2021 Ford Ranger

While driving the vehicle started to act like it could not find a its gears in the transmission and made a loud clunk then stopped moving attempted to put it in reverse and it sook a minute before it shifted and made another loud clunk then lost both forward and reverse. Currently at ford getting a new transmission. Vehicle stopped moving while driving and hard to get off the road, No warning lights came on in the vehicle.

Increasingly the transmission, when cold, was experiencing difficulty shifting between 3-4-5 and not shifting into 9-10. When the weather started reaching zero degrees overnight, the vehicle was reluctant to move and, once it began moving, would not shift out of 1st. After allowing the vehicle to warm up, it would reluctantly shift from 3-4-5 and then, without any speed reduction, suddenly downshift with a shudder and bang. Vehicle is in the Ford dealer while they preform the TSB related to this universally known problem with the 10R80 transmission. Despite the TSB “approving” significant part replacements, including clutches, modules and converter, the dealer is required to proceed a few steps at a time and then test the vehicle to document the need to replace more components, before proceeding the the TSB. Ford is avoiding what should be a full recall involving providing the dealers with a rebuilt transmission and converter with the dealer’s responsibility only being the replacement of the transmission. Ford’s dealing with this very well know problematic transmission with a TSB is grossly unfair to the dealers and exceedingly unfair to the consumers who eventually bear the financial burden.

The contact owns a 2021 Ford Ranger. The contact stated that while driving at various speeds, the vehicle hesitated and jerked while depressing the accelerator pedal. The contact stated that at first there were no warning lights illuminated; however, after a while the "Power Train Malfunction - Reduced Power" message was displayed. The dealer and an independent mechanic were notified of the failure and acknowledge that the defect was a common failure. The contact was provided an estimate for a new transmission. The manufacturer was also notified of the failure and the contact was offered financial assistance if the vehicle was serviced by a Ford dealer. The vehicle was not repaired. The failure mileage was approximately 37,000.

Transmission issues that are known to the manufacturer. Backed out onto a road while there was no traffic, shifter into drive and the transmission made a banging noise and refused to shift. Cars started coming in behind me and I was blocking traffic. Was able to get it into neutral then into drive so I could pull away. This is a well known issue to Ford and they have only offered service bulletins that provide temporary fixes until vehicles are out of the factory warranty period and Ford no longer has to cover repair costs. Vehicle only has 50,000 miles and the transmission issues started around 30,000

We love Ford Rangers. This is my 4th. It has been wonderful, until [XXX]. We had to replace an A/C, but that's normal. We've also noticed a very few times that when the transmission shifted, there was a little jolt. But that was rare. But on [XXX], after stopping at a light at the intersection of [XXX] and [XXX] in Indianola, MS., we had a frightening experience. After crossing the busy highway I began to accelerate and suddenly the truck jolted forward and quickly accelerated to 70 mph. I hit the brakes, and after a couple of taps it slowed down. But when I gave it more gas, it only roared twice, and no power...with big trucks beside and behind me. That was frightening. Then it returned to normal, and I went on to Isola, MS. Upon leaving it didn't want to move forward, only roaring, but then quickly responded and was back to normal. I was scheduled for a 12:30 lunch meeting in Leland, MS and my wife and I proceeded. All normal. Upon leaving Leland, same thing. No power at first, then it moved forward, normally. We noticed it was a rough shift at 45 mph as we got out on freeway. I called the service department at Hallmark Ford, Batesville, and told mgr. my problem. Thought it might be fuel pump, filter, or transmission. Upon arrival at home, it wouldn't go in reverse. I sent it to dealer on wrecker. Got second opinion. Both say it needs a new transmission at $8900. My concern is will the new transmission have same problems...reading now on internet of other people who have had similar events. Money matters, but MY CONCERN is the danger this could have inflicted upon us. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 Ford Ranger - 10R80 Transmission Failure while driving. Hard shifting, lurching, slipping gears then abrupt failure. It is available. Currently at Diehl Ford in New Brighton, Pennsylvania. - It went from being 90% drivable to coming to complete stop with no transmission engagement at all. Break down occured while climbing a grade and the complete stop happened over a blind crest with guard rails on either side. Leaving myself vulnerable to being struck from behind and another driver having minimal time to see then avoid me or potentially have no where to go but through me. Can I add documents later as I get them?

I am, yet another of numerous Ford Ranger owners with the same brake issue. I completely concur with the November 3, 2023 complaint (NHTSA ID Number: 11553431) and everything stated in it. I must add that a few times I got pretty scared that I would not be able to stop in time as planned. The brake pedal travels (literally falls) far deep to the floor before ANY, however slight, breaking effort is achieved. Disturbingly, if I don’t keep the brake pedal firmly pressed the truck will move forward!

This is what is going on with my 2021 Ford Ranger automatic 10-speed transmission and the vehicle's drivability. When bringing the vehicle to a stop, the shifting down to a 1st gear is often executed so harshly that I can hear the driveshaft ringing in reaction to the transmission hard shift nearly locking the rear wheels. The whole act resembles "slamming" a shifter into a gear without disengaging a clutch that can be achieved on a standard (stick-shift) transmission "bangs" at a full stop feeling like being rear-ended. After a full stop, the take-off is “sluggish” - The truck gets moving in the 1st gear, the engine revs up to 2500 - 3000 RPM the transmission hesitatingly shifts into 3rd (always skipping 2nd), the noticeable sound of ‘gear grinding’ is heard when the 3rd gear is engaging. The whole process usually takes 2 to 3 seconds, the truck would literally "drift" before any noticeable acceleration is achieved. Lastly, since the day days of ownership, in the area around 2K miles and above, the truck, when the gas pedal is “floored” (ea. on the highway), would get a hard "mallet-like: kick with a significant audible, hard knock somewhere in the drivetrain and at times during this even the "explosion-like" could be heard from the engine compartment making the vehicle shudder.

Truck has hard shifting and loss of power, usually on startup and at low speeds (like in a parking lot) that cause lurching and no response from gas pedal. These events are not reliably repeatable, and result in no dash lights. Sequence of events, start truck, place in reverse, back out of parking spot, place in drive, apply throttle/gas pedal, while driving slowly, car will hard shift, sometimes resulting in a lurch forward, approach exit to parking lot, truck rolls down slight incline of parking lot entrance and throttle is unresponsive to gas pedal, no power, release pedal, wait a second or two, apply pressure and it works. Driving at low speeds in parking lots, truck cannot decide what gear to be in, and sounds horrible, 5-10 mph. Approaching stops on an incline, driving forward, release gas, start to apply brakes, truck will shift and apply power while under braking. Once, pulled in to parking space, backed out to straighten, placed in drive, wrench light came on, no power. Turned the truck on and off again, and that fixed the issue. All incidents between 20k and 40k miles.

The critical level of FUEL DILUTION (Fuel% = 5.5) in the motor oil of this vehicle's 2.3L EcoBoost engine poses a Safety Hazard due to its system's Fuel Leaks and Fire Danger probability existing since the vehicle purchase. I am concerned for the safety of everyone because this vehicle has been evaluated to be a Fire Hazard with 104.5C via ASTM D93 Closed Cup Flash Point. The Motorcraft's Safety Data Sheet (SDS) is listed as >185C. Ford Motor Company (FMC) inspected the vehicle numerous times but safety issues remain. For this reason, I took it out of service and parked at my residence until this problem would be resolved entirely in according with the law. The vehicle mustn't be driven on its power.