2021 Ford Ranger

The 10R80 10-speed automatic transmission and the gear-shift linkage module are defective, and the truck remains available for inspection. Our safety is constantly put at risk because the transmission exhibits an extremely violent, highly intermittent powertrain lunging jolt during deceleration and stopping. The impact is so severe that it sounds and feels like a loud gunshot firing right next to the cabin occupants. Furthermore, the transmission simultaneously exhibits severe throttle hesitation and gear-skipping. This causes the vehicle to drop gears and completely fail to move when attempting to accelerate at busy stoplights, trapping us as a sitting duck in active traffic. Earlier in our timeline, the technician improperly reassembled the shift linkage, which caused the multi-ton vehicle to refuse to engage in Park and violently roll backward down a steep residential incline; an emergency parking brake deployment was required to prevent a catastrophic accident. The transmission defect was physically confirmed by [XXX] of Papillion, who verified scored, sticking fluid control valves inside the main control unit. Additionally, the hazard was officially confirmed by BBB AUTO LINE National Arbitrator Sharon Katt (Case XXX). The arbitrator officially signed a ruling certifying that our safety, use, and value concerns are completely valid, explicitly noting that the intermittent nature of this transmission failure does not minimize the extreme safety hazard. There were no warning lamps prior to the failure. The symptoms first appeared at ~49,000 miles. The dealer has since refused advanced diagnostics, executed an irrelevant radio reset instead, and willfully fabricated a fake service record on CARFAX on April 21, 2026, to force-close system safety alerts in their database. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Factory Driver's Side Floor Mat does not stay snapped in. This causes the Floor Mat to slide forward towards the pedals. This causes the Floor Mat to lodge underneath the accelerator pedal, which can cause an inability to accelerate. The Fllor Mat could also lodge undermeath the brake pedal, not allowing the full use of the brakes.

2021 Ford Ranger - 10R80 Transmission Failure while driving. Hard shifting, lurching, slipping gears then abrupt failure. It is available. Currently at Diehl Ford in New Brighton, Pennsylvania. - It went from being 90% drivable to coming to complete stop with no transmission engagement at all. Break down occured while climbing a grade and the complete stop happened over a blind crest with guard rails on either side. Leaving myself vulnerable to being struck from behind and another driver having minimal time to see then avoid me or potentially have no where to go but through me. Can I add documents later as I get them?

The contact owns a 2021 Ford Ranger. The contact stated that the vehicle had previously been involved in a crash due to unintended acceleration, which caused the contact to rear-end another vehicle. The vehicle had body and paint repairs performed; however, the vehicle later experienced jerking, and the transmission was seized while driving. The transmission warning light was illuminated. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The dealer confirmed that there was no recall associated with the VIN. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 79,000.

Ford Ranger XLT VIN [XXX] Ford File CAS [XXX] opened 02/08/23 Contact: [XXX], [XXX] Ext [XXX] Acceleration Incidents on trips between Mobile and Dallas. 1. Vehicle purchased March, 2021. Current mileage 6400 +/- 2. In July, 2022, after driving 6 hours at interstate speeds using cruise control, we exited interstate and drove secondary streets to hotel. On entering parking lot we idled toward parking space and I applied brake to slow and throttle went wide open. I braked and shifted to neutral to stop forward motion. No recurrence on remainder of trip to Mobile or in subsequent city driving. 3. On 02/04/23, after driving 6 hours at interstate speeds using cruise control, we exited interstate and drove secondary streets to hotel. On entering parking lot, we paused with engine running to punch in gate number. When gate opened, we idled forwarded toward parking space. I touched brake to slow and throttle went wide open. I applied brakes and shifted into neutral. 4. On 02/05/23, we left hotel and stopped for gas. We drove four hours at interstate speed, intentionally without using cruise control. After exiting interstate, we drove to apartment and stopped at entrance with engine running before idling through parking lot gate. I touched brake to slow and throttle went wide open. Applying brakes did not stop truck and I shifted into neutral and turned off ignition. At least three nearly identical incidents found reported on internet dating from 10/2020, at least one of which Ford opened file on. Dealer Five Star Ford, Dallas, Tx. could not duplicate SUA but did not drive vehicle for 4-6 hours at interstate speeds to duplicate conditions. Ford closed file on warranty claim. Vehicle sold to dealer. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2021 Ford Ranger. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, causing the accelerator pedal to depress simultaneously, due to the brake pedal being positioned very close to the accelerator pedal. While both the brake and accelerator pedals were depressed, it caused the rear tires to squeal and create smoke. The vehicle was taken to the dealer. The dealer informed the contact that there was no failure and that the vehicle was up to specification. The manufacturer was made aware of the failure. The failure mileage was approximately 4,500.

The contact owns a 2021 Ford Ranger. The contact stated that while his wife was pulling into a parking space at approximately 5 MPH with the brake pedal depressed, the vehicle independently accelerated and crashed into the building. The contact stated that there was a camera view which showed that the brake lights were illuminated during the failure. The contact stated that the driver’s side air bag deployed. There were no injuries sustained. The contact was concerned that the Forward Collision Avoidance System failed to operate as designed. The contact stated that there was no warning light illuminated. A police report was filed. The vehicle was towed to the dealer. The contact was informed that the body damage needed to be repaired before a failure cause could be determined. The contact was concerned that if the sensors were replaced prior to the diagnostic test that possible codes would be erased. The vehicle was not repaired. The manufacturer was contacted and informed of the failure. The failure mileage was approximately 3,000.