IllustrationREAR BUMPER MOUNT FRAME ROT
2003 Ford Ranger
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Ford Ranger do not stand out strongly from the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
630–25K
2225–50K
3050–75K
2075–100K
35100–150K
15150K+
185 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports11 fire reports20 injury reports
What owners actually said
243 reportsHAD A RIGHT REAR SPRING SHACKLE REPLACED FROM BEING BROKEN IN HALF FROM CORROSION OF RUST. AUTO REPAIR SHOP SAID "REAR FRAME RAILS ARE PAPER THIN FROM RUST." "ESPECIALLY THE RIGHT SIDE". THEY TOLD ME THE VEHICLE WOULDN'T PASS INSPECTION EVEN AFTER THE INSPECTION HAD JUST BEEN RENEWED LESS THAN A YEAR AGO. RUST DOESN'T HAPPEN THA…
Read full complaint
HAD A RIGHT REAR SPRING SHACKLE REPLACED FROM BEING BROKEN IN HALF FROM CORROSION OF RUST. AUTO REPAIR SHOP SAID "REAR FRAME RAILS ARE PAPER THIN FROM RUST." "ESPECIALLY THE RIGHT SIDE". THEY TOLD ME THE VEHICLE WOULDN'T PASS INSPECTION EVEN AFTER THE INSPECTION HAD JUST BEEN RENEWED LESS THAN A YEAR AGO. RUST DOESN'T HAPPEN THAT FAST.
THE SPARE TIRE CARRIER(THE SHEET METAL PART THAT IS ATTACHED TO THE FRAME)RUSTED AND FELL OFF THE TRUCK WHILE THE TRUCK WAS GOING DOWN THE ROAD.
WHEN COMING TO A SLOW STOP AT A CITY STREET OR HIGHWAY AT STOP SIGNS AND STOPLIGHTS THE TRUCK STARTS TO ACCELERATE AS I PUSH THE BRAKE. WHEN I APPLY THE BRAKES THE VEHICLE SUDDENLY ACCELERATES TO A HIGH RPM 3500 , PLUS THE TIRES SQUEAL AND 3 PLUS SECONDS LATER I TURN THE KEY OFF BEFORE RESTARTING THE TRUCK. WHEN I RESTART THE TR…
Read full complaint
WHEN COMING TO A SLOW STOP AT A CITY STREET OR HIGHWAY AT STOP SIGNS AND STOPLIGHTS THE TRUCK STARTS TO ACCELERATE AS I PUSH THE BRAKE. WHEN I APPLY THE BRAKES THE VEHICLE SUDDENLY ACCELERATES TO A HIGH RPM 3500 , PLUS THE TIRES SQUEAL AND 3 PLUS SECONDS LATER I TURN THE KEY OFF BEFORE RESTARTING THE TRUCK. WHEN I RESTART THE TRUCK IT SEEMS TO BE OKAY. THIS HAS HAPPED TO ME 4 TIMES, AND SO FAR NO DAMAGE TO PROPERTY OR PERSONS. I HAVE PARKED THE TRUCK AS I FEEL IT IS UNSAFE TO CONTINUE TO DRIVE THE TRUCK. IT IS NOT SAFE TO DRIVE. THE LAST TIME I DROVE IT, I WAS GOING TO A FRIENDS HOME AT A GATED COMMUNITY. AS I TRIED TO STOP TO ENTER TO STOP TO ENTER THE CODE THE TRUCK ACCELERATED AS I BRAKED THE I TURNED THE KEY OFF AND THE TRUCK CAME TO A STOP. I HAVE BEEN FORTUNATE SO FAR THAT I HAVE NOT HIT ANOTHER VEHICLE, OBJECT OR PERSON WHEN THESE INCIDENTS HAVE HAPPENED.
