IllustrationWHILE DRIVING AT ANY SPEED VEHICLE LOSES POWER UNTIL VEHICLE REACHES ABOUT 35 MPH, AND THEN IT JERKS WITHOUT ANY PRIOR WARNING. *AK
1991 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1991 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 16 of 649 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 260 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 116 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports21 fire reports18 injury reports
Engine And Engine Cooling complaints
116 reportsWHILE DRIVING AT 30 MPH WITHOUT PRIOR WARNING THE ENGINE HEAD GASKET BLEW OUT AND THE MOTOR MOUNTS ARE BROKE AND NEEDED TO BE REPLACED. WORN OUT FRONT AXLE, AND A/C O-RINGS LEAK. *AK
WAS DRIVING AT 40 MPH, WHEN CAR CLUNKED TO A STOP. THE CAR THEN IMMEDIATELY ACCELERATED TO 80 MPH AND BRAKES WOULD NOT WORK. HAD TO PULL OFF THE ROAD AND THROW CAR INTO PARK TO STOP CAR. ACCORDING TO FORD DEALERSHIP, THE FRONT RIGHT MOTOR MOUNT SNAPPED. THIS CAUSED THE MOTOR TO LIFT UP INTO THE HOOD, SEVERING THE THROTTLE CABLE …
Read full complaint
WAS DRIVING AT 40 MPH, WHEN CAR CLUNKED TO A STOP. THE CAR THEN IMMEDIATELY ACCELERATED TO 80 MPH AND BRAKES WOULD NOT WORK. HAD TO PULL OFF THE ROAD AND THROW CAR INTO PARK TO STOP CAR. ACCORDING TO FORD DEALERSHIP, THE FRONT RIGHT MOTOR MOUNT SNAPPED. THIS CAUSED THE MOTOR TO LIFT UP INTO THE HOOD, SEVERING THE THROTTLE CABLE AND RADIATOR HOSES. ACCORDING TO DEALER, MOTOR MOUNTS COMMONLY GO BAD AND ARE PART OF NORMAL YEARLY MAINTENANCE CHECKS. FUNNY THAT THE PAMPHLET THAT FORD PUTS OUT ON RECCOMMENDED YEARLY MAINTENANCE DOESN'T MENTION THIS ANYWHERE. THE DEALER ALSO SAID THAT THIS WAS NOT RELATED TO THE RECENT RECALL ON ENGINE MOUNTS AND WOULD NOT BE COVERED. REPAIRS WERE DONE INCLUDING THE RECALL, INSURANCE COVERED PART. DEALER REFUSED TO GIVE ITEMIZED REPAIR TICKET TO CUSTOMER AND GAVE NO PROOF THAT RECALL WORK WAS DONE. NOW THE POWER STEERING PUMP IS LEAKING. DEALER SAID WAS OLD LEAK AND NOT CAUSED BY EVENT. NEVER HAD A LEAK BEFORE. IF I HAD BEEN DRIVING AT A HIGHER SPEED, OR EVEN IN A SCHOOL ZONE AT THE TIME, IT WOULD HAVE BEEN MORE DIFFICULT TO STOP. THE DEALER THAT DID THE REPAIRS IS FAMILY AUTO FORD; 6105 E. 38TH ST.; INDIANAPOLIS, IN 46226; PH. 317-545-8551. SERVICE ADVISOR, BENJAMIN BELL WAS VERY RUDE AND UNCOOPERATIVE TO BOTH US AND THE INSURANCE COMPANY AND A COMPLAINT IS FILED WITH FORD. WHEN WE QUESTIONED THE REPAIRS, WE DID NOT GET FAR, AND WERE BLUNTLY TOLD THAT IT WAS ALL CAUSED BY US NOT DOING THE PROPER MAINTENANCE CHECK. HE SAID MOTOR MOUNTS COMMONLY GO OUT WITH NO WARNING AT ALL.
MOTOR MOUNTS REPLACED, REPLACEMENT MOUNTS BECAME LOOSE CAUSING DAMAGE TO THE POWER STEERING AND EXCESSIVE WEAR TO STRUTS.
ENGINE MOUNTS FAILED ON TWO OCCASIONS. FIRST TIME WAS WITHIN 18,000, AND SECOND TIME AT APPROXIMATELY 48,000 . CONSUMER BELIEVED THIS WAS A MANUFACTURER'S DEFECT, AND NEEDED TO BE LOOKED INTO. CAN NHTSA HELP IN THIS MATTER. *AK
MY MOTOR MOUNTS, TIE RODS, AND CV BOOTS WENT BAD. THE MOTOR MOUNTS AND TIE RODS I FEEL WENT OUT WAY TO SOON FOR ANY CAR. THIS CAR WAS GIVEN TLC BEFORE I HAD IT B/C IT WAS MY GRANDMA'S. MY PASSENGER SIDE DOOR LOCKS ARE WORKING IMPROPERLY. THEY ARE EXTREMELY HARD TO OPEN WITH FINGERS. YOU HAVE TO PULL THE DOOR HANDLE FROM THE…
Read full complaint
MY MOTOR MOUNTS, TIE RODS, AND CV BOOTS WENT BAD. THE MOTOR MOUNTS AND TIE RODS I FEEL WENT OUT WAY TO SOON FOR ANY CAR. THIS CAR WAS GIVEN TLC BEFORE I HAD IT B/C IT WAS MY GRANDMA'S. MY PASSENGER SIDE DOOR LOCKS ARE WORKING IMPROPERLY. THEY ARE EXTREMELY HARD TO OPEN WITH FINGERS. YOU HAVE TO PULL THE DOOR HANDLE FROM THE INSIDE USUALLY TO GET IT.
98S36. CONSUMER STATES THE VEHICLE BEING REPAIRED AND DEALER STATES THE ENGINE MOUNTS ARE NOT RELATED TO RECALL. ENGINE IS TILTED. REPAIRWORK IS NOT COVERED IN RECALL. REPAIRS AT OWNERS EXPENSE. PROBLEM STILL EXIST. PROVIDE FURTHER INFORMATION...
DRIVING AT 40 MPH. LOUD CLUNKING NOISE FROM FRONT OF CAR. CAR IMMEDIATELY INCREASED SPEED TO 80 MPH. BRAKES FAILED. CAR STOPPED ONLY BY THROWING INTO PARK. ACCORDING TO DEALER, RIGHT REAR MOTOR MOUNT SNAPPED, TILTING ENGINE FORWARD, SEVERING THROTTLE CABLE. MOTOR ALSO LIFTED UP HOOD RESULTING IN SEVERELY DENTED HOOD. IN PROCES…
Read full complaint
DRIVING AT 40 MPH. LOUD CLUNKING NOISE FROM FRONT OF CAR. CAR IMMEDIATELY INCREASED SPEED TO 80 MPH. BRAKES FAILED. CAR STOPPED ONLY BY THROWING INTO PARK. ACCORDING TO DEALER, RIGHT REAR MOTOR MOUNT SNAPPED, TILTING ENGINE FORWARD, SEVERING THROTTLE CABLE. MOTOR ALSO LIFTED UP HOOD RESULTING IN SEVERELY DENTED HOOD. IN PROCESS OF LIFTING INTO HOOD, ALSO SEVERED RADIATOR HOSES. TOLD BY DEALER THAT MOTOR MOUNTS COMMONLY FAIL WITH NO WARNING TO DRIVER. I WAS LUCKY THAT I COULD STOP THE VEHICLE WITHOUT ANY INJURIES TO MYSELF OR ANYONE ELSE. HAD THIS FAILURE OCCURRED ON A HIGHWAY AT A HIGHER SPEED, I WOULD NOT HAVE BEEN ABLE TO STOP.
ORIGINAL TRANSMISSION WAS FIXED 3 TIMES AND THEN FINALLY REPLACED, ALL UNDER WARRANTY. THE REPLACEMENT TRANSMISSION LASTED ABOUT 70000 MILES, AND THEN HAS HAD THE SAME TYPES OF PROBLEMS, AND HAS BEEN REPLACED. THE FRONT RIGHT MOTOR MOUNT BROKE SEVERAL TIMES AND CONTINUALLY THE TOP BOLT VIBRATES LOOSE. THE MOUNT HAS JUST BEEN REP…
Read full complaint
ORIGINAL TRANSMISSION WAS FIXED 3 TIMES AND THEN FINALLY REPLACED, ALL UNDER WARRANTY. THE REPLACEMENT TRANSMISSION LASTED ABOUT 70000 MILES, AND THEN HAS HAD THE SAME TYPES OF PROBLEMS, AND HAS BEEN REPLACED. THE FRONT RIGHT MOTOR MOUNT BROKE SEVERAL TIMES AND CONTINUALLY THE TOP BOLT VIBRATES LOOSE. THE MOUNT HAS JUST BEEN REPLACED AGAIN. THE FRONT WHEEL ROTORS CONTINUALLY GO BAD, AND HAVE TO BE REPLACED, ESPECIALLY THE RIGHT ONE. *AK
THE CONSUMER NOTICED SMOKE IN THE PASSENGER'S COMPARTMENT. WHEN CONSUMER PULLED OVER TO CHECK THE ENGINE IT WAS AN FIRE AT THE TOP OF DRIVER,S SIDE OF THE ENGINE, CAUSE UNKNOWN. DEALER HAS NOT BEEN CONTACTED. *AK
Official recalls
498V323000 · Structure:frame And Members
Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
97V025000 · Vehicle Speed Control
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
92V065000 · Wheels
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
91V134000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14SQ98008 · Audio System Fires
Opened May 4, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Electrical System
SEE RESUME FOR DETAILS.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
DP91013 · ANTI-LOCK Brakes
Opened Sep 24, 1991 · Closed Jan 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ANTI-LOCK BRAKES
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available