Engine And Engine Cooling. Review the 638 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

54 crash reports49 fire reports35 injury reports

Engine And Engine Cooling complaints

638 reports

Clear category filter

Mileage unknown · Feb 20, 2001

Engine And Engine Cooling

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ODI #741227

Mileage unknown · Feb 15, 2001

Engine And Engine Cooling

HEAD GASKET BLOWN AT 95,000 MILES. FORD REFUSED TO FIX, ALTHOUGH IT'S A KNOWN DEFECT.*AK

NHTSA ODI #740955

Mileage unknown · Feb 15, 2001

Engine And Engine Cooling

REPLACED HEAD GASKET, BOLTS AND THE SIDE COVER PLATE ON TIMING CHAIN BECAUSE OF LEAKING WATER. CJ

NHTSA ODI #559676

Mileage unknown · Feb 6, 2001

Engine And Engine Cooling

HEAD GASKETS BLEW WHEN I STARTED CAR IN GARAGE. I HAD CAR TOWED TO MY REGULAR REPAIRMAN. HE ADVISED ME THAT THE PROBLEM WAS NOT UNCOMMON WITH TAURUSES. I CONTACTED FORD MOTOR CO. FIVE TIMES BY PHONE AND SENT TWO LETTERS WITH NO POSITIVE RESPONSE ALTHOUGH MY RESEARCH INDICATED THEY WERE WELL AWARE OF THE PROBLEM. *AK

NHTSA ODI #740526

Mileage unknown · Feb 3, 2001

Engine And Engine Cooling

Read full complaint

I DON'T KNOW EXACTLY WHEN THE FAILURE OCCURRED. THERE WAS NOTHING DRAMATIC ABOUT IT. I SIMPLY NOTICED THE HEATER IN THE CAR WAS NO LONGER WORKING. WHEN I TOOK IT IN TO BE REPAIRED, APPROXIMATELY A WEEK OR TWO LATER, THE DEALER TOLD ME I HAD A BLOWN HEAD GASKET. THEY ESTIMATED IT WOULD COST "APPROX. $1400" TO REPAIR IT/THEM. THE WORK REQUEST DOESN'T SPECIFY WHETHER ONE OR BOTH WERE BLOWN, BUT IT DOES SPECIFY THAT BOTH WOULD BE REPLACED. FORD IS AWARE OF THIS MANUFACTURING DEFECT AND THAT IT HAS EXISTED SINCE 1988. HOWEVER, FORD HAS ONLY EXTENDED COVERAGE FOR THIS DEFECT TO CARS FROM 1994 ON. IT WAS ALMOST 1994 WHEN I BOUGHT MY CAR, BUT IT IS A 1993 MODEL, AND NOT COVERED, EVEN THOUGH THE PROBLEM IS IDENTICAL.*AK

NHTSA ODI #740396

Mileage unknown · Feb 2, 2001

Engine And Engine Cooling

ON TWO OCCASIONS THE VEHICLE STALLED WITHOUT WARNING, CONSUMER WAS ADVISED TO LET THE VEHICLE COOL OFF AND TO DRIVE WITHOUT THE A/C ON, CONSUMER DID THIS IN 103 DEGREE WEATHER, MECHANIC IS UNSURE WHAT THE PROBLEM IS. NLM

NHTSA ODI #559368

Mileage unknown · Jan 31, 2001

Engine And Engine CoolingVisibility

Read full complaint

I SUBMITTED INFORMATION TWO DAYS AGO. I DON'T KNOW IF IT WENT THROUGH OR NOT. IN CASE NOT, I STARTED HAVING HEATING PROBLEMS LAST YEAR AND AFTER REPLACING HEATING COMPONENTS,IE, RADIATOR, TWO THERMOSTATS, TWO HEATING SENSING UNITS, WATER PUMPAND HEAT GUAGE. IT KEPT RUNNING HOT TO THE POINT I WAS SCARED IT WOULD RUIN MY MOTOR. I NEVER RAN IT TO THE BOILING POINT. I FINALLY LEFT IT WITH MY MECHANIC AND AFTER MANY CHECK, HE FINALL FOUND FAULTY HEAD GASKETS WITH A GAS ANALIZER. I HAD THE GASKETS AND NECESSARY COMPONENTS REPLACED. IT IS NOW BACK TO NORMAL. I HAVE NOT HAD ANY MORE PROBLEMS. I WOULD JUST LIKE TO KNOW WHY MR. [XXX], MANAGER,VEHICLE SERVICE AND PROGRAMS, FORD CUSTOMER SERVICE DIVISION DETERMINED BY LETTER THAT ALL 94 AND 95 TAURUS'S WITH 3.8L ENGINES WOULD BE REPAIRED FREE BY THE FORD MOTOR CO.. IF HE WOULD CHECK THE INTERNET FOR 93 TAURUS ,WITH 3.8L ENGINES HAD THE SAME PROBLEM. HE SAID HE HOPED THIS PROGRAM WOULD CONFIRM YOUR CONTINUED SATISFACTION IN YOUR FORD-BUILT VEHICLE. THE LETTER ALSO STATED IF YOU REPAIRED YOUR VEHICLE PRIOR TO THIS LETTER, YOU WOULD RECEIVE A REFUND. I HAVE BEEN A FORD PERSON ALL MY LIFE. I HAVE TWO NOW. I WOULD LIKE TO BE TREATED FAIR. I APPRECIATE YOUR TIME AND PATIENCE FOR LETTING ME SUBMIT THIS COMPLAING. SINCERELY, [XXX] (PLEASE EXCUSE THE ERRORS).*AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #740241

Mileage unknown · Jan 29, 2001

Engine And Engine Cooling

VEHICLE HAD HEATING PROBLEM. CONSUMER REPLCAED NUMEROUS PARTS, BUT STILLTHE PROBLEM EXIST. HEAT ANALYZER MACHINE INDICATED FAULTY HEAD GASKET CAUSED THE HEATING PROBLEMS. *YH

NHTSA ODI #879262

Mileage unknown · Jan 29, 2001

Engine And Engine Cooling

VEHICLE EXPERIENCED HEATING PROBLEMS, HEAT WOULD FLUCTUATE BETWEEN HIGH NORMAL AND HOT, CONSUMER REPLACED RADIATOR AND THERMOSTAT, SOMETIME LATER PROBLEMS BEGAN AGAIN, THIS TIME REPLACING WATER PUMP, THERMOSTAT FOR THE SECOND TIME, HEAT SENSING UNIT, HEAT GAUGE, AND FAN BELT, AGAIN PROBLEMS CAME BACK AND THIS TIME MECHANIC FOUND…

Read full complaint

NHTSA ODI #879258

Mileage unknown · Jan 23, 2001

Engine And Engine Cooling

VEHICLE HAS BLOWN HEADGASKET.*AK

NHTSA ODI #878810

Official recalls

98V323000 · Structure:frame And Members

Dec 16, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence & remedy

Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.

98V094000 · Suspension:front:springs:coil Springs

May 6, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.

Consequence & remedy

Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.

98V009000 · Exterior Lighting:headlights:switch

Jan 21, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.

Consequence & remedy

Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.

97V025000 · Vehicle Speed Control

Feb 26, 1997

VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.

Consequence & remedy

Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.

97V019000 · Engine And Engine Cooling:cooling System:fan

Feb 25, 1997

THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.

93V023000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Jan 4, 1993

ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..

Consequence & remedy

Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.

Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ99017 · Front Suspension Spring

Opened Aug 9, 1999 · Closed Feb 16, 2000

Status: closed (inferred from source dates) · Suspension

There is no summary currently available

EA99023 · Windshield Wiper

Opened Aug 6, 1999 · Closed Jun 12, 2001

Status: closed (inferred from source dates) · Visibility

ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.

PE99015 · Windshield Wiper

Opened Feb 24, 1999 · Closed Aug 6, 1999

Status: closed (inferred from source dates) · Visibility

ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING

EA97026 · Front Suspension Coil Spring Failure

Opened Nov 26, 1997 · Closed May 13, 1998

Status: closed (inferred from source dates) · Suspension

ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY

Additional source detail variants (2)

Suspension

ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY

Suspension

ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY

PE97035 · Front Suspension Coil Spring Failure

Opened Jul 22, 1997 · Closed Nov 26, 1997

Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs

Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.

EA96024 · Engine Cooling Fan Fires

Opened Sep 30, 1996 · Closed Apr 15, 1997

Status: closed (inferred from source dates) · Engine And Engine Cooling

There is no summary currently available

EA96019 · Headlight Failure

Opened Jul 31, 1996 · Closed Jan 26, 1998

Status: closed (inferred from source dates) · Exterior Lighting

EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.

PE96033 · Engine Cooling Fan Fires

Opened May 2, 1996 · Closed Sep 30, 1996

Status: closed (inferred from source dates) · Engine And Engine Cooling

IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.

PE96018 · Headlights Failure

Opened Mar 5, 1996 · Closed Jul 31, 1996

Status: closed (inferred from source dates) · Exterior Lighting:headlights

There is no summary currently available

DP95004 · Alleged Defective Tie Rods

Opened Aug 8, 1995 · Closed Aug 30, 1995

Status: closed (inferred from source dates) · Unknown Or Other

ALLEGED DEFECTIVE TIE RODS

EA94008 · Broken Tie Rods

Opened Feb 16, 1994 · Closed Feb 27, 1995

Status: closed (inferred from source dates) · Steering

There is no summary currently available

PE93100 · Polycast Road Wheel Cracks

Opened Dec 2, 1993 · Closed Jun 30, 1994

Status: closed (inferred from source dates) · Suspension

There is no summary currently available

PE93058 · Broken Tie Rods

Opened Jun 15, 1993 · Closed Feb 16, 1994

Status: closed (inferred from source dates) · Steering

There is no summary currently available