I PURCHASE THIS TRUCK BRAND NEW FROM GENE EVANS FORD IN AUGUST 2003. I STARTED COMPLAINING TO THEM A WEEK LATER THAT THE TRUCK RIDES AS THOUGH MY BUTT IS HITTING THE PAVEMENT ON A TRIP I TOOK. EVERYONE IGNORED MY CONCERN IN THE SERVICE AND SALES DEPARTMENT. WHEN THE PROBLEM WAS FINALLY NOTICE. I WAS SOLD A BRAND NEW TRUCK WITH A…
Read full complaint
I PURCHASE THIS TRUCK BRAND NEW FROM GENE EVANS FORD IN AUGUST 2003. I STARTED COMPLAINING TO THEM A WEEK LATER THAT THE TRUCK RIDES AS THOUGH MY BUTT IS HITTING THE PAVEMENT ON A TRIP I TOOK. EVERYONE IGNORED MY CONCERN IN THE SERVICE AND SALES DEPARTMENT. WHEN THE PROBLEM WAS FINALLY NOTICE. I WAS SOLD A BRAND NEW TRUCK WITH A SEVERE BENT AXLE AND THEY WOULD NOT DO ANYTHING TO REPAIR THE TRUCK NOR GIVE ME ANOTHER ONE. THEY ALL PLAYED DUMB AND STUPID AS TO NEVER SEEING THE PROBLEM IN THE BEGINNING. FORD STILL OWES ME RESTITUTION. DEALERSHIP SHOULD NOT BE ABLE TO DEFRAUD THE PUBLIC ON DAMAGE VEHICLES PAYING A FORTUNE FOR JUST TO KILL YOU OR SOMEONE ELSE. GENE EVANS KNEW THERE WAS A PROBLEM FROM THE ONSET. THERE HAS BEEN A LOT OF PROBLEMS WITH THIS TRUCK IN THE PAST, PRESENT AND MOST LIKELY IN THE FUTURE CONSIDERING THE REPAIRS THAT HAS ALREADY BEEN PUT INTO THE TRUCK OUT OF MY POCKET. MY VEHICLE DOES EVERTHING IN ALL MOTION AND NO MOTION AT ALL. DANGEROUS THINGS HAPPENS INCLUDING, CUTTING OFF CONSTANTLY, LIGHTS ARE DIM ON THE OUTSIDE SO IT IS VERY HARD TO SEE AT NIGHT,RAIN COMING IN THE REAR WINDOW, TRUCK STARTED SMOKING, FILLED THE RESERVOIR AND OVER FLOWED SPEWING THE ANTIFREEZE ALL OVER THE ENGINE. IT SOUNDED LIKE FOOD WAS FRYING IN VERY HOT GREASE. THERE IS A STINKING ODOR, SMELLS LIKE VERY STRONG URINE . SICKENING FEELING COMES OVER ME AND ANYONE IN THE TRUCK.ABS AND CHECK ENGINE LIGHTS WILL NOT GO OFF. THE PASSENGER WINDOW IS MOVING SLOW AS THOUGH IT IS GOING TO STOP. TRUCKS JUMPS WHICH CAUSING ME TO BOUNCE UP AND DOWN WHILE IDLING OR AT A STOP.
MY WIFE GOT A 2003 FORD RANGER FX4 LAST YEAR. AS WE LOOKED IT OVER WE NOTICE SOME BUBBLING RUST UNDER THE PAINT. THE DEALER SAID HE WOULD PAINT IT IF WE GOT THE TRUCK. OK SO HE DID AND IT LOOKED GOOD. A FEW MONTHS LATER I STARTED TO NOTICE MORE BUBBLING. LAST WEEK I WAS DRIVING IT AND I HEARD SOMETHING LIKE A THUMP, I LOOKED IN …
Read full complaint
MY WIFE GOT A 2003 FORD RANGER FX4 LAST YEAR. AS WE LOOKED IT OVER WE NOTICE SOME BUBBLING RUST UNDER THE PAINT. THE DEALER SAID HE WOULD PAINT IT IF WE GOT THE TRUCK. OK SO HE DID AND IT LOOKED GOOD. A FEW MONTHS LATER I STARTED TO NOTICE MORE BUBBLING. LAST WEEK I WAS DRIVING IT AND I HEARD SOMETHING LIKE A THUMP, I LOOKED IN THE MIRROR AND SAW THE SPARE TIRE IN THE MIDDLE OF THE ROAD. I PULLED OVER AND PUT THE SPARE IN THE BED. WHEN I GOT HOME I LOOKED UNDER THE TRUCK AND NOTICED THE SPAIN TIER AREA WAS TOTALLY ROTTED OUT. YESTERDAY I PULLED INTO THE DRIVEWAY AND HEAR A SQUEAKING NOISE. I LOOKED AROUND AND NOTICED THAT THE FRONT PASSENGER CORNER OF THE BED WAS HANGING. I LOOKED AT THE AREA AND WHAT HELD THE BED UP WAS TOTALLY ROTTED OUT. WE ARE NOW AFRAID TO DRIVE THE TRUCK!!! WHAT CAN WE DO? *TR
ENTERING THE TRUCK I LEANED BACK WHILE GETTING SEAT BELT ON. SEAT SUPPORT BROKE CAUSING THE SEAT TO FALL BACK AGAINST THE BACK SEATS. VEHICLE WAS STATIONARY, THANK GOODNESS.
ENTIRE FRAME RUSTED OUT. WON'T PASS INSPECTION. OBVIOUSLY AN ONGOING PROBLEM. DRIVER SIDE BEHIND CAB TO BUMPER VERY BAD. IT IS ACTUALLY ALLTHE WAY INTO.WE GOT IT ON A LINE OF CREDIT. WE ARE OUT OF 5000.00 . REST OF TRUCK IS REALLY NICE
REAR HALF OF FRAME EXCESSIVE CORROSION. FRAME, SPRING MOUNTS, SPARE TIRE RACK AND MAIN FRAME MEMBERS RUSTED AWAY AFFECTING STRUCTURAL INTEGRITY. CORROSION IS SIGNIFICANTLY WORSE THAN WOULD BE EXPECTED FOR THIS AGE VEHICLE. REAR SPRING MOUNTS DANGEROUSLY CORRODED.
THIS IS MY SECOND RANGER. THE FIRST(1998) I HAD AN ACCIDENT IN,THE SEAT BELT NEVER EMPLOYED, I RECEIVED CONCUSSION, I HAVE NOTICED THE SAME WITH THIS 2003 RANGER, SEAT BELT WILL NOT STAY TIGHT, OR EMPLOY WHEN JERKED ON.STATIONARY.
Official recalls
109V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05066 · Brake Lights Inoperative
Opened Dec 5, 2005 · Closed Mar 24, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.