NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
39 reportsClear category filter82,350 miles · Mar 23, 2008
Engine And Engine Cooling
A PLASTIC WATER HEATER CONTROL VALVE IN THE VEHICLE COOLING SYSTEM DENATURED AND CRUMBLED, LEAKING COOLANT OUT OF THE VEHICLE WHICH COULD HAVE CAUSED AN ENGINE SEIZURE HAD I NOT BEEN AWARE OF THE SITUATION. THIS IS THE SECOND PLASTIC PART FAILURE (FIRST WAS THE THERMOSTAT/TEMP SENSOR HOUSING) WHICH FAILED AND LEAKED COOLANT DUR…
Read full complaint
A PLASTIC WATER HEATER CONTROL VALVE IN THE VEHICLE COOLING SYSTEM DENATURED AND CRUMBLED, LEAKING COOLANT OUT OF THE VEHICLE WHICH COULD HAVE CAUSED AN ENGINE SEIZURE HAD I NOT BEEN AWARE OF THE SITUATION. THIS IS THE SECOND PLASTIC PART FAILURE (FIRST WAS THE THERMOSTAT/TEMP SENSOR HOUSING) WHICH FAILED AND LEAKED COOLANT DURING THE WARRANTY INTERVAL. COOLING SYSTEMS ARE NO PLACE FOR PLASTIC PARTS. *TR
NHTSA ODI #10222065
Mileage unknown · Dec 27, 2007
Engine And Engine Cooling
I BOUGHT A 2002 FORD RANGER IN APRIL OF 2006 AND NOW THERE SEEMS TO BE AN ISSUE WITH THE OIL PRESSURE SENSOR ON THE ENGINE FAILING THE SENSOR CAUSES THE GAUGE TO "TWITCH" I BOUGHT THE VEHICLE WITH THIS UNKNOWN DEFECT HAS THERE BEEN A RECALL ON THIS MATTER? I HAVE VISITED SOME ON LINE BULLETIN BOARDS AND IT SEEMS TO BE A COMMON …
Read full complaint
I BOUGHT A 2002 FORD RANGER IN APRIL OF 2006 AND NOW THERE SEEMS TO BE AN ISSUE WITH THE OIL PRESSURE SENSOR ON THE ENGINE FAILING THE SENSOR CAUSES THE GAUGE TO "TWITCH" I BOUGHT THE VEHICLE WITH THIS UNKNOWN DEFECT HAS THERE BEEN A RECALL ON THIS MATTER? I HAVE VISITED SOME ON LINE BULLETIN BOARDS AND IT SEEMS TO BE A COMMON DEFECT. *TR
NHTSA ODI #10212924
1 miles · Oct 26, 2007
Air BagsEngine And Engine CoolingSeat Belts
SEAT BELT NEVER STAYS CONNECTED ( POPS OUT) ALL SPEEDS. (5 YRS) I ASKED DEALER ABOUT FIXING HE SAID MY WARRANTY EXPIRED BUY A NEW ONE (FORD DOES NOT CARE ABOUT SAFETY AFTER WARRANTY DATE) THE AIRBAG LIGHT WILL STAY ON FOR A WEEK THEN OFF FOR A MONTH THEN REPEAT ( 5 YRS) DOOR AJAR LIGHT HAS NEVER TURNED OFF (MAYBE IT WILL BURN …
Read full complaint
SEAT BELT NEVER STAYS CONNECTED ( POPS OUT) ALL SPEEDS. (5 YRS) I ASKED DEALER ABOUT FIXING HE SAID MY WARRANTY EXPIRED BUY A NEW ONE (FORD DOES NOT CARE ABOUT SAFETY AFTER WARRANTY DATE) THE AIRBAG LIGHT WILL STAY ON FOR A WEEK THEN OFF FOR A MONTH THEN REPEAT ( 5 YRS) DOOR AJAR LIGHT HAS NEVER TURNED OFF (MAYBE IT WILL BURN OUT SO I DON'T SEE IT ANYMORE) TAILGATE LATCH REPLACED 3 TIMES ( DANG THAT CHEAP PLASTIC) FRONT END REALIGNED NUMEROUS TIMES (ANTI NASCAR, ALWAYS TURNS RIGHT) ENGINE SHUDDERS BAD FEW TIMES A YEAR(BAD GAS MAYBE ONCE, OTHERS PROBABLY NOT) COIL PACK REPLACED TWICE (IM STILL UNDER 60,000 MILES) REAR WINDOW LEAKS ALSO :) *TR
NHTSA ODI #10207043
45,000 miles · May 11, 2006
Engine And Engine CoolingFire
I OWNED A 2002 FORD RANGER WITH 45,000 MILES ON IT. MY DAUGHTER WAS DRIVING IT AND CAME TO A STOP AT AN INTERSECTION AFTER EXITING AN EXPRESSWAY. BLACK SMOKE STARTED COMING OUT OF THE ENGINE COMPARTMENT. WITHIN 10 MINUTES, THE TRUCKS ENGINE COMPARTMENT AND COCKPIT WERE COMPLETELY ENGULFED IN FLAMES AND THE TRUCK WAS DESTROYED…
Read full complaint
I OWNED A 2002 FORD RANGER WITH 45,000 MILES ON IT. MY DAUGHTER WAS DRIVING IT AND CAME TO A STOP AT AN INTERSECTION AFTER EXITING AN EXPRESSWAY. BLACK SMOKE STARTED COMING OUT OF THE ENGINE COMPARTMENT. WITHIN 10 MINUTES, THE TRUCKS ENGINE COMPARTMENT AND COCKPIT WERE COMPLETELY ENGULFED IN FLAMES AND THE TRUCK WAS DESTROYED. *JB
NHTSA ODI #10157274
66,941 miles · Dec 9, 2005
Engine And Engine Cooling
DT: THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY THE #3 SPARK PLUG BLEW OUT OF THE ENGINE. THE VEHICLE WAS TOWED TO A MECHANIC. CONTACTED THE MANUFACTURER, AND THE CONTACT WAS TOLD THIS PROBLEM WAS NOT COVERED UNDER WARRANTY. REPAIRS WILL BE MADE AT THE CONTACT'S EXPENSE. AK
NHTSA ODI #10144870
Mileage unknown · Feb 2, 2005
Engine And Engine Cooling
CONSUMER WAS DRIVING APROXIMATELY 10 MPH, AND WHILE MAKING A RIGHT TURN, THE VEHICLE STALLED. CONSUMER LOST CONTROL OF STEERING AND BRAKES. *AK
NHTSA ODI #10109640
10,000 miles · Dec 24, 2004
Engine And Engine Cooling
SINCE ABOUT 10,000 MILES MY ENGINE HAS MADE A CRACKLING NOISE UNDER ACCELERATION. 'VE TALKED TO MANY OTHER RANGER OWNERS WHO ARE HAVING THE SAME PROBLEM. SOME OF THEM SAID THEY TOOK THEIR TRUCKS TO A DEALERSHIP AND THE SERVICE DEPARTMENT SAID THE NOISE WAS FROM THE TIMING IN THE ENGINE AND THE PROBLEM COULD NOT BE FIXED. IT W…
Read full complaint
SINCE ABOUT 10,000 MILES MY ENGINE HAS MADE A CRACKLING NOISE UNDER ACCELERATION. 'VE TALKED TO MANY OTHER RANGER OWNERS WHO ARE HAVING THE SAME PROBLEM. SOME OF THEM SAID THEY TOOK THEIR TRUCKS TO A DEALERSHIP AND THE SERVICE DEPARTMENT SAID THE NOISE WAS FROM THE TIMING IN THE ENGINE AND THE PROBLEM COULD NOT BE FIXED. IT WAS TO MY UNDERSTANDING THAT IF A AUTOMOTIVE COMPANY MAKES A MISTAKE AND IT IS NOT EASILY REPAIRABLE AND IS FREQUENT THERE SHOULD BE A RECALL SO THE PROBLEM COULD BE FIXED. I'M GOING TO SELL MY TRUCK IN THE SPRING BECAUSE OF THIS PROBLEM. I HAVE NO IDEA IF THIS TIMING PROBLEM WILL HAVE ANY LONG TERM EFFECT ON THE ENGINE ITSELF BUT I DO NOT WANT TO WAIT AROUND AND SEE SINCE FORD ONLY OFFERS A 3 YEAR 36,000 MILE WARRANTY AND I HAVE 45,000 MILES ON MY TRUCK.*AK
