NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
41 reportsClear category filter70,000 miles · Dec 14, 2009
Air BagsElectrical SystemSeat Belts
HOW DO I GET FORD MOTOR COMPANY TO HONOR GENUINE NHTSA RECALLS ON A 1990 FORD TAURUS WAGON??? IT CURRENTLY HAS COMPLAINT # NHTSA 90E043001; NHTSA 98V323000; NHTSA 93V106002; NHTSA 91V34000. I CANNOT GET DEALERSHIP TO REPLACE AIR BAG MODULE DEFECT, SEAT BELT DEFECT OR CPU REPLACEMENT DEFECT. WHAT DO I DO TO GET SOME ACTION ON THE…
Read full complaint
HOW DO I GET FORD MOTOR COMPANY TO HONOR GENUINE NHTSA RECALLS ON A 1990 FORD TAURUS WAGON??? IT CURRENTLY HAS COMPLAINT # NHTSA 90E043001; NHTSA 98V323000; NHTSA 93V106002; NHTSA 91V34000. I CANNOT GET DEALERSHIP TO REPLACE AIR BAG MODULE DEFECT, SEAT BELT DEFECT OR CPU REPLACEMENT DEFECT. WHAT DO I DO TO GET SOME ACTION ON THESE ISSUES???? *TR
NHTSA ODI #10295663
Mileage unknown · Aug 7, 2008
Electrical SystemFire
I HAD A LOOSE IGNITION ON MY 1990 FORD TAURUS IN WHICH I COULD REMOVE MY KEY WHILE IT WAS STILL RUNNING I HAD THIS CHANGED WHILE I WAS HAVING OTHER WORK DONE ON THE CAR AND LESS THEN A WEEK LATER I HAD A VERY EXPENSIVE PAPERWEIGHT BECAUSE AFTER THEY PLACED A NEW IGNITION INTO MY CAR IT CAUGHT FIRE WHILE I WAS DRIVING IT BURNING…
Read full complaint
I HAD A LOOSE IGNITION ON MY 1990 FORD TAURUS IN WHICH I COULD REMOVE MY KEY WHILE IT WAS STILL RUNNING I HAD THIS CHANGED WHILE I WAS HAVING OTHER WORK DONE ON THE CAR AND LESS THEN A WEEK LATER I HAD A VERY EXPENSIVE PAPERWEIGHT BECAUSE AFTER THEY PLACED A NEW IGNITION INTO MY CAR IT CAUGHT FIRE WHILE I WAS DRIVING IT BURNING OUT ALL THE WIRING AND DESTROYING THE WIRES CONNECTED TO MY BATTERY. I TOWED THE CAR TO THE FORD DEALER AND I HAD TO LAY OUT EVEN MORE MONEY FOR THEM TO TELL ME THERE IS NOTHING THEY CAN DO ABOUT IT. THERE HAVE NEVER BEEN ANY FIRES OR RECALLS AND THAT WAS THAT. *TR
NHTSA ODI #10237338
Mileage unknown · Sep 11, 2002
Electrical SystemService Brakes, HydraulicFire
WHILE DRIVING BRAKES LOCKED UP. THEN, A FIRE STARTED UNDER THE HOOD. CAUSE OF THE FIRE HAS YET NOT BEEN IDENTIFIED. PLEASE DESCRIBE DETAILS. *AK
NHTSA ODI #8018381
Mileage unknown · Jan 27, 2002
Electrical SystemEngine And Engine CoolingVisibility
THIS CAR HAS HAD A LOT OF WORK DONE TO IT.IT NEVER WORKS RIGHT. IT HAS HAD OVERHEATING PROBLEMS,THERE HAS BEEN OVER 5000.00 PUT TOWARDS IT TO FIX &IT IS STILL DOING THE SAME THING.I HAVE TAKEN IT TO OVER 5 MECHANICS IN THE PAST 7 MONTHS ALSO THE HEATER HAS NEVER WORKED THE DASHBOARD HAS BEEN TAKEN OUT SEVERAL TIMES TO FIX. I THI…
Read full complaint
THIS CAR HAS HAD A LOT OF WORK DONE TO IT.IT NEVER WORKS RIGHT. IT HAS HAD OVERHEATING PROBLEMS,THERE HAS BEEN OVER 5000.00 PUT TOWARDS IT TO FIX &IT IS STILL DOING THE SAME THING.I HAVE TAKEN IT TO OVER 5 MECHANICS IN THE PAST 7 MONTHS ALSO THE HEATER HAS NEVER WORKED THE DASHBOARD HAS BEEN TAKEN OUT SEVERAL TIMES TO FIX. I THINK THIS CAR IS A LEMON!!!!!!!!!I WILL NEVER PURCHASE A FORD AGAIN. THE MONEY I HAVE SPENT ON THIS CAR SHOULD HAVE BEEN USED AS A DOWN PAYMENT ON ANOTHER ONE.DEFINATELY A LEMON. *AK
NHTSA ODI #757390
Mileage unknown · Aug 17, 2001
Electrical SystemEngine And Engine CoolingUnknown Or Other
VEHICLE STALLS ON HIGHWAY AND WHILE PULLING AWAY FROM A STOP. ENGINE CHECK AND BATTERY LIGHTS COME ON AS A WARNING SIGNS. VEHICLE LOSES ALL STEERING AND BRAKES WHEN IT STALLS. MANUFACTURER IS DOING NOTHING AT THIS TIME TO REMEDY SITUATION. *AK CONSUMER STATES BATTERY WAS CHECKED AND FOUND TO BE IN GOOD CONDITION, HOWEVER BOTH …
Read full complaint
VEHICLE STALLS ON HIGHWAY AND WHILE PULLING AWAY FROM A STOP. ENGINE CHECK AND BATTERY LIGHTS COME ON AS A WARNING SIGNS. VEHICLE LOSES ALL STEERING AND BRAKES WHEN IT STALLS. MANUFACTURER IS DOING NOTHING AT THIS TIME TO REMEDY SITUATION. *AK CONSUMER STATES BATTERY WAS CHECKED AND FOUND TO BE IN GOOD CONDITION, HOWEVER BOTH THE BATTERY AND ENGINE LIGHTS STILL ILLUMINATE, CONSUMER HAS SPENT OVER 1000 DOLLARS IN REPAIRS, AND VEHICLE STILL IS NOT REMEDIED. *SLC
NHTSA ODI #894602
Mileage unknown · Aug 7, 2001
Electrical System
IGNITION SYSTEM FAILURES. *CJ
NHTSA ODI #558839
Mileage unknown · Dec 28, 2000
Electrical SystemEngine And Engine CoolingEquipment
THE EGR SENSOR WAS REPLACED. *SLC
NHTSA ODI #558432
Mileage unknown · Nov 3, 2000
Electrical SystemFire
CONSUMER STATES VEHICLE HAS A THICK FILM IGNITION MODULE INSTALLED ON THE DISTRIBUTOR, WHERE IT WOULD OVERHEAT AND CAUSE VEHICLE TO STALL WHICH RESULTED IN VEHICLE CATCHING ON FIRE AND WAS TOTALED BY THE INSURANCE COMPANY, CONSUMER CONTACTED MANUFACTURER SEVERAL TIMES TO COMPLAIN ABOUT THE INCIDENT AND WAS TOLD BY MANUFACTURER T…
Read full complaint
CONSUMER STATES VEHICLE HAS A THICK FILM IGNITION MODULE INSTALLED ON THE DISTRIBUTOR, WHERE IT WOULD OVERHEAT AND CAUSE VEHICLE TO STALL WHICH RESULTED IN VEHICLE CATCHING ON FIRE AND WAS TOTALED BY THE INSURANCE COMPANY, CONSUMER CONTACTED MANUFACTURER SEVERAL TIMES TO COMPLAIN ABOUT THE INCIDENT AND WAS TOLD BY MANUFACTURER THEY HAD NO INFORMATION ABOUT THE CAUSE OF FIRE
NHTSA ODI #557118
Mileage unknown · Oct 28, 2000
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ON NOVEMBER 20, 1998, I HAD WORK DONE ON MY CAR AT SHEEHY FORD COSTING $1100. THE NEXT DAY THE CAR DIED WHILE BEING DRIVEN ON THE HIGHWAY. KEN REED AT SHEEHY FORD SAID IT WOULD COST $3000 4000 TO REPAIR AN ENGINE BEARING PROBLEM. MY HUSBAND AND I HAD SPENT $4000 FOR CAR REPAIRS IN 1998-ON 2/23 WATERPUMP REPLACEMENT, INSPECTIO…
Read full complaint
ON NOVEMBER 20, 1998, I HAD WORK DONE ON MY CAR AT SHEEHY FORD COSTING $1100. THE NEXT DAY THE CAR DIED WHILE BEING DRIVEN ON THE HIGHWAY. KEN REED AT SHEEHY FORD SAID IT WOULD COST $3000 4000 TO REPAIR AN ENGINE BEARING PROBLEM. MY HUSBAND AND I HAD SPENT $4000 FOR CAR REPAIRS IN 1998-ON 2/23 WATERPUMP REPLACEMENT, INSPECTION OF FUEL SYSTEM HOSES AND TUBES, ON 3/18 FUEL PUMP REPLACEMENT, 6/12 NEW PFE SENSOR, 8/13 REPLACEMENT ALTERNATOR AND REGULATOR,COOLING FAN AND FUSIBLE LINK , 8/14 REPLACED ALTERNATOR AND INTERGRATED CONTROL MODULE, 11/11 OIL CHANGE AND MULTIPOINT INSPECTION AND ON 11/20/98 ANOTHER OIL CHANGE AS WELL AS GASKETS, SEALS, HOSES THERMOSTAT ON THIS DATE. SHEEHY FORD REFUSED TO REIMBURSE ME FOR PART OF THE MONIES SPENT ON 11/20 OR PROVIDE FREE WORK ON OUR OTHER CAR A FORD EXPLORER IN LIEU OF CASH. I CONTACTED MONTGOMERY COUNTY DIVISION OF CONSUMER AFFAIRS, AND THEN, THE STATE OF MARYLAND CONSUMER PROTECTION DIVISION. SHEEHY FORD REFUSED TO ARBITRATE AND NEITHER DIVISION COULD PROVE SHEEHY WAS AT FAULT. I HAD INITIALLY CALLED FORD CUSTOMER SERVICE AND WAS REFERRED TO MY DEALER. AFTER DEALING WITH THE CONSUMER AFFAIRS OFFICES , I WROTE A LETTER TO JAC NASSER, CEO OF FORD. ABOUT 6 WEEKS LATER IN MARCH 1999, I DID GET A CALL FROM A FORD REP WHO REFUSED COMPENSATION BECAUSE I HAD DONATED THE CAR JANUARY 31, 1999 SINCE IT WAS NOT DRIVEABLE. I HAD THE CAR TOWED TO AUTOMATION INC. ON 1/25/99 AND WAS TOLD THE CAR NEEDED NO LESS THAN A CRANK KIT, ESTIMATE $12-15,000. I BELIEVE THAT WHATEVER SHEEHY FORD DID TO MY CAR ON 11/20/98 CAUSED BY CAR TO STOP RUNNING FOREVER ON 11/21. THIS SHOULD NOT HAVE HAPPENED TO A CAR WITH 65,510 MILES THAT WAS WELL TAKEN CARE OF. HAS AN ENGINE BEARING PROBLEM HAPPENED TO ANYONE ELSE?
