESPERATELY WITH THE ON/OFF SWITCH & GOT THEM TO COME BACK ON. WENT OUT SEVERAL TIMES OVER THE NEXT 30 MINUTES ... DISCOVERED TURNING OFF AND BACK ON FIXED. SUSPECTED IT HAD TO DO WITH THE HEAT. OVER THE TWO MONTH, RECURRED SEVERAL TIMES AFTER DRIVING FOR 30 MINUTES OR SO. ALSO FOUND THAT USUALLY PRESSURE APPLIED TO THE SWITCH ITSELF AND JIGGLING WOULD BRING THEM BACK, AND DISCOVERED I COULD HOLD THE HIGH BEAMS ON. FINALLY SEARCHED HERE AND FOUND 98V009000, WHICH SEEMS TO BE THE SAME PROBLEM. HAVE CONTACTED THE LOCAL DEALER ... BUT GAVE THEM RECALL 98S01 (FOUND ELSEWHERE WHEN LOOKING FOR REPLACEMENT PART WHEN I HAD DECIDED THAT IT MOST LIKELY WAS IN THE SWITCH). *TR
NHTSA ODI #10483504
192,000 miles · Sep 24, 2007
Exterior Lighting
TL*THE CONTACT OWNS A 1993 FORD TAURUS. WHILE DRIVING 30 MPH, THE HEADLIGHTS FLICKERED RAPIDLY. THE FAILURE OCCURRED INTERMITTENTLY. THE DEALER STATED THAT THE HEADLIGHT SWITCH FAILED AND THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 98V009000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). NO REPAIRS WERE MADE. THE CURREN…
Read full complaint
TL*THE CONTACT OWNS A 1993 FORD TAURUS. WHILE DRIVING 30 MPH, THE HEADLIGHTS FLICKERED RAPIDLY. THE FAILURE OCCURRED INTERMITTENTLY. THE DEALER STATED THAT THE HEADLIGHT SWITCH FAILED AND THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 98V009000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE 192,000. *UPDATED 12/12/07 *BF UPDATED 12/12/07
NHTSA ODI #10204003
70,000 miles · Apr 26, 2007
Electrical SystemExterior Lighting
TL*THE CONTACT OWNS A 1993 FORD TAURUS. THE VEHICLE RECEIVEDE RECALL REGARDING THE CIRCUIT BREAKER OPENING. THE FAILURE CAUSED THE HEADLIGHTS TO DIM FOR SHORT PERIODS OF TIME. THE CONTACT'S VEHICLE HAD THE SAME FAILURE, BUT FORD STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE IS 130,000, AND FA…
Read full complaint
TL*THE CONTACT OWNS A 1993 FORD TAURUS. THE VEHICLE RECEIVEDE RECALL REGARDING THE CIRCUIT BREAKER OPENING. THE FAILURE CAUSED THE HEADLIGHTS TO DIM FOR SHORT PERIODS OF TIME. THE CONTACT'S VEHICLE HAD THE SAME FAILURE, BUT FORD STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE IS 130,000, AND FAILURE MILEAGE WAS 70,000.*AK
NHTSA ODI #10188946
54,000 miles · Feb 11, 2004
Exterior Lighting
HEADLIGHTS FLICKERED ON AND OFF. THIS MALFUNCTION OCCURRED INTERMITTENTLY EVERY TWENTY MINUTES. *AK
NHTSA ODI #10057930
120,000 miles · Feb 4, 2004
Exterior Lighting
NHTSA RECALL 98V009000 CONCERNING HEADLIGHT FAILURE. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS. THIS RECALL FAILED. *AK
NHTSA ODI #10057537
Mileage unknown · Jan 21, 2004
Exterior Lighting
THERE MAY BE A POTENTIAL DESIGN DEFECT IN THE LIGHT SWITCH IN THE CONSUMER'S 1993 FORD TAURUS. *PH THE PART WOULD BECOME SO HOT THAT IT WOULD MELT IN THE DASHBOARD, AS THE SWITCH STARTED TO GO BAD, THE LIGHTS WOULD GO OFF WHILE DRIVING. THE HEADLIGHT SWITCH WAS REPLACED FOR A THIRD TIME. THE CONSUMER REQUESTED REIMBURSEME…
Read full complaint
THERE MAY BE A POTENTIAL DESIGN DEFECT IN THE LIGHT SWITCH IN THE CONSUMER'S 1993 FORD TAURUS. *PH THE PART WOULD BECOME SO HOT THAT IT WOULD MELT IN THE DASHBOARD, AS THE SWITCH STARTED TO GO BAD, THE LIGHTS WOULD GO OFF WHILE DRIVING. THE HEADLIGHT SWITCH WAS REPLACED FOR A THIRD TIME. THE CONSUMER REQUESTED REIMBURSEMENT. *SC *JB
NHTSA ODI #10057321
100,000 miles · Nov 7, 2003
Exterior Lighting
VEHICLE EXPERIENCED THE SAME DEFECT WITH THE HEADLIGHT CIRCUIT BREAKER AS STATED IN NHTSA RECALL 98V009000. THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK
NHTSA ODI #10046529
Mileage unknown · Nov 7, 2003
Exterior Lighting
IMPROPER SEAL ON HEADLIGHTS LEADS TO A PREMATURE AND SIGNIFICANT LOSS OF NIGHTTIME VISIBILITY. I HAVE REPLACED BULBS BUT IT DOESN'T HELP. THE PROBLEM STARTED WHEN THE CAR WAS ABOUT 4 YEARS OLD AND HAS GOTTEN PROGRESSIVELY WORSE. THE HIGH COST OF PERIODICALLY REPLACING THE ENTIRE HEADLIGHT ASSEMBLY IS IMPRACTICAL AS THE CAR AGE…
Read full complaint
IMPROPER SEAL ON HEADLIGHTS LEADS TO A PREMATURE AND SIGNIFICANT LOSS OF NIGHTTIME VISIBILITY. I HAVE REPLACED BULBS BUT IT DOESN'T HELP. THE PROBLEM STARTED WHEN THE CAR WAS ABOUT 4 YEARS OLD AND HAS GOTTEN PROGRESSIVELY WORSE. THE HIGH COST OF PERIODICALLY REPLACING THE ENTIRE HEADLIGHT ASSEMBLY IS IMPRACTICAL AS THE CAR AGES. I HAVE CONFIRMED THIS PROBLEM WITH OTHER OWNERS. THE CAR HAS NOT BEEN IN ANY ACCIDENTS. IN MY OPINION, DRIVING THIS CAR AT NIGHT ENTAILS A HAZARD RELATED TO THE DESIGN OF THE HEADLIGHTS SO I AVOID DOING SO WHENEVER POSSIBLE, BUT I CAN'T ALWAYS DO SO. *LA
NHTSA ODI #10045636
Mileage unknown · Mar 28, 2003
Exterior Lighting
AFTER THE RECALL FOR THE HEADLIGHTS WAS PERFORMED, THE PROBLEM RECURRED. RECALL # 98 V 009 000 *JB
NHTSA ODI #10014654
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
May 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.
Consequence & remedy
Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Jan 4, 1993
ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.
Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99023 · Windshield Wiper
Opened Aug 6, 1999 · Closed Jun 12, 2001
Status: closed (inferred from source dates) · Visibility
ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.
PE99015 · Windshield Wiper
Opened Feb 24, 1999 · Closed Aug 6, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING
EA97026 · Front Suspension Coil Spring Failure
Opened Nov 26, 1997 · Closed May 13, 1998
Status: closed (inferred from source dates) · Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Additional source detail variants (2)
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
PE97035 · Front Suspension Coil Spring Failure
Opened Jul 22, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
PE96018 · Headlights Failure
Opened Mar 5, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Exterior Lighting:headlights
There is no summary currently available
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration