NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
70 reportsClear category filter154,553 miles · Jul 28, 2005
Electrical SystemParking BrakeService Brakes, Hydraulic
DT: 1992 FORD TAURUS. THE U SHAPED HOUSING THAT HOLDS UP THE ENGINE RUSTED. CONSUMER TOOK VEHICLE TO A MECHANIC, AND THEY TOLD HIM THAT IT WAS AN UNSAFE VEHICLE. THE RIGHT OUTER TIE ROD, ENGINE CRADLE RUSTED. ALSO, THE FRONT, EMERGENCY, SERVICE AND REAR BRAKES WERE NO GOOD, THE KEY BROKEN IN THE IGNITION. THERE WERE…
Read full complaint
DT: 1992 FORD TAURUS. THE U SHAPED HOUSING THAT HOLDS UP THE ENGINE RUSTED. CONSUMER TOOK VEHICLE TO A MECHANIC, AND THEY TOLD HIM THAT IT WAS AN UNSAFE VEHICLE. THE RIGHT OUTER TIE ROD, ENGINE CRADLE RUSTED. ALSO, THE FRONT, EMERGENCY, SERVICE AND REAR BRAKES WERE NO GOOD, THE KEY BROKEN IN THE IGNITION. THERE WERE OTHER PROBLEMS WITH THE VEHICLE. THE CONSUMER ACQUIRED VEHICLE FROM AN AUCTION HOUSE. HE HAD A MECHANIC INSPECT IT, AND FOUND IT WAS BAD. HE TOOK IT BACK THE AUCTION HOUSE AND HE KEPT THE TITLE. CONSUMER BELIEVED THAT THEY MIGHT HAVE TAMPERED WITH THE ODOMETER . THE INCIDENT DATE HE TOOK IT TO THE MECHANIC AND HE REJECTED THE VEHICLE. IT WAS TAKEN BACK TO CAPITAL AUCTION 603-622-9058.*AK
NHTSA ODI #10130517
58,000 miles · May 19, 2004
Electrical SystemInjury
MY 1992 FORD TAURUS JUST CUTS OFF; THE 1ST TIME THE CHECK ENGINE LIGHT CAME ON AND IT QUIT. I HAD THE CAR SERVED AND CHECKED. I'D DRIVE APPRX. 60 MILES AND IT WOULD HAPPEN AGAIN, THEN I WAS GOING BACK TO FLORIDA AND IT DID IT AGAIN, SO I TOOK IT TO ORANGE FORD IN ORANGE ,TEXAS AND THEY PUT IT ON THE COMPUTER AND SAID IT WAS FINE…
Read full complaint
MY 1992 FORD TAURUS JUST CUTS OFF; THE 1ST TIME THE CHECK ENGINE LIGHT CAME ON AND IT QUIT. I HAD THE CAR SERVED AND CHECKED. I'D DRIVE APPRX. 60 MILES AND IT WOULD HAPPEN AGAIN, THEN I WAS GOING BACK TO FLORIDA AND IT DID IT AGAIN, SO I TOOK IT TO ORANGE FORD IN ORANGE ,TEXAS AND THEY PUT IT ON THE COMPUTER AND SAID IT WAS FINE BUT THE CHECK ENGINE LIGHT WOULD STILL COME ON AND THE CAR WOULD CUT -OFF, THIS HAPPENED A GOOD HALF A DOZEN TIMES AND I LIMPED INTO BLOUNTSTOWN, FL. WHERE I HAD MY MECHANIC KEITH LEE PUT IT ON THE COMPUTER, HE COULDN'T FIND ANYTHING YET THE CAR CHECK ENGINE LIGHT WOULD COME ON AND THE CAR WOULD JUST QUIT RUNNING. TO MAKE A LONG STORY SHORT THE MAP SENSOR, FUEL FILTER,MAIN BRAIN,THERMOSTAT AND TEMPERTURE SENSOR HAVE ALL BEEN REPLACED AND I MADE IT BACK TO TEXAS. THEN ON APRIL 29TH 2004 I WAS IN TRAFFIC ON HWY 290 TRAVELING ABOUT 45 MILES AN HOUR AND IT JUST QUIT CAUSING ME AND MY PASSENGERS TO LURCH AND I HAD TO RE-START MY CAR. THIS HAPPENED AGAIN WHEN I WAS JUST MOVING THE CAR TO A SHADY PARKING SPOT ON THE 29TH OF APRIL. I'M 60 YEARS OLD AND I ONLY HAVE THE ONE CAR FOR TRANSPORTATION SO IT'S VERY IMPORTANT THAT MY CAR BE MAINTAINED AND I HAVE A CHILTON'S BOOK FOR MY CAR AND INSIST THAT ANYONE WHO WORKS ON MY CAR FOLLOW THE MANUALS INSTRUCTIONS TO A TEE, LIKE DISCONNECTING THE NEGATIVE GROUND BEFORE WORKING ON MY CAR AFTER ALL THE ENGINEERS WHO DESIGNED IT KNOW BEST. WE ARE A FORD FAMILY AND OWN A BRONCO II, AND A FORD F-350 W/ A CUMMIN DIESEL ENGINE AND HAVE HAD NO PROBLEMS WITH THEM, WHICH THE ARE A 1987 & 1986 RESPECTIVELY AND STILL RUNNING WHICH WILL TELL YOU THAT THEY HAVE HAD THE PROPER CARE AND MAINTENENCE.*AK
NHTSA ODI #10072873
137,210 miles · Sep 22, 2003
Electrical System
THE VEHICLE STALLED ALL AROUND TOWN BUT NOT ON THE HIGHWAY. *PH THE STALLING OCCURRED DAILY. NUMBER OF FAILURES WERE TOO NUMEROUS TO COUNT. *SCC POSSIBLE IGNITION PROBLEMS. *JB
NHTSA ODI #10040402
Mileage unknown · Apr 3, 2003
Electrical System
THE CONSUMER EXPRESSED HIS CONCERN OF WHAT HE/SHE FEELS TO BE UNFAIR/DISHONEST TREATMENT GIVEN BY FORD. PER INVOICE, THERE WAS AN ISSUE OR CONCERN ABOUT THE IGNITION COIL(S). THE CONSUMER REQUEST MONEY BACK. MR SCC *JB
NHTSA ODI #10011701
146,000 miles · Mar 18, 2003
Electrical SystemFire
I OWN A 92 FORD TAURUS, AND RECENTLY IT CAUGHT ON FIRE UNDER THE DASH BOARD...I HAVE BEEN DOING RESEARCH ON DEFECTS FOR FORD IGNITION SWITCHES...I HAVE FOUND MANY DOCUMENTS ABOUT CLASS ACTION LAW SUITS FOR OTHER OWNERS OF FORD VEHICLES FROM 1983-1995...I WAS NOT NOTIFIED OF THIS BEING A DEFECT IN MY CAR AND BELIEVE THAT FORD IS …
Read full complaint
I OWN A 92 FORD TAURUS, AND RECENTLY IT CAUGHT ON FIRE UNDER THE DASH BOARD...I HAVE BEEN DOING RESEARCH ON DEFECTS FOR FORD IGNITION SWITCHES...I HAVE FOUND MANY DOCUMENTS ABOUT CLASS ACTION LAW SUITS FOR OTHER OWNERS OF FORD VEHICLES FROM 1983-1995...I WAS NOT NOTIFIED OF THIS BEING A DEFECT IN MY CAR AND BELIEVE THAT FORD IS RESPONSIBLE FOR THE FIRE IN MY DASHBOARD...I WOULD LIKE TO KNOW WHAT IS STILL POSSIBLE FOR RECALLS/DEFECTS AND WHAT CAN BE DONE ABOUT THIS. *JB
NHTSA ODI #10010715
Mileage unknown · Mar 11, 2002
Electrical SystemFire
WHILE PARKED VEHICLE CAUGHT ON FIRE. FIRE DEPT INDICATED IT WAS AN ELECTRICAL FIRE. CONTACT DEALER. *AK
NHTSA ODI #8005312
Mileage unknown · Feb 26, 2002
Electrical SystemVehicle Speed Control
CONSUMER STATES WHEN THE HAZARD LIGHTS BLOW A FUSE, THE CRUISE CONTROL WILL NOT DISENGAGE WHEN BRAKES ARE APPLIED.*AK. CONSUMER STATED CRUISE CONTROL DOES NOT DISENGAGE WHEN BRAKES ARE APPLIED, AND TRIES TO OVER COME BRAKES WITH ACCELERATION.*SLC
NHTSA ODI #8004586
Mileage unknown · Feb 18, 2002
Electrical SystemFire
CAR BURNED UP. *AK
NHTSA ODI #758407
Mileage unknown · Feb 15, 2002
Electrical System
CAR STALLS WITHOUT WARNING. I NOTICED THE PROBLEM WAS PUBLISHED STATING THE IGNITION SYSTEM WAS FAULTY.
NHTSA ODI #9006074
Mileage unknown · Feb 12, 2002
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
WHILE STARTING VEHICLE WHITE SMOKE WAS COMING OUT OF TAILPIPE. HEARD POPPING NOISE, ALSO WATER AND ANTIFREEZE WAS COMING FROM TAILPIPE. TOOK VEHICLE TO DEALER, AND DEALER INDICATED ENGINE HEAD GASKETS WERE BLOWN.*AK BLOWER FAN BLADE HAD TO BE REPLACED. ON SEVERAL OCCASIONS, THE STARTER HAD TO BE REPLACED. CUSTOMER STATES TE…
Read full complaint
WHILE STARTING VEHICLE WHITE SMOKE WAS COMING OUT OF TAILPIPE. HEARD POPPING NOISE, ALSO WATER AND ANTIFREEZE WAS COMING FROM TAILPIPE. TOOK VEHICLE TO DEALER, AND DEALER INDICATED ENGINE HEAD GASKETS WERE BLOWN.*AK BLOWER FAN BLADE HAD TO BE REPLACED. ON SEVERAL OCCASIONS, THE STARTER HAD TO BE REPLACED. CUSTOMER STATES TEMPERATURE GAUGE GOES UP, LOW ON WATER AND LOOSING COOLANT. DEALER REPLACED RADIATOR, WATER PUMP AND SERPENTINE BELT. BRAKES ARE GRINDING. DEALER REPLACED FRONT BRAKES HAD TURNED ROTORS. ON ONE OCCASION, THE THROTTLE POSITIONING SENSOR HAD TO BE REPLACED. *TT
NHTSA ODI #8003937
Official recalls
5Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Sep 4, 1991
MANUFACTURING ERRORS BY THE SUPPLIER OF THE LIFTGATE LATCH MECHANISM MAY CAUSE THE SECONDARY PORTION OF THE LIFTGATE LATCH NOT TO FUNCTION. IF THE LATCH IS NOT IN THE PRIMARY LATCH POSITION, THE LIFTGATE COULD OPEN WITHOUT OPERATOR ACTION.
Consequence & remedy
Consequence: IF THE LIFTGATE WERE TO OPEN DURING VEHCILE OPERATION,PASSENGERS OR CARGO COULD FALL FROM THE OPEN LIFTGATE.
Remedy: REPLACE MALFUNCTIONING LIFTGATE LATCHES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14RQ98016 · Front Suspension Spring Breakage
Opened Sep 29, 1998 · Closed Jan 12, 1999
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
FRONT SUSPENSION SPRINGS AY BREAK DUE TO MANUFACTURING CRACHS IN COMBINATION WITH CORROSION.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
PE95026 · Plastic Trim Panel Separation
Opened May 1, 1995 · Closed Aug 31, 1995
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
Illustration