IllustrationWHILE DRIVING ABOUT 65 MPH AND THE TRANSMISISON MADE A STRANGE NOISE, AND THE LEFT FRONT AXLE LOCKED UP. THE DEALER HAS REPAIRED THE VEHICLE. *AK
1991 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1991 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 16 of 649 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 260 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 116 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports21 fire reports18 injury reports
Power Train complaints
260 reportsWHILE DRIVING THE TRANSMISSION STARTED TO MAKE STRANGE NOISES, AND THE LEFT FRONT AXLE LOCKED UP. DEALER HAS REPAIRED VEHICLE. *AK
I HAVE RECENTLY HAD MY TANSMISSION REPLACED. I WAS INFORMED THAT IT ALLREADY HAD BEEN REPLACED ONCE. I AM EXPERIENCING THE SAME PROBLEMS. THERE IS A HESITATION WHEN I FIRST TAKE OFF, AND SOMETIMES IT ACTS LIKE IT IS COUGHING AT CERTAIN SPEEDS, OR LIKE SKIPPING, IF I LET OF OF THE GAS WHEN IT DOES THAT AND THEN PUSH BACK DOWN I…
Read full complaint
I HAVE RECENTLY HAD MY TANSMISSION REPLACED. I WAS INFORMED THAT IT ALLREADY HAD BEEN REPLACED ONCE. I AM EXPERIENCING THE SAME PROBLEMS. THERE IS A HESITATION WHEN I FIRST TAKE OFF, AND SOMETIMES IT ACTS LIKE IT IS COUGHING AT CERTAIN SPEEDS, OR LIKE SKIPPING, IF I LET OF OF THE GAS WHEN IT DOES THAT AND THEN PUSH BACK DOWN IT USUALLY STOPS. I AM AFTRAID THE TRANSMISSION IS GOING TO GO OUT AGAIN. ALSO WHEN I USE MY OVERDRIVE, IT FEELS REALLY STIFF AT 55, AND DOES THAT SKIPPING THING AGAIN. PLEASE GIVE ME SOME ADVICE. *AK
FRONT AXLES HAVE A RUBBER CUP ON THEM WHICH WEARS OUT AND BREAKS, DIRT ACCUMULATES AND VEHICLE WILL GO INTO NEUTRAL AND THERE WOULD BE NO CONTROL. DEALER NOT CONTACTED, AND PROBLEM STILL EXISTS. *AK
WHILE DRIVING 25 MPH AND WITH 60,00O MILES ON THE VEHICLE TRANSMISSION PREMATURELY FAILED. CAUSE UNKNOWN. *AK
TRANSMISSION SUDDENLY FAILED ON HIGHWAY AT HIGH SPEED; NEEDED TO BE REPLACED/ PAINT IS PEELING FROM ALL LATERAL SURFACES OF CAR DUE TO MANUFACTURERS DEFECT
VEHICLE EXPERIENCED AUTOMATIC TRANSMISSION FAILURE AS STATED IN RECALL LETTER (94M84), HOWEVER IS BEING DENIED REFUND. MJS
WHEN TRAVELING AT 45 MPH CONSUMER NOTICED A GRIDING SOUND COMING FROM TRANSMISSION WHICH WENT COMPELETY OUT. CONSUMER CONTACTED THE DEALER, DEALER STATED TRANSMISSION NEEDED REPLACING. *AK
PLANETARY GEAR WORE OUT. ALSO, A TSB HAS BEEN ISSUED ON VEHICLE. THE DEALER HAS BEEN NOTIFIED. *AK
THE TRANSMISSON COULD NOT BE ENGAGED IN EITHER FORWARD OR REVERSE AND A GRINDING NOISE WAS HEARD. VEHICLE HAD TO BE TOWED. A CHECK WITH REPAIR SPECIALISTS DISLOSES THAT THERE IS AN INHERRANT PROBLEM WITH THESE TRANSMISSON WHICH PRDICATED FORD TO ISSUE A SERVICE BULLETIN IN 1994. THE TRANSMISSION WARRANTEE WAS EXTENDED TO 7 YEARS…
Read full complaint
THE TRANSMISSON COULD NOT BE ENGAGED IN EITHER FORWARD OR REVERSE AND A GRINDING NOISE WAS HEARD. VEHICLE HAD TO BE TOWED. A CHECK WITH REPAIR SPECIALISTS DISLOSES THAT THERE IS AN INHERRANT PROBLEM WITH THESE TRANSMISSON WHICH PRDICATED FORD TO ISSUE A SERVICE BULLETIN IN 1994. THE TRANSMISSION WARRANTEE WAS EXTENDED TO 7 YEARS FROM DATE OF MANUFACTURE OR 60,000.00 MILES. THE REPAIR TOTAL WAS $2400.00 PLUS TOWIING CHARGES. WITH REGARD TO THE CHECK ENGINE LIGHT. WHEN VEHICLE TRAVELS AT SPEED OVER 65 MPG THE CHEKC ENGINE LIGHT COMES ON FOR 20 TO 30 SECONDS AND SHUTS OFF NUMEROUS TIMES. WHEN VEHICLE TRAVELS UNDER 65 THERE IS NO PROBLEM.ALL FLUIDS ARE FILLED, NO OTHER INDICATION OF PROBLEMS. FORD AUTHORIZED DEALERS CANNOT FIX THE PROBLEM.
Official recalls
498V323000 · Structure:frame And Members
Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
97V025000 · Vehicle Speed Control
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
92V065000 · Wheels
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
91V134000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14SQ98008 · Audio System Fires
Opened May 4, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Electrical System
SEE RESUME FOR DETAILS.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
DP91013 · ANTI-LOCK Brakes
Opened Sep 24, 1991 · Closed Jan 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ANTI-LOCK BRAKES
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available