NHTSA ODI #735355
Mileage unknown · Oct 19, 2000
Electrical System
WHILE COASTING VEHICLE WILL STALL. THERE ARE NO BRAKES OR STEERING WHEN THIS HAPPENS.*AK
NHTSA ODI #873387
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Aug 17, 1992
THE RIGID MOUNTED SAFETY BELT BUCKLES ARE DEFECTIVE IN THREE WAYS. FIRST, A FASTENED SAFETY BELT BUCKLE WILL NOT UNLATCH WHEN THE RELEASE BUTTON IS DEPRESSED. THIS RESULTS FROM INTERFERENCE BETWEEN THE BUCKLE EJECTOR FINGER AND THE BUCKLE TONGUE WINDOW. THE SECOND DEFECT IS THE SAFETY BELT BUCKLE MAY NOT LATCH. THE THIRD POSSIBLE DEFECT IS THAT THE TONGUE MAY BE RETAINED BY THE BUCKLE, BUT IT MAY NOT BE LATCHED SUFFICIENTLY TO PROVIDE OCCUPANT PROTECTION.
Consequence & remedy
Consequence: AN INSUFFICIENTLY LATCHED OR UNLATCHED SAFETY BELTINCREASES THE RISK OF INJURY TO SEAT OCCUPANTS IN THE EVENT OF A SUDDEN STOP ORACCIDENT. IF THE SAFETY BELT BUCKLE WILL NOT UNLATCH, IT WILL NOT ALLOW THEOCCUPANT TO GET OUT OF THE VEHICLE IN AN EMERGENCY SITUATION.
Remedy: FORD WILL REPLACE THE RIGID MOUNTED SAFETY BELT BUCKLES WITH END RELEASE SAFETY BELT BUCKLES DESIGNED TO PREVENT LATCH PROBLEMS.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Aug 28, 1990
WHEELS MAY CONTAIN CRACKS THAT COULD PROPOGATE IN RAISED PORTION OF WHEEL CENTER.
Consequence & remedy
Consequence: UNDER SEVERE DUTY, THIS COULD RESULT IN EVENTUALSEPARATION OF WHEEL RIM FROM CENTER WITH LOSS OF CONTROL AND POSSIBLY ACOLLISION.
Remedy: REPLACE WHEELS WITH WHEELS OF A REVISED DESIGN.
Oct 13, 1989
AN INCORRECT TRANSISTOR MAY CAUSE AUTOLAMP SYSTEM LIGHT SENSOR MODULE MALFUNCTION.
Consequence & remedy
Consequence: HEADLAMPS COULD TURN OFF WHILE VEHICLE IS BEING DRIVEN ORREMAIN ON AFTER VEHICLE IS PARKED. LOSS OF HEADLIGHTS WHILE DRIVING AT NIGHTCOULD BE HAZARDOUS TO THE DRIVER AND OTHER TRAFIFIC.
Remedy: REPLACE LIGHT SENSOR MODULES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
15DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE92044 · Power Steering Leaks/fires
Opened Apr 27, 1992 · Closed Aug 31, 1992
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE92014 · Engine Mount Failure
Opened Feb 4, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA91011 · Seat Belt Buckle Failure
Opened Dec 18, 1990 · Closed Aug 13, 1992
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
EA90045 · Brake Disc Hub Separations
Opened Sep 28, 1990 · Closed Sep 12, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
Additional source detail variants (2)
Service Brakes, Hydraulic
===
Service Brakes, Hydraulic
===
PE90113 · Safety Belt Buckle Locking
Opened Aug 20, 1990 · Closed Dec 18, 1990
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE90104 · Wheel Separation
Opened Aug 2, 1990 · Closed Aug 30, 1990
Status: closed (inferred from source dates) · Wheels:hubcap/cover
There is no summary currently available
Illustration