NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
60 reportsClear category filter154,553 miles · Jul 28, 2005
Electrical SystemParking BrakeService Brakes, Hydraulic
DT: 1992 FORD TAURUS. THE U SHAPED HOUSING THAT HOLDS UP THE ENGINE RUSTED. CONSUMER TOOK VEHICLE TO A MECHANIC, AND THEY TOLD HIM THAT IT WAS AN UNSAFE VEHICLE. THE RIGHT OUTER TIE ROD, ENGINE CRADLE RUSTED. ALSO, THE FRONT, EMERGENCY, SERVICE AND REAR BRAKES WERE NO GOOD, THE KEY BROKEN IN THE IGNITION. THERE WERE…
Read full complaint
DT: 1992 FORD TAURUS. THE U SHAPED HOUSING THAT HOLDS UP THE ENGINE RUSTED. CONSUMER TOOK VEHICLE TO A MECHANIC, AND THEY TOLD HIM THAT IT WAS AN UNSAFE VEHICLE. THE RIGHT OUTER TIE ROD, ENGINE CRADLE RUSTED. ALSO, THE FRONT, EMERGENCY, SERVICE AND REAR BRAKES WERE NO GOOD, THE KEY BROKEN IN THE IGNITION. THERE WERE OTHER PROBLEMS WITH THE VEHICLE. THE CONSUMER ACQUIRED VEHICLE FROM AN AUCTION HOUSE. HE HAD A MECHANIC INSPECT IT, AND FOUND IT WAS BAD. HE TOOK IT BACK THE AUCTION HOUSE AND HE KEPT THE TITLE. CONSUMER BELIEVED THAT THEY MIGHT HAVE TAMPERED WITH THE ODOMETER . THE INCIDENT DATE HE TOOK IT TO THE MECHANIC AND HE REJECTED THE VEHICLE. IT WAS TAKEN BACK TO CAPITAL AUCTION 603-622-9058.*AK
NHTSA ODI #10130517
Mileage unknown · Sep 12, 2003
Service Brakes, HydraulicCrashInjury
WHILE DRIVING ABOUT 65 MPH ON THE HIGHWAY APPLYING THE BRAKE THE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR. THIS CAUSED THE VEHICLE TO STALL AND ANOTHER VEHICLE HIT THE CONSUMER FROM BEHIND. THE DRIVER AND PASSENGER WAS TRANSPORTED BY AMBULANCE. THERE WERE NO FATALITIES. PLEASE PROVIDE DETAILS. *PH
NHTSA ODI #10039902
Mileage unknown · Apr 13, 2002
Service Brakes, HydraulicVehicle Speed Control
MY REAR BRAKE SYSTEM KEEPS COMING APART. THIS FIRST HAPPENED WHILE DRIVING AT 55 M.P.H. AND I HAD TO BRAKE SUDDENLY. I HAD TO DRIVE AROUND VEHICLE IN FRONT OF ME TO AVOUD A CRASH, I HAD A MECHANIC PUT THEM BACK TOGETHER BUT THE PROBLEM KEEPS PERSISTING EVEN THOUGH I HAVE HAD THE BRAKE SYSTEM COMPLETELY REDONE. THE PROBLEM WITH M…
Read full complaint
MY REAR BRAKE SYSTEM KEEPS COMING APART. THIS FIRST HAPPENED WHILE DRIVING AT 55 M.P.H. AND I HAD TO BRAKE SUDDENLY. I HAD TO DRIVE AROUND VEHICLE IN FRONT OF ME TO AVOUD A CRASH, I HAD A MECHANIC PUT THEM BACK TOGETHER BUT THE PROBLEM KEEPS PERSISTING EVEN THOUGH I HAVE HAD THE BRAKE SYSTEM COMPLETELY REDONE. THE PROBLEM WITH MY CRUISE CONTROL IS THAT WHEN I USE IT AND SET IT THE CAR WILL GO THAT SPEED AND AFTER A WHILE WILL INCREASE THE SPEED ON IT'S OWN.I HAVE ALMOST GOTTEN A TICKET BECAUSE OF THIS AND SINCE EVERYTIME I USE IT THIS HAPPENS I HAVE STOPPED USING THE CRUISE CONTROL.*AK
NHTSA ODI #760642
Mileage unknown · Mar 21, 2002
Service Brakes, HydraulicStructureSuspension
CONSUMER STATES RECALL REPAIRS WERE DONE, HOWEVER ON ONE OCCASION WHILE DRIVING CONSUMER COULD HEAR A CRUNCHING NOISE AND WAS TOLD THAT THE FRONT SUBFRAME BOLTS WERE BAD, CONSUMER WAS INFORMED THAT BECAUSE OF THE RECALL WITH THE REAR BOLTS BEING BAD IT CAUSED STRESS TO THE FRONT SINCE THE FRAME IS ALL ONE PIECE, FORD STATED THAT…
Read full complaint
CONSUMER STATES RECALL REPAIRS WERE DONE, HOWEVER ON ONE OCCASION WHILE DRIVING CONSUMER COULD HEAR A CRUNCHING NOISE AND WAS TOLD THAT THE FRONT SUBFRAME BOLTS WERE BAD, CONSUMER WAS INFORMED THAT BECAUSE OF THE RECALL WITH THE REAR BOLTS BEING BAD IT CAUSED STRESS TO THE FRONT SINCE THE FRAME IS ALL ONE PIECE, FORD STATED THAT THIS WAS NOT PART OF THE RECALL AND REPAIRS WOULD BE AT THE CONSUMERS EXPENSE. BRAKES WERE REPLACED. FRONT WHEEL BEARINGS WERE REPLACED. *SLC
