Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 109 of 576 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports29 fire reports34 injury reports
What owners actually said
576 reports
Mileage unknown · Jan 22, 2004
Vehicle Speed Control
CONSUMER STATED THAT WHILE DRIVING DOWN THE HIGHWAY AND ATTEMPTING TO MAKE A STOP VEHICLE FAILED TO STOP. CONSUMER PUT VEHICLE IN NEUTRAL, TURNED IT AROUND, AND WENT BACK HOME. AT HOME CONSUMER RAISED THE HOOD AND DISCOVERED THAT THE THROTTLE CABLE SEPARATED. CONSUMER WAS SCARED BECAUSE HE WAS TRAVELING ABOUT 45-50 MPH. *…
Read full complaint
CONSUMER STATED THAT WHILE DRIVING DOWN THE HIGHWAY AND ATTEMPTING TO MAKE A STOP VEHICLE FAILED TO STOP. CONSUMER PUT VEHICLE IN NEUTRAL, TURNED IT AROUND, AND WENT BACK HOME. AT HOME CONSUMER RAISED THE HOOD AND DISCOVERED THAT THE THROTTLE CABLE SEPARATED. CONSUMER WAS SCARED BECAUSE HE WAS TRAVELING ABOUT 45-50 MPH. *AK
NHTSA ODI #10055700
32,000 miles · Jan 21, 2004
Interior Lighting
DOOR WAS AJAR AND LIGHT CAME ON INTERMITTENTLY. IT WAS REPAIRED ONCE, BUT HAS RECURRED. *AK
NHTSA ODI #10055617
43,000 miles · Jan 15, 2004
Power Train
FRONT WHEEL DRIVE INTERMITTENT EVEN WHEN 4X4 LIGHT IS ON AND 4X4 SWITCH IS ENGAGED. MOST NOTABLE WHEN BELOW OUTSIDE TEMPERATURES ARE 30 DEGREES FAHRENHEIT AND BELOW. MULTIPLE FORD DEALERS HAVE TRIED BUT CANNOT DUPLICATE CONDITION. THIS CONDITION IS INCREASING IN FREQUENCY AND HAS CREATED SOME DANGEROUS DRIVING SITUATIONS DUE TO…
Read full complaint
FRONT WHEEL DRIVE INTERMITTENT EVEN WHEN 4X4 LIGHT IS ON AND 4X4 SWITCH IS ENGAGED. MOST NOTABLE WHEN BELOW OUTSIDE TEMPERATURES ARE 30 DEGREES FAHRENHEIT AND BELOW. MULTIPLE FORD DEALERS HAVE TRIED BUT CANNOT DUPLICATE CONDITION. THIS CONDITION IS INCREASING IN FREQUENCY AND HAS CREATED SOME DANGEROUS DRIVING SITUATIONS DUE TO LACK OF TRACTION WHEN DRIVER THOUGHT 4WD SYSTEM WAS ENGAGED. *CB
NHTSA ODI #10054215
Mileage unknown · Dec 22, 2003
Power TrainCrash
VEHICLE'S DRIVE SHAFT BROKE RESULTING IN LOST OF CONTROL. *MR *SC *JB
NHTSA ODI #10052182
46,200 miles · Dec 19, 2003
Suspension
PASSENGER SIDE LOWER CONTROL ARM JOINT GREASE PROTECTOR HAS DETERIORATED ALLOWING MOISTURE AND DIRT TO ENTER THE JOINT.*AK
NHTSA ODI #10050773
Mileage unknown · Dec 10, 2003
Steering
THE DAY AFTER PURCHASING THE VEHICLE, (1998 FORD RANGER) THE CONSUMER HAD TO GET THE RACK AND PINION STEERING CHANGED. (SEE ODI NUMBER 10052130 FOR CONSUMER COMPLAINT REGARDING 2002 FORD ESCAPE).*MR *CB *JB
NHTSA ODI #10051805
185,000 miles · Nov 14, 2003
Steering
VEHICLE WAS MAKING A LEFT HAND TURN WHEN THE STEERING COLUMN CAME APART. DRIVER THEN SLAMMED ON THE BRAKES UNTIL VEHICLE CAME TO A STOP. *AK
NHTSA ODI #10048017
65,000 miles · Nov 5, 2003
Interior Lighting
WHILE DRIVING AT NIGHT, THE DRIVER WAS UNABLE TO SEE THE ASHTRAY BECAUSE VEHICLE DID NOT HAVE A LIGHT NEAR THE ASHTRAY. OWNER HAS CONTACTED THE DEALERSHIP.*AK THE DEALERSHIP HAD NO OPTION TO ADD A LIGHT TO THE ASHTRAY. THE CONSUMER PURCHASED LED LIGHTS AND INSTALLED THEM HIMSELF. CONSUMER FEELS ANY VEHICLE EQUIPPED WITH AN …
Read full complaint
WHILE DRIVING AT NIGHT, THE DRIVER WAS UNABLE TO SEE THE ASHTRAY BECAUSE VEHICLE DID NOT HAVE A LIGHT NEAR THE ASHTRAY. OWNER HAS CONTACTED THE DEALERSHIP.*AK THE DEALERSHIP HAD NO OPTION TO ADD A LIGHT TO THE ASHTRAY. THE CONSUMER PURCHASED LED LIGHTS AND INSTALLED THEM HIMSELF. CONSUMER FEELS ANY VEHICLE EQUIPPED WITH AN ASHTRAY SHOULD HAVE LIGHTING TO MAKE IT VISIBLE. *PH *JB
NHTSA ODI #10042520
Mileage unknown · Oct 24, 2003
Electrical System
WHEN TRYING TO START THE VEHICLE ANTI THEFT DEVICE WOULD ACTIVATE, CAUSING THE VEHICLE NOT TO START. DRIVER CONTACTED DEALERSHIP. *AK A TECHNICIAN DISABLED THE RELAY. *TS *NLM
NHTSA ODI #10042313
Mileage unknown · Sep 10, 2003
Service Brakes, Hydraulic
BRAKE PEDAL FELL OFF WHILE PULLING OUT OF THE PARKING LOT. THERE WERE NO INJURIES TO REPORT.CONSUMER WAS ABLE TO STOP THE VEHICLE. BY APPLYING THE EMERGENCY BRAKE.*AK
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.
Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.
Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE99045 · Steering Knuckle Separations
Opened Jul 6, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1998 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration