IllustrationVEHICLE WAS HIT FROM THE REAR AT A STOP LIGHT AND SEATBACK AUTOMATICALLY RECLINED, FALLING BACK UPON IMPACT. DEFECT CAUSED CONSUMER TO GO THROUGH BACK OF WINDSHIELD. CONSUMER SUSTANED HEAD INJURIES. *AK
1996 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 1996 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 80 of 413 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports18 fire reports30 injury reports
What owners actually said
413 reportsWHILE PULLING AWAY FROM A STOP FRONT WHEELS : RIM BASE ON DRIVER'S SIDE SPLIT RIGHT DOWN THE MIDDLE, CAUSING FRONT END OF TRUCK TO FALL TO THE GROUND. TRUCK WAS TOWED TO DEALERSHIP. RIM WILL BE REPLACED AT OWNER'S EXPENSE. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
I DON'T UNDERSTAND HOW AFTER 4 YEARS OF OWNING THE VEHICLE WITH ONLY 45,000 MILES ON IT THAT THE CARRIER BEARING WAS SHOT. I WAS ALSO TOLD THAT BY THE MECHANIC, WHO WAS ALSO TOLD THAT BY THE DEALERSHIP WHEN HE CALLED TO REPLACE THE PART. IF IT IS A MANUFACTURER DEFECT I WOULD REALLY APPRECIATE KNOWING.. THANK YOU. *AK
VEHICLE HAS A BAD HEADLIGHT SWITCH. SWITCH HAS TO BE JIGGLED AROUND TO GET THE LIGHTS TO COME ON. ALSO, WHEN HIGH BEAMS ARE ACTIVATED THE LIGHTS GO OUT COMPLETELY. DEALER HAS BEEN CONTACTED. *AK
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
FIRESTONE FR 480 MTS P22570R14NTS TIRES FAILED, ONE PUNCTURED AND REPAIRED HOWEVER 3,000 MILES LATER THE TREAD SEPARATED, REMOVED TIRE 2 FROM TIRE RACK UNDER BED AND NOTICED SPARE TIRE SIDEWALL DAMAGED DUE TO STORAGE. *MJS
WHILE DRIVING DOWN THE ROAD AND ALL OF A SUDDEN LOST ALL POWER AND VEHICLE STALLED. CONTACTED DEALER. *AK
DRIVING ON INTERSTATE @ APPROX 60 MPH WHEN THE ENGINE QUIT RUNNING, ACTTED LIKE A WIRE HAD BURNT INTO BECAUSE THE ENGINE STOPPED AND RAN INTERMITTENT ABOUT 3 TIMES. *AK
INTERIOR LIGHT STAYS ON WHILE DRIVING. IF DRIVING AT NIGHT IT MAY CAUSE A REFLECTION ON THE WINDSHIELD AND VISUAL DIFFICULTY WHICH COULD RESULT IN A CRASH. COMMON PROBLEM. DEALER SAYS THAT THIS IS A DESIGN FLAW THAT NEEDS TO BE CORRECTED. *AK.ET.
WHILE DRIVING ON A NARROW TWO-LANE ROAD, I PROCEEDED TO PASS ANOTHER VEHICLE. I ACCELERATED AND KICKED THE TRUCK INTO PASSING GEAR. THE THROTTLE WENT TO THE WIDE OPEN POSITION AND WOULD NOT RELEASE. I USED THE BRAKES TO FIGHT THE OUT OF CONTROL ENGINE AND VEHICLE. I PROCEEDED DOWN THE CURVY FOR 3 TO FOUR MILES UNTIL I GOT TO…
Read full complaint
WHILE DRIVING ON A NARROW TWO-LANE ROAD, I PROCEEDED TO PASS ANOTHER VEHICLE. I ACCELERATED AND KICKED THE TRUCK INTO PASSING GEAR. THE THROTTLE WENT TO THE WIDE OPEN POSITION AND WOULD NOT RELEASE. I USED THE BRAKES TO FIGHT THE OUT OF CONTROL ENGINE AND VEHICLE. I PROCEEDED DOWN THE CURVY FOR 3 TO FOUR MILES UNTIL I GOT TO A PULLOUT PLACE WHERE I APPLIED THE BRAKES SO HARD THAT IT KILLED THE ENGINE. THE BRAKES WERE DOWN TO NO PADS, WERE VERY HOT, AND COOKED OUT GREASE THAT CAUGHT ON FIRE. I RESTARTED THE ENGINE AT WHICH TIME THE THROTTLE WAS NO LONGER STUCK IN THE WIDE OPEN POSITION. *AK
Official recalls
209V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.