NHTSA ODI #8006111
Mileage unknown · Feb 12, 2002
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
WHILE STARTING VEHICLE WHITE SMOKE WAS COMING OUT OF TAILPIPE. HEARD POPPING NOISE, ALSO WATER AND ANTIFREEZE WAS COMING FROM TAILPIPE. TOOK VEHICLE TO DEALER, AND DEALER INDICATED ENGINE HEAD GASKETS WERE BLOWN.*AK BLOWER FAN BLADE HAD TO BE REPLACED. ON SEVERAL OCCASIONS, THE STARTER HAD TO BE REPLACED. CUSTOMER STATES TE…
Read full complaint
WHILE STARTING VEHICLE WHITE SMOKE WAS COMING OUT OF TAILPIPE. HEARD POPPING NOISE, ALSO WATER AND ANTIFREEZE WAS COMING FROM TAILPIPE. TOOK VEHICLE TO DEALER, AND DEALER INDICATED ENGINE HEAD GASKETS WERE BLOWN.*AK BLOWER FAN BLADE HAD TO BE REPLACED. ON SEVERAL OCCASIONS, THE STARTER HAD TO BE REPLACED. CUSTOMER STATES TEMPERATURE GAUGE GOES UP, LOW ON WATER AND LOOSING COOLANT. DEALER REPLACED RADIATOR, WATER PUMP AND SERPENTINE BELT. BRAKES ARE GRINDING. DEALER REPLACED FRONT BRAKES HAD TURNED ROTORS. ON ONE OCCASION, THE THROTTLE POSITIONING SENSOR HAD TO BE REPLACED. *TT
NHTSA ODI #8003937
Mileage unknown · Jan 13, 2002
Engine And Engine CoolingParking BrakeService Brakes, Hydraulic
FOR A CAR WITH SUCH LOW MILEAGE, HAVE HAD TO REPLACE OR FIX SIGNIFICANT NUMBER ITEMS (SERIOUS SAFETY ITEMS INCLUDED!!) THAT FAILED. HOPE MANUFACTURER CAN HELP REIMBURSE COSTS. PER RESEARCH, THESE ITEMS SHOULD NOT BREAK DOWN AT THIS MILEAGE LEVEL! NO SAFETY DEFECT MENTIONED. *AK
NHTSA ODI #756792
Mileage unknown · Feb 23, 2001
Engine And Engine CoolingService Brakes, Hydraulic
WHEN PUTTING ON BRAKES VEHICLE PULLS TO RIGHT, AND MAKES A GRINDING NOISE. TOOK VEHICLE TO DEALER, AND IT WAS MOTOR MOUNTS. *AK
NHTSA ODI #881351
Mileage unknown · Feb 15, 2001
Engine And Engine CoolingService Brakes, Hydraulic
HEAD GASKET FAILED, CONSUMER OWNS TWO OF THESE VEHICLES THAT HAVE HAD THE HEAD GASKET REPLACED. NLM
NHTSA ODI #559715
Mileage unknown · Feb 9, 2001
Service Brakes, HydraulicUnknown Or OtherVehicle Speed Control
WHILE DRIVING 70MPH WITH CRUISE CONTROL ABS BRAKES BECAME STUCK. BRAKE ASSIST FAILED. BRAKES WERE SMOKING. CRUISE CONTROL FAILED TO DISENGAGE. CHECK ENGINE LIGHT CAME ON. ENGINE WOULD REV VERY HIGH. DISCONNECTED CRUISE CONTROL CABLE TO THROTTLE. *AK
NHTSA ODI #880294
Mileage unknown · Dec 19, 2000
Power TrainService Brakes, HydraulicTires
WHEN BRAKES ARE APPLIED WOULD MAKE GRINDING NOISES, LIKE METAL AGAINST METAL. ROTORS WERE VERY BAD. HAD DEEP GROOVES IN THEM. CORDS WERE COMING COMPLETELY THROUGH & OUT OF TIRES. ALSO, BALL BEARS ARE WEARING OUT.
NHTSA ODI #876762
Official recalls
5Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Sep 4, 1991
MANUFACTURING ERRORS BY THE SUPPLIER OF THE LIFTGATE LATCH MECHANISM MAY CAUSE THE SECONDARY PORTION OF THE LIFTGATE LATCH NOT TO FUNCTION. IF THE LATCH IS NOT IN THE PRIMARY LATCH POSITION, THE LIFTGATE COULD OPEN WITHOUT OPERATOR ACTION.
Consequence & remedy
Consequence: IF THE LIFTGATE WERE TO OPEN DURING VEHCILE OPERATION,PASSENGERS OR CARGO COULD FALL FROM THE OPEN LIFTGATE.
Remedy: REPLACE MALFUNCTIONING LIFTGATE LATCHES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14RQ98016 · Front Suspension Spring Breakage
Opened Sep 29, 1998 · Closed Jan 12, 1999
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
FRONT SUSPENSION SPRINGS AY BREAK DUE TO MANUFACTURING CRACHS IN COMBINATION WITH CORROSION.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
PE95026 · Plastic Trim Panel Separation
Opened May 1, 1995 · Closed Aug 31, 1995
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
Illustration