IllustrationWHILE DRIVING THE ENGINE FAILED. *NM THE DEALER INFORMED THE CONSUMER THAT NOTHING COULD BE DONE. FORD HAD ISSUED A RECALL ON THE 3.0 ENGINE, BUT THE CONSUMER SUGGESTED THAT MAYBE THIS PROBLEM PERTAINED TO THE 4.0 ENGINE AS WELL. *SC *JB
2003 Ford Ranger
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Ford Ranger do not stand out strongly from the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
630–25K
2225–50K
3050–75K
2075–100K
35100–150K
15150K+
185 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports11 fire reports20 injury reports
What owners actually said
243 reportsTHE AIR BAG LIGHT CONTINUOUSLY ILLUMINATED ON THE DASHBOARD. AS A RESULT, AIR BAGS WERE INOPERATIVE, AND WOULDN'T DEPLOY WHEN NEEDED. DEALERSHIP INSPECTED AND FIXED THE AIR BAGS THREE TIMES. HOWEVER, THE PROBLEM RECURRED TWICE. *AK *NM
THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED WHILE DRIVING. *MR THE DEALER REPLACED THE PRE-TENSIONER AND RETRACTOR CIRCUIT. *NM
WHILE DRIVING AT 55 MPH VEHICLE LOST POWER. THIS PROBLEM OCCURRED SIX TIMES. ELECTRICAL INERTIA SWITCH WAS DEFECTIVE. DEALER REPLACED THE SWITCH ONCE, AND NEEDS TO BE REPLACED AGAIN. *AK
DRIVE LINE BINDING, HAS BEEN IN FOR REPAIRS THREE TIMES. FIRST TIME THEY WHERE UNABLE TO FIX IT. 2ND TIME THE DRIVE LINE WAS REPLACED. 3RD TIME SPINDLE WAS GREASED, STILL HAVE THE SAME PROBLEM. *AK
WHILE DRIVING AIR BAG LIGHT ILLUMINATED AND STAYED ON THE REMAINDER OF THE TIME THAT VEHICLE WAS BEING OPERATED. THE DEALERSHIP TRIED TO REPAIR VEHICLE TWICE, BUT SAME PROBLEM RECURRED. *AK
WHEN THE VEHICLE IS SHIFTED INTO REVERSE ENGINE REVS. DEALER EXAMINED THE VEHICLE AND REPROGRAMMED THE COMPUTER OF THE ENGINE. NOT LONG AFTERWARDS THE VEHICLE WAS AT A STOP LIGHT AND SURGED FORWARD, NEARLY CAUSING A COLLISION.*AK *MR
WHEN COMING TO A STOP WITH FOOT PRESSED ON BRAKE PEDAL VEHICLE CONTINUED TO ROLL. CONSUMER HAD TO PUMP THE BRAKES REAL FAST TO GET VEHICLE TO STOP. DEALER STATED CONSUMER WAS PRESSING GAS AND BRAKE PEDALS AT THE SAME TIME. THE DRIVER DID NOT AGREE. *AK
WHILE PULLING OUT OF THE DRIVEWAY AT LOW SPEEDS FRONT AIR BAGS INADVERTENTLY DEPLOYED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
2003 FORD RANGER WAS PURCHASED BY THE POLICE DEPARMENT AS A UTILITY TRUCK. ON 2 SEPARATE OCCASIONS, WITH 2 DIFFERENT POLICE OFFICERS DRIVING THE TRUCK, THE VEHICLE SUDDENLY ACCELERATED EVEN THOUGHT BOTH POLICE OFFICERS REPORT THEY HAD THEIR FOOT OFF THE ACCELERATOR AND ON THE BRAKE. THE FIRST INCIDENT OCCURED 2/24/04 AND TH…
Read full complaint
2003 FORD RANGER WAS PURCHASED BY THE POLICE DEPARMENT AS A UTILITY TRUCK. ON 2 SEPARATE OCCASIONS, WITH 2 DIFFERENT POLICE OFFICERS DRIVING THE TRUCK, THE VEHICLE SUDDENLY ACCELERATED EVEN THOUGHT BOTH POLICE OFFICERS REPORT THEY HAD THEIR FOOT OFF THE ACCELERATOR AND ON THE BRAKE. THE FIRST INCIDENT OCCURED 2/24/04 AND THE TRUCK WAS TAKEN TO THE DEALER. THEY WERE UNABLE TO DUPLICATE THE PROBLEM BUT REPLACED THE THROTTLE BODY. THE NEXT INCIDENT OCCURRED 3/11/04. DIFFERENT POLICE OFFICER HAD MULTIPLE INCIDENTS WHERE THE TRUCK SURGED FOREWARD EVEN THOUGH FOOT WAS OFF ACCELERATOR AND ON THE BRAKE. THE VEHICLE WAS AGAIN TAKEN TO THE LOCAL DEALER AND ONCE AGAIN THE MECHANICS WERE UNABLE TO DUPLICATE THE PROBLEM BUT DID REPLACE A VALVE ASSEMBLY- THROTTLE AIR BYPASS. THE VEHICLE HAS 4000 MILES ON IT.*AK
Official recalls
109V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05066 · Brake Lights Inoperative
Opened Dec 5, 2005 · Closed Mar 24, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.