NHTSA ODI #10104460
5,000 miles · Apr 22, 2004
Engine And Engine CoolingSuspension
INTERMITTENTLY WHILE DRIVING THERE WAS VIBRATION IN THE REAR END OF THE VEHICLE. TIRES WERE ROTATED 4 TIMES, BUT THE VIBRATION STILL OCCURRED. ALSO, AT 5,000 MILES, COOLING FAN BEARING/HUB SQUEAKED BECAUSE OF MOISTURE BUILD UP. THE FAN BELT WAS REPLACED. SQUEAKING NOISE RECURRED AT 10,000 MILES. DEALERSHIP LUBRICATED THE FA…
Read full complaint
INTERMITTENTLY WHILE DRIVING THERE WAS VIBRATION IN THE REAR END OF THE VEHICLE. TIRES WERE ROTATED 4 TIMES, BUT THE VIBRATION STILL OCCURRED. ALSO, AT 5,000 MILES, COOLING FAN BEARING/HUB SQUEAKED BECAUSE OF MOISTURE BUILD UP. THE FAN BELT WAS REPLACED. SQUEAKING NOISE RECURRED AT 10,000 MILES. DEALERSHIP LUBRICATED THE FAN BELTS. BUT, THE SQUEAKING NOISE RECURRED AT 35,0000. THE FAN BELT NEEDED TO BE REPLACED AGAIN. *AK
NHTSA ODI #10068686
Mileage unknown · Apr 8, 2004
Engine And Engine Cooling
INTERMITTENTLY WHILE DRIVING 35 MPH VEHICLE STALLED.VEHICLE WAS TOWED TO THE DEALERSHIP AND KEPT FOR TWO DAYS, BUT COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK *MR
NHTSA ODI #10061566
6,643 miles · Feb 27, 2004
Engine And Engine CoolingLatches/locks/linkagesPower Train
TRUCK PULLS TO THE RIGHT ESPECIALLY AT HIGHWAY SPEEDS. AT TIMES SEVERE VIBRATION AND RUBBING NOISE. SAFETY DEFINETLY AN ISSUE WHEN DRIVING VEHICLE. MORE RECENTLY 4X4 ENGAGED & TRUCK TILTED TO FRONT RIGHT AND MADE LOUD GRINDING NOISE, COULD ONLY DRIVE 5MPH OR SO. PUT IN REVERSE AND WAS ABLE TO DRIVE IT AT HIGHWAY SPEEDS BUT STIL…
Read full complaint
TRUCK PULLS TO THE RIGHT ESPECIALLY AT HIGHWAY SPEEDS. AT TIMES SEVERE VIBRATION AND RUBBING NOISE. SAFETY DEFINETLY AN ISSUE WHEN DRIVING VEHICLE. MORE RECENTLY 4X4 ENGAGED & TRUCK TILTED TO FRONT RIGHT AND MADE LOUD GRINDING NOISE, COULD ONLY DRIVE 5MPH OR SO. PUT IN REVERSE AND WAS ABLE TO DRIVE IT AT HIGHWAY SPEEDS BUT STILL PULLS, VIBRATES AND IS GETTING WORSE. NOW, A OIL LEAK FOUND. ALSO, ANTI LOCK BRAKES ARE LOCKING UP. FAN MOTOR COOLER NOT WORKING CORRECTLY. *AK
NHTSA ODI #10059089
Official recalls
3Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Feb 4, 2002
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration