Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
The contact owns a 2023 Ford Ranger. The contact stated while driving at an undisclosed speed, the vehicle inadvertently decelerated to 40 MPH, and the vehicle then shifted into 4WD-Low independently. As a result of the failure, the vehicle dramatically decelerated and skidded to a complete stop. The 4WD warning light was illumi…
Read full complaint
The contact owns a 2023 Ford Ranger. The contact stated while driving at an undisclosed speed, the vehicle inadvertently decelerated to 40 MPH, and the vehicle then shifted into 4WD-Low independently. As a result of the failure, the vehicle dramatically decelerated and skidded to a complete stop. The 4WD warning light was illuminated. The vehicle was taken to the dealer, who observed water damage to the fuse box which caused electrical failures. The contact was informed that the fuse box needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 10,000.
NHTSA ODI #11651300
Mileage unknown · Jan 27, 2025
Power Train
in normal drive mode the transmission downs shifts thru the gears and skips from 3 to 1. becuase of that skip it feels like you got rear ended by another car. if your not prepared for it you could let off the brakes which could cuase you to hit the person in front. in sport mode it downshifts thru all the 10 gears properly.
NHTSA ODI #11638904
Mileage unknown · Jun 15, 2024
Power Train
Transmission. Hesitates from a stop to highway speeds and hard downshift upon stopping…either controlled or emergency stop. Seems hard to find a gear. Indecisive acceleration. I took it back to Ford and they drove it and said they could not replicate my complaint. No one has inspected it except when I took it back to my dealersh…
Read full complaint
Transmission. Hesitates from a stop to highway speeds and hard downshift upon stopping…either controlled or emergency stop. Seems hard to find a gear. Indecisive acceleration. I took it back to Ford and they drove it and said they could not replicate my complaint. No one has inspected it except when I took it back to my dealership. No warning lamps or issues. There is a definite problem with the shifting and clunking of this transmission. It hesitates & makes a hard noise when stopping. I’m [XXX] and have always bought Fords. This one needs fixed! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11594547
1,000 miles · Oct 24, 2023
Power TrainFire
The contact owned a 2023 Ford Ranger. The contact stated that while driving at an undisclosed speed in tow mode, he heard an abnormal pop emanating from underneath the vehicle, prompting him to pull to the shoulder of the roadway. After a visual inspection, he observed an oil leak, smoke, and a fire near the transmission. Local …
Read full complaint
The contact owned a 2023 Ford Ranger. The contact stated that while driving at an undisclosed speed in tow mode, he heard an abnormal pop emanating from underneath the vehicle, prompting him to pull to the shoulder of the roadway. After a visual inspection, he observed an oil leak, smoke, and a fire near the transmission. Local emergency services were called, and they were able to extinguish the fire. A police and fire report was filed, but no injuries were reported. No warning lights were illuminated. The vehicle was towed to a tow yard and deemed a total loss. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 1,000.
NHTSA ODI #11551701
Mileage unknown · Oct 24, 2023
Electrical SystemEnginePower Train
It is automatic shut down. No power. No light. No door lock……I let it sit after few hours it starts working back. No idea what happen. There is very dangerous when traveling for long way in hot or cold weather.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
Ford Motor Company (Ford) is recalling certain 2023 Bronco and Ranger vehicles. The lug nuts on the driver's side wheels may have been improperly tightened.
Consequence & remedy
Consequence: Loose lug nuts may result in wheel detachment while driving, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect, and if necessary, retighten the lug nuts, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
0
No exact-year investigations in this snapshot.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration